1998 VOLKSWAGEN BEETLE Complaints

BAD WIRING, ALARM GOES OFF IN THE MIDDLE OG THE NIGHT, REAR HATCH LIGHT COMES ON AND OFF, WIRING IS BAD IN COLD WEATHER, FRONT HEADLIGHTS KEEP BURINING OUT, EXCESSIVE OIL CONSUMPTION, AT ABOUT 2000 MILES ENGINE WILL BE BONE DRY, EXCESSIVE ROAD NOSIE, RADIO NO LONGER WORKS, IN GENERAL THE CAR IS IN BAD SHAPE AFTER TWO YEARS OF USE AND IT SEESM TO BE ALL FACTORY RELATED TYPE OF PROBLEMS.

CAR OVERHEATS ROUTINELY. INITIALLY IN FOR REPAIR ON 1/25/01 WHEN DEALER CLAIMED TO HAVE REPLACED THE WATER PUMP AND THERMOSTAT. SINCE THEN, CAR HAS OVERHEATED ON THREE OCCASIONS, AND WATER LEAKAGE HAS BEEN OBSERVED. DEALER SAYS THEY CAN NOT REPLICATE THE ISSUE. DRIVER'S SIDE DOOR DOES NOT LOCK AND UNLOCK RELIABLY, FORCING ME TO ENTER AND EXIT CAR THROUGH PASSENGER DOOR. REPORTED TO DEALER THREE TIMES (INITIALLY 5/31/00). ONE TIME DEALER LUBRICATED LOCK; CURRENTLY THEY SAY THEY CAN NOT REPLICATE THE ISSUE AND WILL NOT FIX. AFTER WATER PUMP REPAIR IN 1/01, CAR EXHIBITED A WHINING NOISE AND POWER STEERING STIFFNESS AT LOW RPMS -- LIKELY DUE TO IMPROPER WORKMANSHIP DURING THAT REPAIR. DEALER CLAIMS POWER STEERING FLUID WAS LOW, AND HAS BEEN "TOPPED OFF" TO ALLEVIATE PROBLEM. HOWEVER, I RECENTLY HAD ROUNTINE MAINTENANCE AT ANOTHER ESTABLISHMENT JUST 4 DAYS PRIOR TO TAKING INTO SHOP; DURING THAT SERVICE, POWER STEERING FLUIDS WERE INDICATED AS "OK." OIL CONSUMPTION IS EXCESSIVE. DESPITE REPEATED REPORTS TO VW (INITIALLY 5/00), HAVE RECEIVED NO RESOLUION OR INVESTIGATION INTO THIS ISSUE. THROUGH RESEARCH, I HAVE LEARNED THAT THIS IS A COMMON BEETLE PROBLEM, AND SOME BEETLE OWNERS ARE RECEIVING NEW ENGINES OR VALVE STEM REPAIRS TO REMEDY. TRANSMISSION JERKS SEVERLY WHEN SHIFTING FROM REVERSE TO DRIVE. INITIALLY REPORTED 9/29/98 AT 9596 MILES AND NOT ADDRESSED BY DEALER. RECURRING PROBLEMS WITH HEADLIGHT SEALANT LEAKAGE AND WATER GETTING INTO HEADLIGHT ASSEMBLY, CAUSING HEADLIGHTS TO BE UNRELIABLE AND POTENTIAL ELECTRICAL/FIRE HAZARD. HAVE RESEARCHED VW AND LEARNED DURING INITIAL BEETLE PRODUCTION IN PUEBLA, MEXICO, THEY EXPERIENCE AN ABOMINAL 40% DEFECT RATE. FROM RESEARCH INTO OTHER CONSUMER ISSUES WITH 1998 BEETLES, I AM CERTAIN THAT VW PASSED THESE DEFECTIVE VEHICLES ON TO CONSUMERS. PLEASE CONTACT ME FOR FURTHER DETAILS. I HAVE ALSO EXPERIENCED WINDOW REGLATOR FAILURES, DEAD BATTERY, INTERIOR PIECES FALLING APART AND OTHER ISSUES. THANK YOU!*AK

CONSUMER WAS DRIVING , APPROACHING A STOP LIGHT, AND APPLYING BRAKES AND SEAT CAME LOOSE. DRIVER WAS FORCED INTO STEERING WHEEL, AND THEN WENT ALL WAY BACK, NOT ALLOWING DRIVER TO REACH THE PEDALS. ONLY COMPONENT THAT HELD THE SEAT TO VEHICLE WAS A WHEEL MOUNTED IN A TRACK. THERE WERE 2 SCREWS (3/4") THAT HAD COME LOOSE WHICH CAUSED THIS DEFECT. PLEASE PROVIDE ANY ADDITIONAL INFORMATION/ATTACHMENTS.*AK

WHILE DRIVING IN RAIN, LOW BEAMS WENT OUT WITHOUT WARNING DUE TO A WIRING HARNESS MALFUNCTION. DEALER REPLACED BOTH HEADLIGHT BULBS, AND REPLACED HEADLIGHT HARNESS. *AK

BATTERY PROBLEM. I STOPPED AT SIGNAL AND WHEN I RESTARTED THE ENGINE STOPPED AND I WAS ALMOST REAR END. THE ABS AND BRAKE LIGHTS CAME ON. THE CAR WAS TOWED. APPARENTLY THE BATTERY WAS FALLING OUT OF THE CAR AT 13,000 MILES. A FEW MONTHS LATER I HEARD A NOISE AND SLIPPING WITHIN THE TRANSMISSION. AS IT TURNED OUT, ENGINE COOLANT HAD LEAKED INTO THE TRANSMISSION AND A REBUILT WAS PUT IN. WITHIN A FEW WEEKS AFTER THE REBUILT WAS PUT IN, IT WAS MAKING SOME NOISE AND IT HAD INTERMITTENT LURCHING. I COMPLAINED TO VW OF AMERICA AND THE DEALERSHIP. THEY TOOK CARE OF THE NOISE AND SAID THEY WOULD BE UNABLE TO HELP WITH THE LURCH PROBLEM. I WAS IN AN ACCIDENT A MONTH AND A HALF AFTER GETTING THE REBUILT. I WENT INTO A POLE SIDEWAYS. I HAD AN INDEPENDENT TRANSMISSION SPECIALIST TEST DRIVE IT AFTER THE CAR WAS REPAIRED. HE REPORTED AN UNUSUALLY LONG PAUSE FOR ENGAGEMET. I BELIEVE THAT WHEN I WAS IN A ROLL FORWARD MOTION AND WOULD PUT MY FOOT TO THE GAS, IT WOULD NOT ENGAGE PROPERLY AND LURCHED. THE REASON IT WAS INTERMITTENT , IS DUE TO THE FACT THAT SOMETIMES WHEN YOU WOULD BE IN A ROLLFORWARD MOTION IT WOULD BE IN GEAR AND NOT LURCH. IF IT WAS NOT IN GEAR DUE TO THE LONG PAUSE, YOU WOULD GET A LURCHING MOVEMENT. MY FIRST TRANSMISSION NEVER HAD THIS PROBLEM. THERE IS A POTENTIAL DESIGN FLAW WITH THIS TRANSMISSION. WHEN I WAS TALKING TO THE SERVICE MANAGER AT COMMONWEALTH, WITH MY FIRST TRANSMISSION, HE HAD STATED THEY WERE HAVING PROBLEMS WITH THE JETTA TRANSMISSIONS.*AK

ELECTRICAL WIRING LOCATED IN ENGINE COMPARTMENT WAS ROUTED TOO CLOSE TO ENDGE OF VEHICLE BATTERY TRAY. WIRING BECAME DAMAGED BY CHAFING. AIR CONDITIONER COMPRESSOR AND FUEL PUMP COULD MALFUNCTION. PLEASE PROVIDE FURTHER INFORMATION. *AK

COOLANT LOSS ON TWO OCCASIONS CAUSING ENGINE TO BLOW, NO WARNING UNTIL LAST MINUTE, ALL FLUIDS AND MAINTENACE DONE AND UNDER EXTENDED WARRANTY, DEALER REFUSED TO PAY FOR NEW ENGINE. *AK

WHILE DRIVING PLASTIC COVER THAT PROTECTS ENGINE/ EXHAUST SYSTEM AND PLUGS DISENGAGED FROM UNDER VEHICLE. PLEASE GIVE ANY FURTHER DETAILS.*AK

DRIVER'S SEAT IS LOOSE FROM FLOORBOARD. THERE'S ALOT OF MOVEMENT WHEN DRIVING AND BRAKING. SEAT WAS REPAIRED BY AN INDEPENDENT REPAIR SHOP. CONSUMER WILL ATTACH ADDITIONAL INFORMATION. *AK SEAT BOLTS FAILED. *SLC

AM DOING THIS FORM TO LET PEOPLE KNOW THERE ARE BEETLES AND PROBLEMS. ALSO THAT VW IS NOT STANDING BEHIND REPAIRING THESE PROBLEMS. THE HEADLIGHTS HAVE BLOWN (BAD WIRING) 4 TIMES AT NIGHT. NOT A FUN THING TO HAVE HAPPEN AT 65 MPH. YOU TRY STOPPING BLIND. *AK