2005 TOYOTA TUNDRA Complaints

The driver's side front frame has rotted out disconnecting the mount for the anti-roll bar. This has happened despite several reports to the dealership going back many years that the frame was rusting rapidly which, upon examination, they said that it was OK. They did apply a coating which might have delayed the process a bit but ultimately resolved nothing. For trucks that had perforated frames during the first few years, they replaced the frame. I tried to take care of mine, but it has finally failed and they say the replacement program is over. They are unwilling to provide even the necessary frame section and mounting bracket for the sway bar (~$545) for the frame shop to install %(2120).This vehicle has less than 98,000 miles on it and is used for short trips performing farmette duties. Frame failure can cause catastrophic accidents and should not be ignored by the manufacturer regardless of age. They know they used bad steel and should act accordingly. My action has been delayed by storm damage to frame shop which didn't reopen until December.

The contact owns a 2005 Toyota Tundra. The contact stated while performing a routine inspection, the contact noticed that the subframe was rusted on the front and the rear suspension of the vehicle. The vehicle was taken to the dealer and the mechanic stated that the vehicle had a spray-on coating however, the vehicle was rusted and the subframe needed to be replaced. The vehicle was not replaced. The manufacturer was not contacted. The failure mileage was 60,000.

******* DELETE VOQ ******* THIS COMPLAINT IS BEING MARKED FOR DELETION BECAUSE THE CONSUMER PLACED THE REQUEST.*DJR ******* DELETE VOQ *******

i recently purchased the 2005 Tundra I was instructed to take the Tundra to Westbury Toyota for inspection and they didnt even took at the truck they claimed according to the VIN is not eligible for any consideration from Toyota North North America The frame has recessive deterioration. We understand the truck doesnt have lifetime warranty but I am disappointed in Toyota's response

The frame is rusted, luckily a mechanic caught it in time, it’s not road worthy.

I own a 2005 Toyota Tundra 4dr. and in January of this year 2022 a recall was sent out on ‘Inadequate Hardness of Ball Joint Housing’. My Tundra is having ball joint problems meaning skeeking on the front wheels, vibrating until over 55 mph., and suspension problems. I called a Toyota dealership to get the truck fixed but they told me that back in 2007 the ball joints were already fixed. I shouldn’t be having this problem if the recall just came out. I’m trying to get this problem corrected on my truck without having to pay the $900 bill they want to charge me to fix it. Whst can I do ??

The contact owns a 2005 Toyota Tundra. The contact stated that while his son was driving at an undisclosed speed, the driver’s side air bag was inadvertently deployed without warning. There was no impact to the vehicle to cause the driver’s side air bag to deploy. The vehicle was taken to the dealer where the manufacturer sent a field technician to inspect the vehicle. The contact was not made aware of the diagnosis. The manufacturer was made aware of the failure and informed the contact that the hot weather conditions caused the air bag to deploy. The failure mileage was approximately 64,000.

Front left wheel fell off. What component or system failed or malfunctioned, and is it available for inspection upon request? FRONT LEFT WHEEL. YES, AVAILABLE FOR INSPECTION How was your safety or the safety of others put at risk? WHEEL FELL OFF Has the problem been reproduced or confirmed by a dealer or independent service center? YES. TOWED TO SHOP; THEY AGREED THAT FRONT LEFT WHEEL FELL OFF. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? CAPITOL BODY SHOP, RIDGELAND, MS Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? UKNOWN. VEHICLE HAS MADE NOISE OFF AND ON, BUT WHETHER DUE TO THIS I CANNOT SAY. PLEASE NOTE: THIS VEHICLE WAS SUBJECT TO Recall Number 07V013000 Recall Date 01/19/2007 lOWER BALL JOINT. THIS VEHICLE HAD THAT SERVICE DONE IN LAS VEGAS NEVADA AT APPROX 12,500 MILES. WHAT FAILED WAS THE FIXED/REPAIRED/REPLACED JOINT. ALL

The contact owns a 2005 Toyota Tundra. The contact stated his wife was driving on the highway at approximately 40 MPH when she hit a patch of ice and spun out of control crashing into an embankment on the rear driver side. As a result, the rear driver side tire was pushed back out of place about an inch and a half causing the control arm to become bent. The air bags did not deploy. The wife was not injured. A police report was filed. The vehicle was able to be driven from the scene. The vehicle was not diagnosed or repaired. A dealer was not contacted. The vehicle was currently being repaired at a body shop for cosmetic repairs. The manufacturer was not notified of the failure. The failure mileage was 215,000

I believe my Toyota frame is rusted. The truck has 56,000 miles. The front wheel has a noticeable problem with the camber - it can not be driven safely.