2016 VOLKSWAGEN GTI Complaints

While driving my 2016 Volkswagen GTI MK7 Autobahn Edition with approximately 37,000 miles, the power steering suddenly and without warning failed completely. The steering wheel became extremely difficult to turn, requiring significant physical force to operate. Simultaneously, both the TPMS (Tire Pressure Monitoring System) warning light and the ESC (Electronic Stability Control) warning light illuminated on the dashboard. I brought the vehicle to an authorized Volkswagen dealership, Deel Volkswagen in Miami, Florida. The dealership diagnosed the issue as a complete failure of the steering rack and pinion assembly and quoted approximately $6,000 for replacement. This failure occurred at only 37,000 miles — far below any reasonable expectation of component life for a steering rack, which should last well over 100,000 miles under normal use. The failure was sudden, with no prior warning signs or gradual degradation. A sudden and total loss of power steering assist while driving at any speed constitutes a serious and unreasonable safety risk, as it dramatically increases the force required to steer and can cause loss of vehicle control. A review of MK7 GTI owner forums and communities reveals this is a recurring and documented issue among this vehicle population, suggesting a systemic defect in the steering rack assembly used in this model. I am requesting that NHTSA investigate whether a safety defect exists in the 2016 Volkswagen GTI steering system that warrants a recall and manufacturer-funded remedy.

NHTSA Recall 24V-110 (VW 20UF). The vehicle is in Limp Mode and experiencing low oil pressure symptoms. It is also subject to Recall 24V-110, which identifies a fire risk due to fuel leakage. Despite the safety hazard, the local Volkswagen dealership has refused to perform the recall repair or diagnose the vehicle, stating it is at their 'discretion.' I am reporting a failure by the manufacturer and the dealer to remedy an active safety defect, leaving me with an unsafe, undriveable vehicle."

I am reporting a safety concern related to Safety Recall 20UF on my 2016 Volkswagen Golf GTI SE and the handling of this recall by an authorized Volkswagen dealership (Pohanka Volkswagen, Capitol Heights, MD). Prior to the recall service, the vehicle exhibited loss of power, intermittent shuddering, and severe difficulty refueling (fuel pump nozzle repeatedly shut off even with a low fuel level). These symptoms were similar to prior EVAP system failures that required replacement of the charcoal canister and EVAP purge (N80) valve earlier in 2025. I brought the vehicle to the dealership on December 29, 2025, specifically requesting completion of Recall 20UF and inspection/replacement of EVAP components if necessary. The dealership initially refused to perform the recall unless I returned the vehicle with less than one-quarter tank of fuel, despite the recall documentation specifying that fuel extraction equipment (VAS5190A or equivalent) is required for this repair. A diagnostic report generated by the dealership listed a “Fuel Pump (in tank)” replacement as a customer-pay repair before later removing it once it was identified as recall-related. After significant delays, the dealership stated the recall had been completed and declined to replace any EVAP components. Since the recall service, the vehicle continues to experience intermittent shuddering and difficulty accelerating. While refueling has temporarily improved, drivability concerns persist, raising questions about whether the recall repair was properly performed and whether the vehicle remains safe to operate. I am concerned about inconsistent handling of a safety recall, improper diagnostic practices, and continued fuel-system-related drivability issues that may pose a safety risk.

Fuel is leaking from near the gas tank when the car is running and creates a puddle- I took my car to the local VW dealership in February to get the Suction Jet Pump Recall completed.

I was driving on the highway, and heard a quiet sound like someone sprinkling sand on my windshield for about 10 seconds. All of a sudden, the sun roof burst and shattered with a loud pop. Luckily the internal slide-able screen webbing kept the glass from entering the compartment (except a bit of glass dust and small shards). I never heard a rock hit, or any other cause. I believe the ‘sand sprinkling’ sound was the ‘spider web’ cracks spreading prior to the burst. Obviously that is extremely dangerous while driving on the highway. If it wasn’t for the internal screen keeping the glass off me, it could have been much worse. I was able to pull off the highway and temporarily secure the glass with some cardboard and packing tape.

Repeated issues with leaking water pump and broken seals under the intake manifold causing vehicle to be underivable.

The contact owns a 2016 Volkswagen GTI. The contact received notification of NHTSA Campaign Number: 24V110000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while driving at an undisclosed speed, the vehicle stalled. There was no warning light illuminated. The contact stated while the vehicle was parked, the contact became aware of fuel leaking from the rear of the vehicle. The vehicle was towed to the dealer where the vehicle was diagnosed with a fuel leak coming from the fuel tank suction pump. The contact was informed that the fuel tank suction pump needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 45,000. VIN tool confirms part not available.

The contact owns a 2016 Volkswagen Golf GTI. The contact stated that while driving at an undisclosed speed, there was an abnormally strong gasoline odor coming from the exhaust. The contact stated that while attempting to fill the tank, the tank failed to accept more than a half tank of fuel. The contact received notification of NHTSA Campaign Number: 24V110000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The dealer was contacted and diagnosed the vehicle with a failure of the fuel pump which was replaced; however, the failure persisted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure but was unable to confirm when the part would be available. The failure mileage was approximately 160,000. VIN tool confirms parts not available.

The contact owns a 2016 Volkswagen GTI. The contact received notification of NHTSA Campaign Number: 24V110000 (Fuel System, Gasoline). The contact stated that while refueling, the gasoline was leaking from the vehicle from an unknown location. The vehicle was taken to an independent mechanic where it was diagnosed that the carbon canister was clogged with fuel and needed to be replaced. The vehicle was repaired started the vehicle was losing motive power. On another occasion, nine months later, the failure reoccurred. The vehicle was taken to a dealer where it was diagnosed and determined that the purge valve, fuel tank, N80, carbon canister, and other unknown parts needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 24,000. VIN tool confirms parts not available.

The contact owns a 2016 Volkswagen Golf GTI. The contact stated that while making a turn at an undisclosed speed, there was water leaking through the sunroof. The contact stated that the sunroof frame had previously been replaced; however, the failure recurred. The vehicle was taken to the dealer, where it was diagnosed that the sunroof frame needed to be replaced for the second time; however, the part was on backorder. The vehicle was not repaired. The manufacturer was made aware of the failure but informed the contact that the vehicle was not covered under warranty. The failure mileage was approximately 34,000.