2009 VOLKSWAGEN JETTA Complaints

WHILE DRIVING THE DASH WARNING LIGHTS ILLUMINATED AND THE CAR STALLED CAUSING COMPLETE LOSS OF ALL POWER STEERING ALMOST CAUSING ME TO LOSE CONTROL AND WRECK. I WAS ABLE TO STEER CAR TO SIDE OF ROAD AND STOP. ONCE STOPPED WAS ABLE TO GET CAR TO RESTART BUT WAS BARELY ABLE TO DRIVE HOME (PERIODICALLY DIED AND HAD TO RESTART, WOULDN'T STAY RUNNING OR IDLE). HAD CAR TOWED TO REPAIR SHOP. THEY HAVE DIAGNOSED PROBLEM AS LOW RAIL FUEL PRESSURE CAUSED BY FAILED HIGH PRESSURE FUEL PUMP. THIS FAILURE CAUSED METAL SHAVINGS TO BE DISPERSED THROUGHOUT ENTIRE FUEL SYSTEM. I'M TOLD THAT THE HP FUEL PUMP, LOW AND HIGH PRESSURE FUEL REGULATORS, AND TANK FUEL PUMP ALL MUST BE REPLACED ALONG WITH A COMPLETE REMOVAL AND CLEANING OF ALL FUEL SYSTEM COMPONENTS. ESTIMATED COST TO REPAIR IS BETWEEN $7,000 AND $10,000. THIS CAR IS A DIESEL TDI. *TR

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE VEHICLE STALLED WITH THE ILLUMINATION OF THE ENGINE FAULT WORKSHOP LIGHT. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY ADVISED THAT THE FAILURE COULD HAVE BEEN CAUSED BY A FAILING FUEL PUMP. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE FAILURE MILEAGE WAS 38,000. THE VIN WAS UNAVAILABLE.

I WAS DRIVING ON THE INTERSTATE, AT ABOUT 68 MPH, WHEN THE ENGINE COMPLETELY SHUT DOWN WITHOUT ANY WARNING WHATSOEVER. THE CAR, HAVING A MANUAL TRANSMISSION, WAS STILL IN GEAR AND SLOWED DOWN VERY QUICKLY WITHOUT ANY WARNING TO OTHER DRIVERS (NO BRAKE LIGHTS). I TRIED TO PUSH IN THE CLUTCH AND COAST TO THE SHOULDER, AND SUCCESSFULLY MADE IT OFF THE HIGHWAY. THE CAR RESTARTED, AND I MADE IT A FEW MILES TOWARDS THE DEALER BEFORE IT HAPPENED AGAIN, LUCKILY ON A LOW-TRAFFIC STREET. THE CAR WAS TOWED THE REST OF THE WAY TOWARDS THE DEALER AND DIAGNOSED AS A FAILED HIGH PRESSURE FUEL PUMP, CAUSING CATASTROPHIC FUEL SYSTEM DAMAGE. THE FUEL RAIL, INJECTORS, PUMP, TANK, AND ALL LINES WILL NEED TO BE REPLACED AS THE RESULT OF THE PUMP FAILURE CAUSED BITS OF METAL FLAKES TO CIRCULATE ABOUT THE FUEL SYSTEM. THE DIAGNOSIS AND LISTED REPAIRS WERE DETERMINED BY THE VOLKSWAGEN DEALER. *TR

CAR STALLED 5 TIMES OVER A TWO DAY PERIOD DUEL TO A FAILURE OF THE FUEL PUMP. DASH BOARD WARNING SAID "ENGINE FAULT WORKSHOP" AND GLOW PLUG WARNING LIGHT CAME ON. OWNER MANUAL SAID TO BRING INTO SHOP SOON. DEALERSHIP FOUND METAL SHAVINGS THROUGHOUT THE FUEL SYSTEM THAT WAS CAUSED BY A FAILED HIGH PRESSURE FUEL PUMP. THE WARNING LIGHTS FIRST CAME ON WHEN THEIR WAS A NEAR EMPTY CONDITION IN THE FUEL TANK. I HAVE HEARD THAT THIS HAS HAPPENED TO OTHERS WHEN FUEL IS LOW. COST FOR REPAIR WOULD HAVE BEEN AROUND $6000, BUT VW WARRANTY COVERED THIS. IF THIS STALL HAD HAPPENED ON THE INTERSTATE IT WOULD HAVE BEEN VERY DANGEROUS. AS IT WAS I HAD A POLICE CAR PUSH ME OUT OF AN INTERSECTION DURING RUSH HOUR TO A SAFE SPOT.

ON SEPTEMBER 26, 2012 WHILE TRAVELING IN ARKANSAS, EASTBOUND ON INTERSTATE 30, AT 75 MILES PER HOUR, MY 2009 VW JETTA SPORTS WAGEN TDI SUFFERED A HIGH PRESSURE FUEL PUMP FAILURE. I WAS TOLD BY THE LITTLE ROCK VW DEALERSHIP THAT I HAD CONTAMINATED FUEL. I FILED AN INSURANCE CLAIM. THE INSURANCE COMPANY HAD AN INDEPENDENT LAB DO AN ANALYSIS ON THE FUEL. THE INSURANCE COMPANY DENIED MY CLAIM BECAUSE THE FUEL WAS NOT CONTAMINATED. THE INSURANCE COMPANY INFORMED ME THAT THE NHTSA HAS REVIVED NUMEROUS COMPLAINTS ABOUT HIGH PRESSURE FUEL PUMP FAILURES ON VOLKSWAGEN TDI ENGINES. I WANT TO ADD MY VEHICLE TO THAT LIST WITH AN INDEPENDENT LAB ANALYSIS STATING THAT THE FUEL WAS NOT CONTAMINATED. IT IS DEFINITELY A SAFETY HAZARD WHEN YOUR VEHICLE STOPS ON A CONGESTED HIGHWAY. ADDITIONALLY, WITH REPAIR BILLS FOR THIS FAILURE RANGING FROM $6,000 TO $10,000 THE NHTSA SHOULD REQUIRE VW TO RECALL THEIR VEHICLES WITH THE TDI ENGINES. *TR

I WAS ON THE EXIT RAMP OF THE INTERSTATE AND THE GO TO WORKSHOP WARNING CAME ON ALONG WITH THE GLOW PLUG WARNING LIGHT. VEHICLE LOST POWER, I WAS ABLE TO GET TO A SIDE STREET AND TURNED OFF VEHICLE, IT RESTARTED AND SEEMED FINE DROVE ABOUT 2 MILES AND STOPPED FOR A LIGHT, CAR STALLED AND WARNING LIGHTS CAME BACK ON. CAR DID NOT RESTART HAD PUSH TO SIDE OF ROAD AND TOW HOME. TOWED TO DEALER FIRST OF WEEK. FOUND TO BE HIGH PRESSURE FUEL PUMP FAILURE OF THE DIESEL ENGINE. THIS IS THE SECOND ONE TO GO BAD FIRST ONE AT 135380 MILES AND NOW AT 228605 MILES ONLY 93225 MILES ON REPAIR JOB. VW REPAIRED THE FIRST ONE, REPLACED ENTIRE FUEL SYSTEM AT NO CHARGE, DO TO FAULTY HPFP. EVEN THOUGH THIS PUMP HAS LESS MILES THEY WILL NOT HELP WITH REPAIR COST. BOTH TIMES CAR DIED AT A MAJOR INTERSECTION AND HAD TO BE PUSHED TO SIDE OF ROAD. *TR

I WAS ON THE EXIT RAMP OF THE INTERSTATE AND THE GO TO WORKSHOP WARNING CAME ON ALONG WITH THE GLOW PLUG WARNING LIGHT. VEHICLE LOST POWER, I WAS ABLE TO GET TO A SIDE STREET AND TURNED OFF VEHICLE, IT RESTARTED AND SEEMED FINE DROVE ABOUT 2 MILES AND STOPPED FOR A LIGHT, CAR STALLED AND WARNING LIGHTS CAME BACK ON. CAR DID NOT RESTART HAD PUSH TO SIDE OF ROAD AND TOW HOME. TOWED TO DEALER FIRST OF WEEK. FOUND TO BE HIGH PRESSURE FUEL PUMP FAILURE OF THE DIESEL ENGINE. THIS IS THE SECOND ONE TO GO BAD FIRST ONE AT 135380 MILES AND NOW AT 228605 MILES ONLY 93225 MILES ON REPAIR JOB. VW REPAIRED THE FIRST ONE, REPLACED ENTIRE FUEL SYSTEM AT NO CHARGE, DO TO FAULTY HPFP. EVEN THOUGH THIS PUMP HAS LESS MILES THEY WILL NOT HELP WITH REPAIR COST. BOTH TIMES CAR DIED AT A MAJOR INTERSECTION AND HAD TO BE PUSHED TO SIDE OF ROAD. *TR

WHILE STARTING TO ACCELERATE AFTER A STOP, MY 2009 JETTA TDI SHUDDERED AND DIED WITH A "MAJOR ENGINE FAILURE" ERROR AND WOULD NOT RESTART. THE CAR WAS BLOCKING TRAFFIC AT A MAJOR INTERSECTION. HAD TO HAVE THE CAR PUSHED OUT OF THE TRAFFIC LANE AND THEN WAITED FOR A TOW TRUCK TO TOW IT TO THE LOCAL DEALER. AFTER ONE DAY THEY SAID THE HAD NO IDEA WHAT WAS WRONG WITH IT. ON THE SECOND DAY THE DEALER CALLED TO SAY THAT THEY FOUND THE FUEL PUMP HAD BLOWN APART AND THERE WERE METAL SHARDS THROUGHOUT MY ENTIRE FUEL SYSTEM AND IT WOULD NEED TO BE COMPLETELY REPLACED (APPROX $8-9000 IN REPAIRS). THEY ALSO SAID THAT THE WARRANTY WOULD NOT COVER IT UNLESS I COULD PROVE THAT I ONLY PUT DIESEL FUEL IN SO HAD TO PROVIDE RECEIPTS FOR MY RECENT FUEL PURCHASES AS WELL AS FUEL SAMPLES. STILL WAITING FOR THE WARRANTY COMPANY TO DECIDE WHETHER OR NOT THEY WILL COVER THE REPAIR SO I AM WITHOUT A VEHICLE WHILE THEY HAGGLE. LUCKILY I WAS ALMOST STOPPED WHEN IT HAPPENED OR IT COULD HAVE BEEN A BIGGER SAFETY ISSUE (ALTHOUGH I WAS IN A CAR IN A BUSY INTERSECTION CAUSING A MAJOR TRAFFIC JAM WITH MANY POTENTIAL CRASHES ALL AROUND ME -- THE HONKING HORNS AND SWERVING CARS ATTEST TO THAT -- AS I SAT WAITING TO BE PUSHED OUT OF THE WAY). *TR

TDI DIESEL ENGINE. ENTERED HIGHWAY, CAR STUTTERED, ENGINE DIED, DISPLAYED WORKSHOP CODE PROBLEM, GLOWPLUG LIGHT FLASHING. RESTARTED ONE TIME, TRAVELED TO PARKING AREA, ENGINE DIED AND WOULD NOT RESTART. CODE WAS P0087, FUEL PUMP PRESSURE FAILURE. NO PREVIOUS PROBLEMS OR HINTS OF THIS ISSUE. SUDDEN ENGINE FAILURE. VERY DANGEROUS, WAS DRIVING UPHILL, THE ONE RESTART ALLOWED ME TO LEAVE ROAD. DEALER NOTED NO FUEL CONTAMINATION. SYSTEM WAS PROPERLY PRIMED ON FUEL FILTER CHANGES. USED A ROSS-TECH CABLE AND SOFTWARE. REPAIR IS EXPECTED TO BE ABOUT $7000.00. PREVIOUS DIESEL 2001 MODEL WAS STILL RUNNING WITH 332,000 MILES WHEN THIS ONE WAS PURCHASED. TDICLUB.COM WEBSITE HAS NOTED MANY OF THESE FAILURES, SEARCH HPFP, HIGH PRESSURE FUEL PUMP. VW IS NOT FURNISHING PUMPS DESIGNED WITH THE US DIESEL FUEL QUALITY IN MIND. VW NEEDS TO CORRECT THIS PROBLEM, THERE HAVE BEEN A LOT OF THESE FAILURES. *TR

I WAS STOPPED AT A TRAFFIC LIGHT ON A BUSY STREET WHEN MY JETTA TDI SPORT WAGON MADE A LOUD RUMBLING NOISE AND STALLED. IT WOULD NOT RESTART AND WAS TOWED TO THE DEALER. THE DEALER FOUND METAL SHAVINGS IN THE FUEL SYSTEM AND SUGGESTED THIS WAS DUE TO GAS CONTAMINATION OF THE DIESEL FUEL SINCE I HAD JUST FUELED MY CAR. HOWEVER THE DIESEL FUEL WAS NOT CONTAMINATED WITH GAS AND THE DEALER REPLACED THE ENTIRE FUEL SYSTEM, BLAMING THIS ON A PUMP FAILURE. I'M GLAD IT DID NOT HAPPEN 15 MIN EARLIER WHEN I WAS TRAVELING 55MPH. *TR