2006 VOLKSWAGEN BEETLE Complaints

CAR TRANSMISSION DIS-ENGAGES AND THEN HARD SHIFTS BETWEEN 2ND AND 3RD GEARS AS WELL AS BETWEEN 4TH AND 5TH GEARS. THE MOST DANGEROUS INCIDENT INVOLVED MY DAUGHTER STARTING THROUGH A SIGNALIZED INTERSECTION, AND WHEN THE TRANSMISSION DIS-ENGAGED, SHE WAS ALMOST REARENDED. I'VE TAKEN THE CAR TO THE DEALERSHIP TWICE AND WERE ADVISED BOTH TIMES THAT THE TRANSMISSION NEEDED REPLACEMENT AT A COST OF ~$5,500. AT THE MOST RECENT TRIP TO THE MECHANIC, THE CAR HAD APPROXIMATELY 80,000 MILES. I RECEIVED A SERVICE BULLETIN FROM VW DATED NOV 2010 (A YEAR AGO) INDICATING THAT THE VALVE BODY MAY BE THE PROBLEM. THE MECHANIC ADVISED ME THAT MY PROBLEM WAS NOT RELATED TO THE VALVE BODY, BUT THAT THE TRANSMISSION NEEDED REPLACEMENT. THEY DID NOT OPEN THE TRANSMISSION TO CHECK THE PARTS TO MAKE THIS DETERMINATION, BUT MERELY RAN A COMPUTER DIAGNOSTIC CHECK. THE INTERNET IS FULL OF SIMILAR COMPLAINTS. I'M AT A LOSS AS TO WHAT TO DO, AND FEAR OTHER NEAR MISS ACCIDENTS. ACCORDING TO THE DEALER'S MECHANICS, THE ONLY REMEDY IS TO HAVE THE TRANSMISSION REPLACED AT CONSIDERABLE COST. I EXPECT THAT THE TRANSMISSION WOULD NOT IRREPARABLY MALFUNCTION WITH SO FEW MILES. SHORT OF A CLASS-ACTION LAWSUIT, I SEE NO RELIEF OR REMEDY. *TR

THERE APPEARS TO BE AN ISSUE WITH THE TRANSMISSION ON THE BEETLES. I TOOK IT TO A LOCAL TRANSMISSION REPAIR SHOP AND WAS TOLD BY THE MECHANIC THAT THERE HAS BEEN SEVERAL OF THE TRANSMISSION FAILURES IN HIS SHOP RECENTLY. *TR

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN NEW BEETLE CONVERTIBLE. THE CONTACT STATED THAT THE VEHICLE WOULD JERK WHILE SHIFTING FROM SECOND TO THIRD GEAR. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHERE THE VALVE BODY WAS REPAIRED. THE FAILURE CONTINUED. THE VEHICLE WAS TAKEN BACK TO THE DEALER, WHERE THE CONTACT WAS INFORMED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 55,000 AND THE CURRENT MILEAGE WAS 60,000.

DEFECTIVE WINDOW REGULATOR: I HAVE A 2006 NEW BEETLE CONVERTIBLE, WHICH I BOUGHT NEW. NO ACCIDENTS, NOTHING OF THE SORT. I WAS ROLLING UP THE DRIVERS SIDE WINDOW AND HEARD A POP. THEN THE WINDOW WOULD NOT MOVE, AND I COULD HEAR A GRINDING NOISE IN THE DOOR. THE WINDOW REGULATOR HAD BROKEN OUT OF NO WHERE. APPARENTLY THIS IS A COMMON ISSUE, BUT ONE THAT COSTS UP TO $800 TO FIX AT THE DEALERSHIP. I THOUGHT I COULD FIX IT MYSELF, SO I BOUGHT THE REPAIR KIT FROM THE DEALERSHIP FOR $110, BUT IT REQUIRE A SPECIAL TOOL THAT ONLY THE DEALERS HAVE. HOW AM I ON THE HOOK FOR SUCH A POORLY DESIGNED MECHANISM? *TR

THE BACK WINDOW IN MY CONVERTIBLE 2006 NEW BEETLE SEPARATED FROM THE FABRIC. THE ENTIRE TOP HAD TO BE REPLACED. ACCORDING TO THE VEHICLE UPHOLSTERY SHOP THAT REPLACED THE TOP, IF THE SEPARATION HAD BEEN CAUGHT EARLY ENOUGH IT COULD HAVE BEEN REPAIRED WITH AN ADHESIVE GLUE. MY CAR WAS IN FOR SERVICE AND I ASKED FOR THE TOP TO BE CHECKED BECAUSE I HAD EXPERIENCED AN INCIDENT OF THE TOP NOT OPENING PROPERLY. TWO WEEKS LATER WE HAD A HEAVY THUNDER STORM AND MY CAR WAS FULL OF WATER. *TR

DSG 6 SPEED AUTOMATIC TRANSMISSION SLIPS INTO NEUTRAL WHILE DRIVING. DASH PANEL DRIVE DISPLAY ILLUMINATES AS A SINGLE BAR. ESP INDICATOR FLASHES AND STAYS ON. MUST PULL OFF ROAD AND TURN ENGINE OFF, WAIT AND START ENGINE AGAIN. MAY OR MAY NOT ALLOW CAR TO SHIFT PROPERLY AFTERWARDS. USED ROADI RDT45 SCAN TOOL TO CHECK FOR FAULT CODE. TRANSMISSION FAULT CODE 18262/P1854 "DATA BUS POWER TRAIN HARDWARE DEFECTIVE" CAME UP REPEATEDLY. VW DEALERSHIP ACKNOWLEDGED SAME FAULT CODE, CLEARED FAULT AND TOLD CAR OWNER IF TRANSMISSION SLIPS INTO NEUTRAL AGAIN THE MECHATRONICS ASSEMBLY WOULD HAVE TO BE REPLACED AT A COST OF APPROXIMATELY $2,000. THE VW DEALERSHIP TOLD CAR OWNER THAT THERE IS NO EXTENDED WARRANTY NOR RECALL ON THIS MODEL YEAR AND TRANSMISSION. THE CAR OWNER MUST PAY THE REPAIR COST.

I OWN A 2006 VW NEW BEETLE CONVERTIBLE. THE AIR BAG WARNING LIGHT STARTED TO LIGHT INTERMITTENTLY AND NOW IT ALWAYS REMAINS LIT. I HAVE TAKEN IT INTO MY VW DEALERSHIP A FEW TIMES FOR THIS ISSUE. AT FIRST,THEY WERE ABLE TO RESET THE CODE AND THE AIR BAG LIGHT WENT OUT. HOWEVER, THE LAST TIME I WENT IN THEY WERE UNABLE TO RESET THE LIGHT. TO CORRECT THE PROBLEM, THE VW DEALERSHIP SAYS THAT I NEED TO PAY THEM A SIGNIFIICANT AMOUNT OF MONEY TO TROUBLESHOOT AND CORRECT THE PROBLEM. I HAVE NEVER BEFORE HAD A PROBLEM WITH ANY AIR BAG WARNING LIGHTS ON ANY OF MY OTHER VEHICLES. I BELIEVE THAT THIS IS A DEFINITE SAFETY ISSUE THAT IS CAUSED BY THE UNRELIABILITY OF VW'S DESIGN IMPLEMENTATION OF THEIR AIR BAG SAFETY SYSTEM. PEOPLE SHOULD BE ABLE TO HAVE HIGH CONFIDENCE THAT THEIR SAFETY SYSTEMS WILL BE UTRA RELIABILITY THROUGHOUT THE LIFE OF THE CAR AND SHOULD NOT HAVE TO EXPECT TO PAY ADDITIONAL FOR THAT ASSURANCE. MY DAUGHTER WAS JUST IN A MINOR REAR END COLLISION. THE AIR BAGS DID NOT DEPLOY EITHER BECAUSE THE COLLISION WAS INSUFFICIENT TO SET OFF THE AIR BAG SYSTEM OR BECAUSE THE AIR BAG SENSOR LIGHT WAS ON. THANKFULLY, MY DAUGHTER WAS NO SERIOUSLY INJURED. *TR

2006 NEW BEETLE TDI TRANSMISSION (DSG) FAILURE. CAN SUDDENLY SLOW AND OPERATED AT HIGH REV'S. LUCKY I DID NOT GET REAR ENDED. *TR

I HAVE OWNED A 2003 AND 2006 VW NEW BEETLE CONVERTIBLES AND HAVE HAD 3 WINDOW REGULATORS FAIL. ALL ON THE BACK SIDE WINDOWS. THIS IS DANGEROUS BECAUSE THEY FAIL FOR NO REASON. THE LAST FAILURE WAS 02/26/2011. I WAS DRIVING ON AN INTERSTATE AND PUT THE WINDOW DOWN AND IT WOULD NOT ROLL BACK UP. I WAS 50 MILES AWAY FROM HOME. THIS IS VERY FRUSTRATING TO HAPPEN FOR THE 3RD TIME BUT DIFFERENT WINDOW EACH TIME. *TR

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN BEETLE. THE CONTACT WAS DRIVING APPROXIMATELY 55 TO 60 MPH WHEN THE FLY WHEEL DISINTEGRATED AND CAUSED THE ENGINE TO LOCK WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THE CONTACT WAS ADVISED THAT HE NEEDED TO REPLACE THE FLY WHEEL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 62,000.