2007 VOLKSWAGEN PASSAT Complaints

TL*THE CONTACT OWNS A 2007 VOLKSWAGEN PASSAT WAGON. WHILE DRIVING 75 MPH, THE CHECK ENGINE LIGHT ILLUMINATED AND THE CONTACT HEARD A LOUD RATTLING NOISE COMING FROM THE VEHICLE. THE VEHICLE THEN LOST POWER. THE DEALER STATED THAT A BOLT SHEERED OFF INSIDE THE ENGINE. AS OF SEPTEMBER 27, 2007, THE DEALER HAD NOT REPAIRED THE VEHICLE. THE VIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 3,500.

COMPLAINT INVOLVES AN ENGINE FAILURE I HAD ON MY 2007 VOLKSWAGEN PASSAT WAGON 3.6L. THE PROBLEM STEMS FROM A FAULTY "OIL PUMP BOLT/CAM BOLT" . THIS PROBLEM HAS BEEN CITED WITH NUMEROUS 3.6L VW OWNERS AND MORE INFORMATION CAN BE FOUND ON THE VW SPONSORED VWVORTEX WEBSITE. I AM FILING THIS COMPLAINT BECAUSE OF THE POTENTIAL FOR FIRE OR PERSONAL INJURY. VW NEEDS TO RECALL THESE VEHICLES AND REPLACE THE FAULTY BOLT BEFORE OWNERS WARRANTIES EXPIRE RESULTING IN COSTLY REPAIRS (TO REPAIR THIS PROBLEM THE ENGINE NEEDS TO BE REMOVED). HTTP://FORUMS.VWVORTEX.COM/ZEROTHREAD?ID=3193697 HTTP://FORUMS.VWVORTEX.COM/ZEROTHREAD?ID=3448589 THANK YOU FOR YOUR ATTENTION TO THIS MATTER. *JB

TL*THE CONTACT OWNS A 2007 VOLKSWAGEN PASSAT WAGON. WHILE DRIVING APPROXIMATELY 65 MPH, THE CHECK ENGINE AND OIL LIGHTS ILLUMINATED. THE CONTACT PULLED OVER AND NOTICED BLUE SMOKE COMING OUT OF THE EXHAUST. HE SHUT THE VEHICLE OFF AND ATTEMPTED TO RESTART IT, BUT WAS UNSUCCESSFUL. THE VEHICLE WAS TOWED TO THE DEALER AND THEY STATED THAT THERE WAS CATASTROPHIC ENGINE FAILURE DUE TO THE DEFECT NUTS FROM THE OIL PUMP. THE DEALER REPLACED THE ENTIRE ENGINE. THE VIN, ENGINE SIZE, AND NUMBER OF CYLINDERS WERE UNKNOWN. THE FAILURE MILEAGE WAS 23,000 AND CURRENT MILEAGE WAS 25,000.

WHEN STOPPED THE ENGINE RPM'S HAS INTERMITTENTLY RAISE SUBSTANTIALLY, TO THE ~1500-2000 RPM RANGE. ALMOST LIKE IT'S RACING. THIS MAKES IT DIFFICULT TO HOLD THE CAR STOPPED. DEALER COULD NOT DUPLICATE THE PROBLEM.

ON HOT DAYS ENGINE RPM'S RAISE SUBSTANTIALLY, TO THE ~1K RPM RANGE. ALMOST LIKE IT'S RACING. THIS ALSO MAKES IT DIFFICULT TO HOLD THE CAR STOPPED WHEN THIS OCCURS. *JB

TL*THE CONTACT OWNS A 2007 VOLKSWAGEN PASSAT. WHEN DECELERATING TO A STOP, THE ENGINE REVS MORE THAN NORMAL. THE FAILURE OCCURS INTERMITTENTLY. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. THE SPEED WAS UNKNOWN. THE CURRENT MILEAGE WAS 7,000 AND FAILURE MILEAGE WAS 600.

THE ENGINE STOPPED WITHOUT ANY EXPLANATION IN THE HIGH SPEED LANE ( FULL TANK OF GAS) WHILE I WAS DRIVING ON I-91. I COULD NOT START ENGINE AGAIN ON FREEWAY. FORTUNATELY, WE DIDN'T HAVE AN ACCIDENT. AAA AND POLICE CAME THERE WITHIN FIVE MINUTES AND WE COULD GET OFF THE FREEWAY BY TOWING. BEFORE STOPPING, THE CHECK ENGINE LIGHT AND EPC LIGHTS CAME ON. MY CAR IS VERY NEW. I'VE JUST DRIVEN MY CAR ONLY FOR TWO WEEKS. THE MILEAGE OF MY CAR IS ABOUT 900 MILES. *TR

COMPLETE/CATASTROPHIC ENGINE FAILURE AT APPROX 1,800 MILES. DEALER STATED BOLT RELATING TO TIMING CHAIN FAILED, CAUSING SERIOUS INTERNAL ENGINE DAMAGE. VEHICHLE WAS REPLACED, BUT NEW VEHICLE HAS SAME ENGINE, AND MANY OTHERS WITH SAME ENGINE ARE HAVING SIMILAR FAILURES.

NO THROTTLE RESPONSE, LONG ACCELERATOR PEDAL REPSONSE FROM A STANDING START OR ROLLING START. TRYING TO MOVE INTO TRAFFIC IS DANGEROUS, PRESS ON THE PEDAL EVEN FLOOR IT AND NOTHING HAPPENS, STUCK IN THE MIDDLE OF AN INTERSECTION COMING INTO TRAFFIC, THEN EVENTUALLY, ALL 280 HP COME ON AND THE CAR ALMOST GETS OUT OF CONTROL IF TURNING. THIS HAPPENS ALL THE TIME. THIS IS A NEW CAR, I HAVE HAD THE CAR SINCE 4/14/07 AND FINALLY TAKING IT TO THE DEALER NEXT WEEK TO SEE WHAT THEY CAN DO. *TR

WITH JUST 12,000 MILES ON THE ODOMETER THE 2007 VOLKSWAGEN PASSAT 3.6L 4-MOTION WAGON, THE CHECK ENGINE LIGHT CAME ON A BLOCK FROM THE HOUSE. I CALLED THE DEALERSHIP RIGHT AWAY AND BROUGHT THE CAR IN THE NEXT MORNING. TURNS OUT THAT MY CAR'S ENGINE HAD A FAIRLY RECENTLY DISCOVERED KNOWN ISSUE WITH SOME SORT OF BOLT IN THE OIL PUMP THAT IS SOMEHOW RELATED TO THE TIMING CHAINS. APPARENTLY, IT'S A NEWLY DISCOVERED DESIGN DEFECT THAT ALLOWS THIS BOLT TO BACK ITSELF OUT AND CREATE BIG PROBLEMS - EVEN CATASTROPHIC ENGINE FAILURE. AT FIRST, THE DEALERSHIP ORDERED A REPLACEMENT OIL PUMP AS A FIX BUT THE MASTER TECH WHO WAS WORKING ON MY CAR WAS CONCERNED THAT OTHER UNSEEN DAMAGE MIGHT HAVE BEEN DONE AN APPEALED TO VWOA FOR A TOTAL ENGINE REPLACEMENT. VWOA MUST HAVE AGREED WITH THE VALIDITY OF HIS CONCERNS AND AUTHORIZED A FULL ENGINE REPLACEMENT. MY CAR'S BUILD DATE WAS 11/05 . I HAVE ALSO READ FORUM POSTS FROM SEVERAL OTHER OWNERS WHO HAVE ALSO HAD THIS PROBLEM (HTTP://FORUMS.VWVORTEX.COM/ZEROTHREAD?ID=3193697). *AK