2004 TOYOTA TUNDRA Complaints

THE T BRACKET THAT HOLDS SPARE TIRE UP UNDER BED OF TRUCK BROKE DUE TO EXCESSIVE RUST DROPPING SPARE TIRE OUT ON ROAD AT 30 MPH...VERY UNSAFE TO SAY THE LEAST. ALSO, FRONT TORSION BAR FRAME MOUNT PASSENGER SIDE HAS BROKEN OFF FRAME DUE TO EXCESSIVE RUST. 2 INCH BY 5 INCH HOLE IN THE FRAME BOTTOM AT THIS LOCATION. *TR

AUTOMATIC TRANSMISSION COLUMN SHIFT PROBLEM OF THE 2004 TOYOTA TUNDRA TOYOTA TUNDRA. THERE IS A SERIOUS PROBLEM WITH THE STEERING COLUMN HOUSING SUPPORT. AFTER STARTING THE VEHICLE AND SUBSEQUENTLY ATTEMPTING TO SHIFT THE GEAR INTO REVERSE , THE GEAR SHIFT LEVER BROKE FREE AT THE STEERING COLUMN. I WAS ABLE TO STOP THE VEHICLE. ABLE TO PARK THE VEHICLE, BUT WAS UNABLE TO SHIFT INTO ANY OTHER GEAR. THE CONSUMER STATED IT APPEARED THE CAST ALUMINUM COMPONENTS SUPPORTING THE TRANSMISSION SHIFT LEVER APPEARED TO BE FLAWED. THERE IS ONLY 81 THOUSAND ON THIS TRUCK. UNSAFE !!!!!!!!! THANK GOD IT DIDN'T BREAK AT 65 MPH ! BUT IT COULD HAVE ! *TR

TOOK MY TRUCK IN FOR AN OIL CHANGE AT THE LOCAL TOYOTA DEALER. AFTER THE ROUTINE INSPECTION THEY TOLD ME THE TRUCK WAS UNSAFE TO DRIVE DUE TO HOLES GREATER THAN 10MM FOUND IN THE FRAME CAUSED BY SEVERE RUST. TOYOTA HAS SAID THE 04 MODEL IS NOT PART OF THE RECALL, AND I APPEAR TO BE IN LIMBO. THIS ISSUE IS STILL UNRESOLVED.THE TRUCK WILL NEED NEW FRAME AND COMPONENTS FOR IT TO BE ROAD WORTHY AGAIN. *TR

TL* THE CONTACT OWNS A 2004 TOYOTA TUNDRA. THE CONTACT STATED THAT POWER STEERING FLUID WAS LEAKING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE RACK AND PINION WAS DEFECTIVE. IN ADDITION, HE STATED THAT WHILE HE WAS INSPECTING THE VEHICLE HE NOTICED THAT THE FRAME WAS CORRODED AND THE CROSS MEMBERS WERE FRACTURED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 178,000.

ON 9/27/13 WHEN MY 2004 TUNDRA WAS BEING CHECKED OUT FOR A RECALL FOR SEVERE FRAME RUST THE RI TOYOTA DEALER BROUGHT TO MY ATTENTION THE REAR DIFFERENTIAL WAS ROTTED THROUGH AND LEAKING OIL AND SAID THAT THIS RUST IS NOT COVERED BY RECALL. THE WHOLE AXLE HAS TO BE REPLACED. MY QUESTION TO YOU IS, SHOULDN'T TOYOTA BE RESPONSIBLE FOR ALL THE SUB-STANDARD STEEL? SHOULDN'T THIS BE UNDER A SAFETY RECALL FOR OIL LEAKAGE? AS FAR AS I KNOW THE OIL LEAK CANNOT BE FIXED W/O COMPLETE AXLE HOUSING REPLACEMENT AND THIS IS A PROBLEM THAT EFFECTS A HUGE # OF TUNDRAS. *TR

I RECENTLY NOTICED A LEAK UNDER THE REAR OF THE VEHICLE. UPON INSPECTION, THE DIFFERENTIAL WAS FOUND TO BE RUSTED RIGHT THROUGH AND LEAKING. I EXAMINED THE FRAME AS WELL AND NOTICED SEVERE RUSTING IN VARIOUS PLACES ON THE FRAME. I NEVER RECEIVED A NOTICE OF RECALL ON THE FRAME. APPARENTLY THERE IS NOT ONLY FRAME DAMAGE TO MANY TUNDRAS, BUT ALSO TO NECESSARY WORKING PARTS. I HAVE NEVER HAD AN AXLE ROT OUT ON ANY OF MY CARS AND BECAUSE OF THE INABILITY TO SIMPLY REPAIR A SEAL, THE ENTIRE AXLE WILL NEED REPLACING? SEEMS A BIT EXTREME. I LIKE THE TUNDRA AND WILL BASE MY DECISION TO REMAIN A CUSTOMER ON HOW I'M TREATED IN THE RECALL APPOINTMENT. *TR

THE 2004 AND EARLIER TOYOTA TUNDRA HAS HAD MAJOR CORROSION ISSUES AND FRAME RECALLS. MY TUNDRA WAS JUST INSPECTED BY THE LOCAL TOYOTA DEALER AND MAJOR CORROSION WAS NOTED ON THE VEHICLE FRAME. TOYOTA APPLIED A FIBERGLASS BASED RUSTPROOFING TO THE FRAME. HOWEVER, THEY WOULD NOT ACKNOWLEDGE ANY OTHER CORROSION OR ROT ON THE VEHICLE. MY VEHICLES MOTOR MOUNTS ARE SO CORRODED THAT I AM AFRAID THAT THE ENGINE WILL FALL OUT OF THE VEHICLE. ALSO, THE MOUNTS THAT HOLD THE RADIATOR ARE SO CORRODED THEY ARE ALMOST GONE. THERE ARE NUMEROUS OTHER AREAS IN THE ENGINE COMPARTMENT AND UNDERCARRIAGE THAT ARE COMPLETELY CORRODED. THE VEHICLE IS UNSAFE TO DRIVE AND TOYOTA WILL NOT ADDRESS IT. *TR

THERE IS EXTENSIVE CORROSION DAMAGE TO ALL METAL FITTINGS AND METAL FUEL AND HYDRAULIC LINES. THE REAR AXLE IS SEVERELY CORRODED AND LEAKING OIL THROUGH THE CASTING REQUIRING REPLACEMENT. THERE IS A FUEL LINE FAILURE NEXT TO THE EXHAUST MANIFOLD. THE CORROSION DAMAGE TO THE STEERING SYSTEM FITTINGS REQUIRES REPLACEMENT OF THE RACK ASSEMBLY ALTHOUGH THE SYSTEM OPERATES PROPERLY. THERE IS CORROSION DAMAGE TO MANY OF THE SUSPENSION CONNECTION POINTS TO THE FRAME INCLUDING REAR SPRINGS. DEALER DEEMS THE VEHICLE UNSAFE IN IT'S CURRENT CONDITION AND RECOMMENDS IT BE SOLD FOR SALVAGE. THERE IS LITTLE TO NO CORROSION DAMAGE TO THE BODY THAT CAN BE SEEN FROM A VISUAL UNDERSIDE INSPECTION AND VEHICLE LOOKS IN EXCELLENT CONDITION FROM THE OUTSIDE. VEHICLE WAS DEALER MAINTAINED PER THE MANUFACTURER'S MAINTENANCE SCHEDULE.

WHILE DRIVING THE SPARE TIRE FELL OFF OF THE TRUCK DUE TO A BADLY RUSTED SPARE TIRE WENCH, AS I LOOKED UNDER THE TRUCK TO SEE IF THEIR WAS ANY OTHER DAMAGE I NOTICED A LOT OF RUST ON THE FRAME. MOST NOTABLY AROUND THE SUSPENSION. *TR

TL* THE CONTACT OWNS A 2004 TOYOTA TUNDRA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, THE SPARE TIRE DISLODGED FROM THE SPARE TIRE WELL AND ONTO THE ROAD. THE FAILURE WAS CONTRIBUTED TO THE UNDER CARRIAGE BEING EXCESSIVELY CORRODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 80,000. THE VIN WAS UNAVAILABLE.