2007 TOYOTA TUNDRA Complaints

The contact owns a 2007 Toyota Tundra. The contact stated the door locks were inoperative. There were no warning lights illuminated. The vehicle was taken to several independent mechanics to be diagnosed. The contact was informed that the subframe needed to be replaced. Additionally, the contact was informed that the driveshaft was defective and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 167,000.

I have been involved in two rear end accidents that i pressed the brake down with no response and ended up in a minor accident going less than 10 miles per hour each time. Also my running lights stop working and have had 4 wheel drive get stuck in that position until i had to look at the book to free it but no longer use it

Dear NHTSA , I have a major safety concern regarding the frame of my 2007 Toyota Tundra Limited. My truck has only 128,665 miles on it, and it's pristine, except for the fact that the frame is rusted away, to the point where it needs to be replaced. I noticed last week that one of my straps holding up my gas tank was hanging, and my tank was near the ground. I brought it to my mechanic, and he said that the strap was fine, the strap was rotted off my frame. He said that the frame is in such dire shape that I was lucky that my truck didn't fall apart while driving it, and that I'm lucky the gas tank didn't drag on the highway, causing a catastrophic event. Upon researching this, I found that Toyota Corporation was aware of this major safety issue. Toyota evidently replaced quite a lot of these defective frames due to rust issues, but a recall was never sent out to all Toyota Tundra owners. I just spoke to someone at Toyota's Corporate office, and the person told me that there was nothing that Toyota could do for me, except say that they are sorry. How can such an important safety issue with these Toyota Tundra frames not trigger a recall? Is there anything that the NHSTA can do to make Toyota correct this hazardous safety issue and problem? A formal recall should have been sent out. How many more Tundra owners are still driving around with this major life safety problem, that they are unaware of? Please help me, Toyota needs to do more than just say 'sorry'. If there something that you can do? If not, where do I turn next? Respectfully, [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Suddenly, I discovered that my fuel tank showing as if it's about to drop on the ground. As I inspected, the fuel tank rear strap broke off the frame due to corrosion. the strap itself was not the issue, part of the corroded frame was still attached to the strap. When I took the truck to my local Mechanic, further inspection showed worse signs of corrosion in the entire frame and in every part connected to the frame as well; suspension parts, brake parts, emergency brake parts, spare tire hinge; etc. Against my disagreement with Toyota dealership, I had the truck painted by Toyota as they recommended during the frame recall in February of 2018. I wanted to replace the frame, based on other professionals advice, but Toyota Dealership insisted that my truck frame is in good shape it ONLY needs the paint recommended by Toyota. I come to find out that they have not remove nor clean any rust and they painted on top of it. Additionally, They never painted the cross members above the tank Now, when I looked under the truck, the paint has coming off in greater areas of the frame showing heavy rust under it. Which means the paint job was a joke, and worthless. Now, after seeing this, I am wondering how can I possibly drive this truck. The tank can drop any time or the spare tire latch can break off, causing a disaster on a highways where I drive. My emergency brake not even adjustable any more due to the heavy rust caused by the frame. Toyota failed to engineer the frame, and later on, failed again to correct their own mistake. contacted the dealer and waited for a month, no response. I called Toyota headquarter and filed a complaint. They respond is that because the recall program has expired there is no further assistance from Toyota. My question to Toyota is, are they going to wait to hear a disaster on one of the highways caused by their faulty equipment and workmanship, or will they take action before it happen. Attached are some pictures.

The contact owns a 2007 Toyota Tundra. The contact stated that the frame of the vehicle was severely corroded. The vehicle was taken to the dealer who diagnosed that the fuel tank crossmember was corroded and the sub frame was severely corroded on both the driver’s and passenger’s side. The manufacturer was notified of the failure and advised the contact that the vehicle could not be repaired under an unknown frame corrosion recall because the recall had already expired. The vehicle was not repaired. The failure mileage was approximately 107,000.

Rear fuel tank strap bracket detached from frame. Bracket appears to have corroded and detached at its frame weld without warning. Tank dropped about 3 inches down at rear and was barely supported by the front tank support strap and the flexible fill hose, which appeared to prevent it from shifting. The fill hose is attached to the tank via a stainless steel clamp. The tank could have dropped from vehicle when I was on the highway, before I was even aware of the issue. I happened to see something sagging when I was walking to my vehicle. It appears that the tank bracket would be very difficult to inspect, and I believe I had the vehicle inspected for a corrosion recall about 2-3 years ago. I was lucky I observed the tank when I did, it may have broken 1 or 2 days before I even noticed it. Attached photo shows the corroded detached bracket assembly. I was able to temporarily resupport the tank under the existing strap.

Excessive frame corrosion. I brought the vehicle in for the corrosion recall in 2018. against my objection, they determined that my frame did not have to be replaced and they coated the frame without removing the rust. I recently brought the truck in for service at a location repair shop where he notified me that my fuel tank supports have completely rust off of the frame. He dropped the fuel tank and found that Toyota had never dropped the tank and coated the cross members above the tank. The tank has been supported only by the filler hose, endangering my life and the life of my family. When I contacted Toyota, their response was they did what they were supposed to do. Case #210622001888

2007 TOYOTA TUNDRA. WHILE DRIVING APPROXIMATELY 40 MPH, THE CHECK ENGINE, ESC, AND VSC WARNING INDICATORS ILLUMINATED AS I WAS ENTERING THE FREEWAY THEN THE VEHICLE STARTED TO LOSE POWER AND WOULD NOT ACCELERATE MORE THAN 60MPH, THE TRUCK WENT INTO A LIMP MODE. I RESET THE ECM BY DISCONNECTING THE BATTERY BUT IT CAME BACK. THE APPROXIMATE FAILURE MILEAGE WAS 71K. THIS ISSUE IS ALL OVER THE INTERNET AND SHOULD BE COVERED BY EMISSIONS WARRANTY. CALLED THE DEALER AND IT IS NOT COVERED BY FEDERAL EMISSIONS WARRANTY AFTER 10YRS. NOT GOOD!

UNDER MOUNTED SPARE TIRE RUSTED OUT AND FELL OFF DRIVING DOWN THE HIGHWAY, ALMOST CAUSED AN ACCIDENT

THE FRAME IS COMPLETELY RUSTED HOLES IN SOME SPOTS. EXHAUST IS RUSTED. EXHAUST HANGERS HAVE RUSTED APART. FUEL TANK HANGERS ARE RUSTED ALMOST APART. ALL BRAKE LINES ARE RUSTED. TRANSMISSION IS SLIPPING DUE TO MOUNTING BRACKETS BEING RUSTED. DRIVESHAFT HAS FALLEN APART DUE TO RUST. TERRIBLE CONDITION.