2000 TOYOTA TUNDRA Complaints

THE ACCELERATOR PEDAL STUCK ON MY 2000 TOYOTA TUNDRA TRUCK WHILE I WAS TRYING TO PARALLEL PARK ON A DOWNTOWN SIDE STREET, CAUSING ME TO HIT THE VEHICLES IN FRONT AND IN BACK. NO ONE WAS HURT, BUT VEHICULAR DAMAGE WAS CONSIDERABLE, AND MY INSURANCE INCREASED. A POLICE REPORT WAS FILED. UNTIL NOW, I COULDN'T FIGURE OUT WHAT HAPPENED. IT HASN'T RECURRED, AND THIS MODEL WASN'T MENTIONED IN THE RECALL. *TR

DEFECT: 2000 TOYOTA TUNDRA RUSTING FRAME. VEHICLE PURCHASED NEW IN 2000 AND PURCHASED RUST PROOFING PACKAGE. FRAME RUST WAS NOTICED IN 2004 AND RETURNED TO RUST PROOFING VENDOR FOR WARRANTY. WAS TOLD THAT IT WAS A PROBLEM WITH THE FRAME AND TO GO BACK TO TOYOTA. TOYOTA AT THE TIME WAS RECALLING TACOMA'S FOR A RUSTING FRAME PROBLEM. TOYOTA TUNDRA'S HAVE NOT BEEN RECALLED, BUT TOYOTA WILL ARRANGE INSPECTION AND WILL FIX WITH A GEL APPLICATION (WHEN AVAILABLE) IF RUSTING IS PRESENT. WE FEEL THEY SHOULD HANDLE THIS PROBLEM WITH A RECALL AND OFFER THE CUSTOMER THE SAME OPTIONS AS FOR THE TACOMA RECALL: IF THERE IS NO RUST, AUTOMATICALLY EXTEND WARRANTY TO 15 YEARS, IF THERE IS RUST, THE FRAMES ARE REPLACED AT NO COST TO THE CONSUMER OR TOYOTA WOULD BUY BACK THE TRUCK AT 150 PERCENT OF THE HIGH KELLY BLUE BOOK VALUE. MY TRUCK HAS UNDER 80,000 MILES ON IT AND I DON'T FEEL THIS PROBLEM WILL GO AWAY ANYTIME SOON. RUST IS FALLING OFF THE TRUCK FRAME STAINING THE GARAGE FLOOR AND NO MATTER HOW MUCH GEL THEY PUT ON, IT WILL NOT LAST. BECAUSE I WAS PRO-ACTIVE IN SCRAPING OFF THE RUST AND APPLYING RUST RESISTOR MYSELF (BECAUSE TOYOTA REFUSED TO DO ANYTHING FOR ME IN 2004), I HAVE DETERRED THE FRAME FROM RUSTING THROUGH AT THIS TIME. HOWEVER, FROM A SAFETY STANDPOINT AND DUE TO THE FACT THAT TOYOTA HAD PROBLEMS WITH THE TACOMA, I FEEL THEY SHOULD BE HELD ACCOUNTABLE FOR THE DEFECT IN THE FRAME MATERIAL FOR THE TUNDRA. *TR

2000 TOYOTA TUNDRA RUST FOUND IN FRONT FRAME BOX WHILE HAVING TOYOTA DEALER INSPECT FOR CROSS MEMBER RECALLED BY TOYOTA. I CONSIDER THIS TO BE A SERIOUS SAFETY HAZARD IF IN AN ACCIDENT.. MORE SO THAN THE REAR CROSSMEMBER DEALER KEPT MY VEHICLE.*CW

TL*THE CONTACT OWNS A 2000 TOYOTA TUNDRA. DURING ROUTINE MAINTENANCE HER INDEPENDENT MECHANIC STATED THAT THE SUB-FRAME DETERIORATED. THE TOYOTA DEALER ALSO CONFIRMED THAT THE SUB-FRAME DETERIORATED. THE MANUFACTURER STATED THAT THEY WOULD NOTIFY HER TO DETERMINE HOW TO RECTIFY THE FAILURE. THERE WERE NO RECALLS. THE FAILURE AND CURRENT MILEAGES WERE UNDER 81,582. UPDATED 02/13/10 *BF THE DEALER INFORMED THE CONSUMER, THE VEHICLE WAS UNSAFE TO DRIVE. UPDATED 02/16/17.*JB THE CONSUMER STILL HAS NOT HEARD FROM TOYOTA, EVEN THOUGH HE WAS TOLD HE WOULD RECEIVE A CALL BACK WITHIN 2-3 WEEKS A DECISION. UPDATED 03/09/10 *BF

I PURCHASED A 2000 TOYOTA TUNDRA WITH ONLY 107K MILES ON THE ODO. THIS WAS JUST BEFORE TOYOTA ANNOUNCED A MINOR RUST RECALL. I TOOK THE VEHICLE TO THE LOCAL TOYOTA DEALERSHIP AND TO MY SURPRISE THEY TOLD ME THAT THE ENTIRE FRAME WAS COMPROMISED. I HAVE NOW BEEN WITHOUT A VEHICLE SINCE THE 28TH OF DEC BECAUSE MY LOW MILEAGE TRUCK WAS DEEMED UNSAFE FOR THE ROAD. TOYOTA HAS YET TO OFFER A SOLUTION TO THIS PROBLEM. *TR

WHILE WASHING THE UNDERSIDE OF MY 2000 TOYOTA TUNDRA IN A COMMERCIAL SELF-SERVICE CAR WASH NUMEROUS PIECES OF SEVERELY RUSTED FLAKES OF STEEL CAME OFF MY FRAME. THE LARGEST PIECES WERE THE SIZE OF A MOTORCYCLE LICENSE PLATE. THESE PIECES CAME OFF FROM THE MAIN FORE AND AFT FRAME MEMBERS FORWARD OF THE BACK TIRES. UPON FURTHER INSPECTION I NOTICED THAT NOT ONLY THE AFOREMENTIONED MAIN FRAME MEMBERS WERE SEVERELY RUSTED BUT THAT THE CROSS-MEMBER FRAME PIECES WERE ALSO VERY RUSTED. I AM CONCERNED THAT THE INTEGRITY OF THE FRAME HAS BEEN COMPROMISED BY THIS SEVERE RUSTING. *TR

2000 LIMITED TOYOTA TUNDRA HAS EXCESSIVE FRAME RUST. MORE THAN I'VE EVER SEEN ON A VEHICLE THAT WAS NOT IN A JUNKYARD. NO SERIOUS INCIDENTS HAVE OCCURRED THUS FAR, BUT I AM SURE THAT THIS FRAME WILL FAIL SOON. I NOTICED THE PROBLEM ABOUT A YEAR AGO AND HAVE NOTICED THAT THE PROBLEM HAS GOTTEN EXPONENTIALLY WORSE IN THAT TIME. *TR

TO WHOM IT MAY CONCERN, I OWN A 2000 4X4 LIMITED TUNDRA WHICH HAS A RUST PROBLEM. MOST OF THE UNDERSIDE OF THE VEHICLE HAS HEAVY SURFACE RUST. IT ALSO HAS A FRONT BODY MOUNT THAT IS RUSTED AND CORRODED THE MEDAL IS FLAKING AND PEELING AWAY. I TOOK THE VEHICLE TO A TOYOTA DEALER FOR INSPECTION. THE DEALER TOLD ME THAT THE FRAME HAS NO PERFORATION HOLES IN IT. NOTHING THEY CAN DO. IN ADDITION TO ALL THE RUST I HAD TO REPLACE REAR BRAKE LINES AND REAR PARKING BRAKE ASSEMBLY ON BOTH SIDES DO TO RUST AND CORROSION. I CALLED TOYOTA CORP TO COMPLAIN ABOUT THESE PROBLEMS ALL THEY DID WAS GIVE ME A CASE NUMBER. I ALSO TOLD THEM THAT THE VALUE OF MY VEHICLE HAS BEEN COMPROMISED DUE TO THE RUST . THEY WILL NOT DO ANYTHING UNTIL HOLES ARE FORMED THROUGH THE FRAME. I FEEL IM CAUGHT BETWEEN A ROCK AND A HARD PLACE. TOYOTA DID THE RIGHT THING LAST YEAR WITH THE TACOMAS HAVING RUST ISSUES BUT DOING NOTHING FOR TUNDRA OWNERS. *TR

FRAME RAILS RUSTING EXCESSIVE! METAL FLAKING OFF IN BIG CHUNKS ALL ALONG THE ENTIRE FRAME. INCLUDING ALL THE CROSS MEMBERS AND STRUCTURE SUPPORTS. I HAVE BEEN ADVISED TO LIMIT THE LOAD AND TOWING CAPACITY OF THE TRUCK, BEING AFRAID OF FAILURE AND CAUSING AN ACCIDENT. *TR

LEFT FRONT BALL JOINT FAILED, WHILE TOWING A TRAILER WITH MY WIFE AND A TWO YEAR OLD. MECHANIC FOUND "SEVERE RUST" AND STATED VEHICLE WAS NOT SAFE DRIVE. *TR