2005 TOYOTA TUNDRA Complaints

QUOTED FOR ALMOST 4000 TO FIX THIS MANIFOLD AIR INJECTION MANIFOLD. RESEARCHED ONLINE AND FOUND OUT IT TO BE A COMMON PROBLEM WITH THIS CAR DUE DEFECT. I DON'T UNDERSTAND WHY THEY RECALLED 2007 AND NEWER BUT NOT THE OLDER ONES WHICH SEEMS TO HAVE THE SAME PROBLEM. I HOPE YOUR AGENCY CAN ASSIST US WITH THIS ISSUE. *TR

DASH LIGHT "CHECK ENGINE" CAME ON AND WHEN THE DEALER INFORMED ME THAT IT WAS THIS EMISSION CONTROL SYSTEM LISTED ABOVE ( SECONDARY AIR INJECTION SYSTEM SWITCHING VALVE NO. 2 BANK 1 AND BANK 2) THAT WOULD COST OVER $3,000 I WENT ONLINE AND SAW MANY TUNDRAS AND SEQUOIAS WITH EXACTLY THE SAME PROBLEM AND THAT THE 2007 TO 2009 TUNDRAS WITH THE EXACT PART NUMBERS WERE WARRANTED FOR 10 YEARS, IT TELLS ME THIS IS A KNOWN PROBLEM, SO WHY IS THERE NOT A RECALL? *TR

2005 TOYOTA TUNDRA. CONSUMER WRITES IN REGARDS TO AIR INDUCTION PUMP DESIGN FLAWS *TGW THE CONSUMER STATED ACCORDING TO THE MECHANIC'S REPORT, THE SECOND AIR PUMP, SECONDARY AIR SWITCHING VALVE, BANK 1 AND BANK WERE REPLACED. THEY WERE ALL CLOGGED WITH INSULATION FOAM AND STUCK TO THE VALVE SEATS WHICH KEPT THE VALVES OPEN. THE SECONDARY AIR INLET WAS ALSO REPLACED, DUE TO THE HOSE BEING HARD BECAUSE OF THE HEAT UNDER THE INTAKE MANIFOLD, WHICH ALSO CONTRIBUTED TO THE ENGINE NOT BEING ABLE TO COOL PROPERLY. FURTHER RESEARCH ABOUT AIR INDUCTION PUMP DESIGN FLAWS ON TOYOTA VEHICLE REVEALED A NATIONWIDE PROBLEM AFFECTING TUNDRA'S UP UNTIL THE 2010 MODEL.

THE CARGO/CENTER HIGH MOUNT BRAKE LIGHT HOUSING MELTED ABOVE EACH CARGO LAMP. THE PLASTIC HOUSING MELTED AND DRIPPED DOWN ON TO THE BULBS, CAUSING THE BULBS TO CRACK AND BECOME INOPERATIVE. THE FUSE PROTECTING THE CARGO LAMP CIRCUIT DID NOT BLOW, CAUSING CONCERN THAT THERE MAY BE A FIRE HAZARD. *TR

I GOT INTO TRUCK TO DRIVE AND HAD NO BRAKES. THEY HAD "GONE" OUT OVERNIGHT. THE TRUCK WAS TOWED TO DEALER AND WE FOUND OUT THAT A BRAKE LINE HAD RUSTED OUT. LESS THAN THREE MONTHS LATER THE SAME THING HAPPENDED AGAIN. NOW IT IS AN ADDITIONAL TWO LINES THAT HAVE RUSTED OUT. TOYOTA IS TELLING US THAT ITS NORMAL AND NOT UNEXPECTED FOR THIS TO HAPPEN WITH A TRUCK THAT HAS ALMOST 50,000 MILES ON IT. IN ADDITION, SINCE THERE ARE SEVERAL BRAKE LINES ON THE TRUCK, THE OTHERS COULD GO AT ANY TIME. THIS IS AN EXTREME SAFELY HAZARD AS THE BRAKES COULD STOP WORKING AT ANYTIME THE TRUCK IS DRIVEN.

TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT WAS DRIVING 45 MPH WHEN THE VEHICLE FAILED TO INCREASE SPEED AFTER THE ACCELERATOR PEDAL WAS DEPRESSED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE DEALER CONFIRMED THAT THE PUMP ASSEMBLY AIR SWITCH NEEDED TO BE REPLACED. THE MANUFACTURER WAS CONTACTED BUT THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 57,500 AND THE CURRENT MILEAGE WAS 57,700.

AFTER STOPPING AT A RED LIGHT. MADE RIGHT TURN UPHILL. TRUCK ACCELERATED QUICKLY LIKE IT WAS FLOORED. ATTEMPTED TO BRAKE EASILY TO SLOW DOWN. TRUCK SPUN 180 ON PAVEMENT, CRASHING SIDEWAYS INTO ISLAND DIVIDER. RIGHT REAR WHEEL WAS SHEERED OFF. TRUCK WAS STOPPED BY REAR BUMPER SMASHING INTO LIGHT STANDARD. SHEERED WHEEL HAD GRIND MARKS AS WHEELS WERE STILL UNDER POWER. THIS WAS POINTED OUT AT SCENE BY LAW ENFORCEMENT. I AM A RETIRED FIREFIGHTER USED TO DRIVING EMERGENCY EQUIPMENT. MY TRUCK ACCELERATED ON ITS OWN. *TR

TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT STATED THAT THE EMERGENCY BRAKE WAS MALFUNCTIONING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO DIAGNOSED THAT THE FAILURE WAS DUE TO CORROSION AND THE PARKING BRAKE NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 47,500 AND THE CURRENT MILEAGE WAS 47,972. THE VIN WAS NOT AVAILABLE.

MY 2005 TOYOTA TUNDRA HAS A LEAKING EXHAUST MANIFOLD. ON THE WAY HOME FROM THE HARDWARE STORE MY NEW CO DETECTOR WENT OFF INDICATING CO IN THE CABIN. I HAVE CONTACTED THE DEALER AND THE MANUFACTURER AND THEY REFUSE TO REPAIR. *KB

TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT STATED THE CHECK ENGINE LIGHT ILLUMINATED AND THE VEHICLE WOULD BECOME RESISTANT WHEN DRIVING UPHILL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE A DIAGNOSTIC TEST SHOWED A FAULTY TRANSMISSION SOLENOID. THE DEALER STATED THAT THE ENTIRE TRANSMISSION WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 91,000.