2000 TOYOTA TUNDRA Complaints

I HAVE A 2000 TOYOTA TUNDRA WITH SEVERE FRAME RUSTING. MY LOCAL MECHANIC HAS DISCOVERED A THROUGH HOLE IN THE LEFT FRAME RAIL AND A DANGEROUSLY THIN LEFT REAR SPRING SHACKLE SUPPORT. I AM CONCERNED THE FRAME COULD FAIL WHILE DRIVING AND THAT THE VEHICLE WILL NOT PASS THE STATE SAFETY INSPECTION. *TR

I OWN A YEAR 2000 TOYOTA TUNDRA, WHICH I PURCHASED AS A NEW VEHICLE. THE TRUCK HAS APPROXIMATELY 81,000 MILES ON IT AND HAS BEEN GARAGED FOR THE ENTIRE TIME THAT I HAVE OWNED IT. THE UNDERSIDE OF THE VEHICLE HAS SHOWN EXTREME RUSTING, ESPECIALLY THE BRAKE SYSTEM WHICH HAS FAILED TWICE DUE TO CORROSION. DURING THE MOST RECENT BRAKE FAILURE I COULD NOT STOP THE VEHICLE WHILE DESCENDING A HILL AND DOWNSHIFTED THE TRANSMISSION TO SLOW DOWN. ADDITIONAL RUST PROBLEMS HAVE INCLUDED REPLACEMENT OF ALL FRONT AND REAR BRAKE LINES, INCLUDING THE REAR PROPORTIONING VALVE. THE FRONT ROTOR CALIPER PINS HAVE ALSO SEIZED DUE TO RUST. THE EMERGENCY BRAKE SEIZED DUE TO RUST AND WAS NOT OPERATIONAL. BOTH SWAY BAR LINKS AND BUSHINGS FAILED DUE TO RUST. THE HEAT SHIELDS AROUND THE MUFFLER AND CATALYTIC CONVERTER RUSTED OFF THE TUNDRA AND MAY HAVE POSED SIGNIFICANT SAFETY HAZARDS TO DRIVERS TRAVELING BEHIND ME ON THE HIGHWAY. THESE CORROSION PROBLEMS WERE REPORTED TO TOYOTA AND THE TRUCK WAS INSPECTED BY A DISTRICT SERVICE REPRESENTATIVE FOR FRAME RUSTING ONLY (SUMMER 2009). THE OTHER PROBLEMS WITH THE BRAKING SYSTEM, ETC. WERE COMPLETELY IGNORED, EVEN THOUGH I BROUGHT THIS TO THE SERVICE REP'S ATTENTION. IN ADDITION, THE DISTRICT MANAGER WAS CONTACTED SEVERAL MONTHS AGO AND HAS NOT ADDRESSED MY CONCERNS. ALL THE ABOVE PROBLEMS ABOVE WERE REPAIRED AT THE LOCAL TOYOTA DEALER, WHOSE MECHANICS COMMENTED THAT THE UNDERSIDE OF THE TRUCK WAS SEVERELY CORRODED. ALSO, THE REPAIRS ARE DOCUMENTED IN MY VEHICLE'S SERVICE HISTORY. *TR

I OWN A 2000 TOYOTA TUNDRA AND A FEW YEARS AGO IT BEGAN TO SHED ITS PAINT. IT SPOTS UP LIKE IT IS CORRODED WITH A CHEMICAL THEN BEGINS TO PEEL OFF. BY THIS POINT THE WHOLE TRUCK HAS EITHER PEELED OFF OR IS SPOTTED. THE RUNNING BOARDS ARE ALSO CORRODED AND RUSTING WITH HOLES ALL OVER THEM. I CONTACTED TOYOTA AND A REP LOOKED AT THE TRUCK AND PRECEDED TO ACCUSE ME OF EXPOSING MY TRUCK TO A CHEMICAL AND SAYING HE HAD NEVER SEEN THIS HAPPEN BEFORE. THEY REFUSED TO MAKE IT RIGHT. I KNOW OF ANOTHER LADY WITH THE SAME YEAR TRUCK AND COLOR OF MINE WHO HAS EXPERIENCED THE SAME PROBLEM. I DID NOT BUY MY TRUCK NEW, BUT IT WAS ONLY 5 OR 6 YRS. OLD WHEN THIS PROBLEM BEGAN TO OCCUR. I AM THINKING THAT I CANNOT BE THE ONLY ONE OUT HERE WHO IS EXPERIENCING THIS. THANK YOU FOR ALL THE HELP YOU CAN OFFER. *TR

TL* THE CONTACT OWNS A 2000 TOYOTA TUNDRA. IN JUNE OF 2004, HE NOTICED CORROSION BUBBLING UNDER THE PAINT ON THE FRAME; THERE WERE QUARTER INCH LUMPS ON THE PAINT. HIS MECHANIC SPECULATED THAT THE CORROSION WAS PREMATURE FOR THE VEHICLE'S AGE IN 2004. HE THEN RECOMMENDED THAT THE VEHICLE BE OILED. THE VEHICLE HAS BEEN OILED SINCE 2005. DURING THE LAST OILING HE WAS ADVISED THAT THE CROSS BRACE THAT HOLDS THE SPARE TIRE HAD CORROSION , AND THE SPARE TIRE WAS MISSING. THE MANUFACTURER NOR THE DEALER WAS CONTACTED. THE CURRENT MILEAGE WAS APPROXIMATELY 154,000. THE FAILURE MILEAGE WAS 50,000. CONSUMER IS ADDING PICTURES. 10/26/09. *NJ UPDATED 10/26/09 *BF THE CONSUMER SENT IN PICTURES OF THE FRAME. UPDATED 10/28/09

I OWN A 2000 TOYOTA TUNDRA LIMITED WITH AN UNUSUAL AMOUNT OF FRAME RAIL RUST ESPECIALLY AROUND THE HANGARS THAT ATTACH TO THE AXLES. I'VE BEEN TOLD BY ST CLOUD MN TOYOTA THAT THERE'S NOTHING THEY CAN DO. *TR

I OWN A 2000 TOYOTA TUNDRA PICK-UP THAT HAS BEEN MAINTAINED CORRECTLY BY THE TOYOTA DEALERSHIP. IT HAS A SEVERE RUST PROBLEM UNDERNEATH THE TRUCK ON THE FRAME AND SUPPORTING PARTS. THE BODY OF THE TRUCK IS IN EXCELLENT CONDITION. I HAVE 89,000 MILES ON IT AND WANTED TO KEEP IT FOR SEVERAL MORE YEARS. I AM AFRAID I HAVE A SAFETY ISSUE AND AM AFRAID TO TAKE THE TRUCK ON THE HIGHWAY. I JUST RECENTLY PUT $2,000 INTO THIS AT THE DEALER AND NOTHING WAS SAID ABUT THE RUST. I CANNOT GET TOYOTA TO ADDRESS THIS. I WANT TO KNOW HOW TO PROCEED...I NEED A VEHICLE TO GET TO WORK AND CANT AFFORD A NEW ONE WITHOUT SOME HELP. PLEASE HELP ME GET THIS RESOLVED. *TR

I HAD THE ACCELERATOR STICK WHILE PARALLEL PARKING MY 2000 TOYOTA TRUCK ABOUT 4 YEARS AGO. I TRIED TO BRAKE, THEN PUT THE VEHICLE IN REVERSE, ENDED UP DAMAGING BOTH THE VEHICLE IN FRONT AND BEHIND MY VEHICLE. AT THE TIME, I DIDN'T UNDERSTAND WHAT HAD OCCURRED. NOW I SEE OTHERS HAVE EXPERIENCED THE SAME PROBLEM. *TR

I HAVE BEEN AWARE OF PROBLEMS WITH EARLY MODEL TOYOTA TUNDRA FRAME RUST PROBLEMS AND HAVE FOLLOWED WITH INTEREST TOYOTA'S RESPONSE [NONE]HOWEVER, I FEEL OBLIGED TO INFORM YOU THAT ON FRIDAY 25TH THE GAS TANK STRAPS FAILED WHILE DRIVING AND THE GAS TANK FELL OF THE VEHICLE AS LUCK WOULD HAVE IT I WAS SLOWING DOWN TO MAKE A TURN SO THE CONSEQUENCES WERE LIMITED. BUT, 30 SECONDS EARLIER AT 55 MPH THIS MOST LIKELY WOULD NOT HAVE BEEN A LIMITED CONSEQUENCE SITUATION. *TR UPDATED IVOQ 06/30/10.*JB

I RECENTLY NOTICED EXTENSIVE FRAME RUST ON MY TOYOTA TUNDRA. ON SEPTEMBER 28, 2009, I TOOK IT TO THE TOYOTA DEALER FOR A FRAME INSPECTION. THE INSPECTION FOUND SIGNIFICANT RUST AND AS A RESULT OF THE INSPECTION, THE DEALER DETERMINED THAT THE VEHICLE IS UNSAFE TO DRIVE. THE DEALER SAID THERE WAS NOTHING THEY COULD DO ABOUT IT SINCE THERE HAD BEEN NO RECALL PROGRAM OR OTHER ACTION BY TOYOTA. THE DEALER DID TELL ME THAT TOYOTA DID ESTABLISH A PROGRAM FOR THE TACOMA. IN FACT, THE DEALER USED A WORKSHEET FORM THE TACOMA PROGRAM TO NOTE THE LOCATION AND EXTENT OF CORROSION. ON SEPTEMBER 29, 2009, I CALLED TOYOTA CUSTOMER SERVICE ABOUT THE PROBLEM BUT THEY DID NOT OFFER ANY RELIEF OR REMEDY. I WAS GIVEN A CASE NUMBER OF 0909141286 AND TOLD THAT A CASE MANAGER WOULD CALL ME. ON SEPTEMBER 30, 2009, A TOYOTA CASE MANAGER CALLED ME BUT SAID AT THIS TIME THERE WAS NOTHING THEY COULD DO. I WAS TOLD THAT TOYOTA HAD RECEIVED SIMILAR COMPLAINTS FROM OTHER OWNERS AND WAS INVESTIGATING THE ISSUE. I WAS TOLD THAT THERE WAS NOTHING IN PLACE TO ASSIST ME WITH MY PROBLEM, EVEN THOUGH A DEALER HAD ALREADY INSPECTED MY VEHICLE AND DECLARED THAT IT WAS UNSAFE TO DRIVE DUE TO THE RUST PROBLEM. I WAS TOLD THAT THERE IS NO DATE BY WHICH THE TOYOTA INVESTIGATION WILL BE COMPLETED AND THERE WAS NOTHING THEY CAN DO FOR ME IN THE MEANTIME. I NEED MY TRUCK FOR TRANSPORTATION NOW. I AM REQUESTING THE ASSISTANCE OF THE NHTSA TO COMPEL TOYOTA TO PROVIDE A REMEDY TO ME FOR THIS SAFETY DEFECT IN THE VEHICLE. *TR

TOYOTA 2000 TUNDRA--EXTENSIVE RUST ON THE ENTIRE FRAME. LARGE THICK FLAKES OF RUST HAVE BEEN FALLING OFF FOR TWO YEARS. SIGNIFICANT RUST-THROUGH PERFORATION IN FRAME. CLEARLY UNDERMINES STRUCTURAL INTEGRITY OF THE FRAME OF THE TRUCK. IT HAS HAD THE UNDERBODY WASHED WEEKLY SINCE IT WAS NEW. IT HAS 72000 ORIGINAL ONE-OWNER MILES. I DON'T FEEL SAFE DRIVING THIS CAR BECAUSE IN THE EVENT OF AN IMPACT THE FRAME WOULD CRUMBLE. CURRENTLY THERE ARE HOLES IN THE FRAME THAT YOU COULD STICK SEVERAL FINGERS THROUGH. *TR