2001 VOLKSWAGEN EUROVAN Complaints

RELIABLE INTERNET AUTOMOTIVE SOURCES HAVE LISTED EXCESSIVE WEAR OF THE INTERMEDIATE (BALANCE SHAFT) VALVE TIMING CHAIN SPROCKET IN EARLY 2001 24-VALVE VR6 ENGINES. THE INADEQUATELY HARDENED SPROCKET TEETH WILL VEER EXCESSIVELY, SUCH THAT CHAIN "JUMPEDS" A TOOTH AND SINCE THE VR6 IS AN "INTERFERENCE" VALVE-TRAIN ENGINE, THE ENGINE WILL ESSENTIALLY BE IRREPARABLY DAMAGED. *TR

DRIVER SEAT HEATER CAUGHT FIRE AND MELTED HOLE IN SEAT. THIS IS A VERY DANGEROUS AND SHOULD BE A RECALL ITEM. *TR

ENGINE COOLING FAN BLADE FAILURE. THE LARGER OF THE 2 FAN BLADE WHEELS HAS A LARGE MISSING PIECE WHICH HAS SOMEHOW DISINTEGRATED WITHOUT ANY REASONABLE EXPLANATION. I UNDERSTAND THERE WAS AN INVESTIGATION OF THE EUROVAN ENGINE COOLING FAN BLADE, HOWEVER A RECALL HAS NOT BEEN ISSUED, WHILE THERE WAS A RECALL ON THE RIALTA, WHICH USES THE SAME FAN AS THE EUROVAN. *TR

TRAVELING WITH TWO OTHER RIALTA MOTOR HOMES VISITING JOSHIA TREE NP WHEN I HEARD A BANGING SOUND LIKE SOMETHING HITTING UNDER MY RIALTA. I IMMEDIATELY NOTED AN INCREASE IN WATER TEMPERATURE AND THEN THE RED WARNING LIGHT CAME ON THE DASH. I PULLED TO THE SIDE OF THE ROAD, OPENED THE HOOD, BUT COULD NOT SEE A BUSTED HOSE, BUT THERE WAS ANTIFREEZE ON THE GROUND. I HAD A SPARE GALLON WITH ME AND FILLED THE RESERVOIR TO RECOMMENDED LEVEL, DROVE ABOUT 3-4 MILES AND HAD TO REPEAT PROCEDURE. AGAIN I WENT ABOUT 3-4 MILES AND HAD TO USE WATER THIS TIME. A PARK RANGER GAVE ME THE NAME OF A REPAIR SHOP IN TWENTYNINE, PALMS WHICH WAS ABOUT 3 MILES AWAY. I REFILLED THE RESERVOIR WITH WATER TO GET ME TO THE SHOP. UPON INSPECTION, A HOLE WAS FOUND IN THE RADIATOR. WHEN THE COOLING SYSTEM WAS DISMANTLED, ONE COOLING FAN HAD COMPLETELY DISINTEGRATED AND THERE WAS A HOLE IN THE SHROUD APPARENTLY WHERE PART OF THE FAN BRACKET THAT HAD BROKEN OFF WENT THROUGH THE SHROUD INTO THE RADIATOR. PARTS HAVE BEEN ORDERED TO REPLACE THE RADIATOR, SHROUD, BRACKET AND ONE NEW FAN. THE OTHER FAN HAS A CHIP OUT OF ONE BLADE BUT IS NOT BROKEN. A FRIEND TOLD ME OF A RECENT RECALL FROM VW (ASSIGNED RECALL NO. 04V-107) REGARDING FAILURE OF THE ENGINE COOLING FANS, WHICH MAY FRACTURE AND BREAK APART. I HAVE ALSO NOTED THAT THE BRACKET PARTS NUMBER HAS CHANGED FROM 7D0-121-206A TO A 7D0-121-206D. ONE CAN DEFINITELY SEE THE DIFFERENCE IN THE TWO, WITH THE LATER BEING REDESIGNED AND REINFORCED. I PURCHASED THE RIALTA IN APRIL OF 2001. THE BRACKET, SHROUD AND RADIATOR ARE AVAILABLE, BUT I PREFER NOT TO CARRY THE RADIATOR WITH ME DUE TO SPACE CONSTRAINTS AND WEIGHT. I AM TRAVELING FOR AT LEAST TWO MORE MONTHS. PLEASE NOTE: THIS IA WINNEBAGO RIALTA ON A VOLKSWAGEN ENGINE. THE REPAIR SHOP MAY RETAIN THE RADIATOR IF NECESSARY. BAILEY'S AUTO REPAIR AND TOWING. TWENTYNINE PALMS, CA 92277. 760/367-7716. ASK FOR FRED. *TR

TL*- THE CONTACT STATED THAT WHILE HAVING THE WHEELS ON THE 2001 VOLKSWAGEN EURO VAN WITH14000 FAILURE MILEAGE INSPECTED DUE TO CONSTANT AIR LEAKAGE THE MECHANIC DISCOVERED STRESS CRACKS IN THE TWO REAR WHEELS. THE CURRENT MILEAGE WAS 16100.*AK

DT*: THE CONTACT STATED WHILE DRIVING SMOKE WAS SMELLED. THE SMOKE WAS DISCOVERED COMING FROM THE FRONT PASSENGER SEAT. THE VEHICLE WAS TAKEN TO THE DEALERSHIP FOR INSPECTION. THEY DETERMINED THE SEAT HEATER BURNED THE SEAT. THE HEATER AND SEAT WERE REPLACED. AFTER PICKING UP THE VEHICLE FROM THE DEALERSHIP, WHILE DRIVING HOME THE ENGINE BLEW AND THE VEHICLE WAS TAKEN BACK TO THE DEALERSHIP AGAIN. THE DEALERSHIP INSPECTED AND DETERMINED THE ENGINE NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED; HOWEVER NO ADDITIONAL REPAIRS WERE MADE.

DT: CONTACT STATES VEHICLE WILL NOT START. HOWEVER, AFTER WRIGGLING THE IGNITION SWITCH THE VEHICLE WILL START. THE SERVICE DEALER STATED IT WOULD BE AN EXPENSIVE REPAIR, THE WRIGGLING OF THE IGNITION MIGHTL RESOLVE THE PROBLEM.*AK

VEHICLE EXPERIENCED ELECTRICAL WIRING PROBLEMS IN FRONT WINDOWS ON BOTH SIDES. WHEN PRESSING THE BUTTON DOWN TO LOWER THE WINDOW SMOKE CAME OUT OF THE DOOR. CONSUMER TOOK VEHICLE TO A LOCAL REPAIR SHOP, AND REPLACED THE WIRING WHICH CONTROLLED BOTH FRONT WINDOWS. ALSO, THE WIRING BURNED DOWN TO THE CONTROL PANEL.*AK.....CONSUMER PAID $491,98 FOR REPAIRS. *AK

INTERMEDIATE DRIVE GEAR WHICH CONTROLS CAM SHAFT AND VALVE TRAIN FAILED DUE TO NON HARDENED METAL . TOTAL FAILURE OF ENGINE WAS TO ENSUE, ACCORDING TO VOLKSWAGEN(MAKER OF VEHICLE), IF DRIVEN FURTHER. THE CAR WAS BEING USED TO TRANSPORT MY FAMILY TO SEATTLE ,WA FROM SANTA ROSA,CA. THE FAILURE OCCURRED 500 MILES FROM HOME AND 75 MILES FROM NEAREST DEALER. WAS ADVISED BY VW THAT A VW DEALER MUST SERVE AS THE DIAGNOSTIC CENTER . THE FAILURE OCCURED IN WINTER AND WITH VIRTUALLY NO WARNING--THE "CHECK ENGINE " LIGHT ILLUMINATED AND THE ENGINE MADE A GROANING SOUND. THE VAN (EUROVAN 2001) WAS TRANSPORTED BY TRUCK TO CORVALLIS,OR FOR REPAIRS. VEHICLE IS PRRESENTLY STILL THERE AND UNDERGOING GEAR REPLACEMENT. I WAS TOLD BY THE VW SERVICE ADVISOR AT CORVALLIS THAT VW HAD BUILT AN UNKNOWN NUMBER OF ENGINES WITH THIS DEFECT BUT DID NOT KNOW IN WHICH VEHICLES THEY WERE PLACED. THE VEHICLE IN QUESTION HAS 27,000+/- ORIGINAL MILES ON ENGINE AND ALL SERVICES RECOMMENDED BY VW WERE MADE AT VW DEALERSHIPS. I AM THE ORIGINAL OWNER.*AK

MY BRAKES ARE SOFT AND FAIL TO KEEP THE CAR AT REST. THE PROBLEM STARTED ON 09/29/2004. SINCE THEN THE VW DEALER WAS NOT ABLE TO FIND THE PROBLEM EVEN THOUGH MANY PARTS WERE REPLACED. *JB