2017 TOYOTA TUNDRA Complaints

Vehicle was driven 30 miles to work with no steering issues and parked in work parking lot. Upon returning to vehicle to return home when backing out of parking spot the front driver wheel would not turn almost causing me to back into parked car next to me. I looked under the front of the driver side tire, and noticed the outer tie rod was hanging down, and was causing the no steering issue. I called a tow truck, and had the vehicle taken to the Toyota dealer where vehicle was purchased new. I informed the dealer to be careful with the vehicle as the outer tie rod on driver side was broken and was not possible to drive. The Toyota dealer investigated the issue and found that the threads on bother inner and outer tie rods on both passenger and driver side was stripped. All outer and inner tie rods on the vehicle had to be replaced due to the threads being stripped on all 4 tie rods. My concern is this truck only has 86,000 miles on it, and if I had been travelling on interstate at 70MPH and the tie rod broke it would have resulted in a catastrophic collision due to a no steering condition. This vehicle has never sustained any front end damage of any type. I can provide the dealers name and the notes on the repair bill from the Toyota dealership stating exactly what I have stated in this report.

As I am driving down the pickup loses power/ has no power. Was driving down the interstate and trying to make it up the Harbor bridge I could only go 40. Then try to pass a semi that (BAD DRIVER) was dangerously close, I could not even pass him. Not to mention people were angry at me and getting defensive. There were no warning lights, I took it in immediately. It has been inspected by my secondary warranty I purchased. ( Tripple Diamond 1-833-909-0015 or 1-844-526-0415 our policy # is [XXX] under [XXX] -So I take it to the Toyota Dealership in Corpus Christi Texas, They then tell me it is my Secondary air pump (both Sides) and Valves including Gasket, Air Tube, Pump Assembly, air, (2 both sides)/inlet, Air pump(1) and valve set, emission (1) That was on 12-16-2022 (it has been there since) this will cost me $3,205.38 out of pocket. But the real problem is that there is a long waiting list of people waiting for this same part, so no one can get it. Many people with the same problem last I called I was 44 people in line. I only have 75,000 miles on my truck, and still have the same tires That are in great shape (I rotate them) So for this to happen seems strange, I take special care of this truck. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Fuel Pump failed. Vehicle is currently at dealership awaiting 2+ week repair. Currently available to inspect. Failure began while driving. Caused misfire in cylinder 1, caused electrical fault that disabled traction control. Potential to leave the vehicle inoperable on the roadside poses a safety risk. Toyota dealership in possession states "START WITH FUEL PUMP, REPORGRAM ECM PER TSB AND RELEARN FUEL DENSITY FOR ALCOHOL CONTENT FLEX FUEL VEHICLE, OUT OF WARRANTY FOR TSB" Toyota dealership is the only entity to perform any inspection. There were no warning lamps or messages related to the fuel system. Check engine light and message stating "Traction Control Off" appeared while driving the vehicle. After limping the vehicle home, the vehicle would not start.

When driving at night, the front lights of the vehicle turn off randomly. Been driving on an highway at going at 75mph and randomly the headlights shuts off. Happened 4 times in the past year.

I believe my Tundra has an emissions problem that Toyota will not cover. The FUEL TANK ROLL OVER VALVE is stuck. I believe this is a hazards condition. Toyota say the fuel tank will have to be replaced and not under warranty. Truck was purchased new by me and has 38887 miles.

NHTSA Recall No. 21E-103 I received a recall letter for my vehicle about a potentially defective power steering gear service and I called my local dealer about it and they said only if you put one in since August 5 2021 I said no but I think I have a steering problem sometimes while driving and they could look at my vehicle just to make sure it is ok. They said since it is no in this time frame that if you brought it in that I will have to pay for the inspection and will cost $150 dollars. I GET A LETTER ABOUT MY VEHICLE FOR A RECALL AND THEY WANT ME TO PAY FOR IT EVEN IF IT WASN'T IN THIS TIMEFRAME BUT I CAN BE DRIVING AND MAYBE GET KILLED IF I HAVE BAD STEERING GEAR!!!!!!!!

The contact's son owns a 2017 Toyota Tundra. The contact received notification of NHTSA Campaign Number: 21E103000 (Steering) however, the part to do the recall repair was not yet available. An unknown local dealer was contacted and informed the contact's son that the remedy for repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact's son had not experienced a failure. VIN tool showed no Unrepaired recalls associated with the VIN.

Headlights, taillights and all dash and interior lights go out when using turn signal at night. My and others safety has been put at risk due to the loss of headlights and taillights when engaging the turn signal. Those in my truck as well as those in surrounding vehicles are at risk because of the lack of exterior illumination while driving. Toyota dealer has not been able to reproduce the problem as the technicians do not work at night to drive the truck in the dark when headlights would be in use. Vehicle has not been inspected by any third parties just the dealership. There were no waring or messages or other symptoms of the problem before the failure. Problem first appeared in January 2022 and has occurred on over 6 occasions before truck was taken to dealership in February 2022. Truck was taken to dealership after lights went out at 70 MHP when signaling to exit highway at night.

Integrated Brake Controller (IBC) not sending sufficient power to electric dual-axle travel trailer brakes producing weak if any braking ability. On the approach to the first red traffic signal, there was zero braking from the trailer requiring full braking from the tow vehicle risking a crash. The IBC is providing no warning or failure indicators to the user. The vehicle and IBC are available for government inspection. The travel trailer in use is a 2022 Jayco Jay Flight SLX8 212QBW. While towing a 5,000 pound dual-axle travel trailer for the first time since I purchased the truck brand new from Toyota in 2017, I attempted to setup the IBC. Instructions say to set Type, which I set to electric brakes matching the trailer, then adjust the gain up while travelling around 25 miles per hours. When lock up of the trailer brakes occur, reduce the gain slightly to prevent full lock up. At a Gain of 10 (10 is the maximum), I could not achieve brake lock up and could only obtain weak trailer braking. The trailer was tested with a different tow vehicle and there were no problems obtaining lock up at mid-range gain. I had Toyota inspect the software updates to the IBC on January 14, 2022 and Toyota advised the IBC is up to date on its software and functioning correctly. The Tundra is out of factory warranty, but since I did not own a travel trailer during the warranty period, there was no way for me to test the IBC before going out of warranty.

I purchased a CPO 2017 Tundra SR5 Double Cab. Within a month of ownership, the EVAP system failed due to a faulty charcoal canister. Truck didn't even have 60,000 miles on it. This was covered under warranty, but the local Toyota Dealer, tried to make me pay for it anyway.