2006 VOLKSWAGEN PASSAT Complaints

1. STARTED HEARING "TICKING" NOISE FROM ENGINE 2. "TICKING" BECAME LOUDER, SLOW PERFORMANCE 3. REPLACED INTAKE CAM / LIFTERS, H.P. FUEL PUMP, VALVE COVER GASKET AND SEALANT, VACUUM PIPE TO LEAK DETECTION PIPE (ALL 2 TIMES EACH). *TR

I OWN A 2006 VW PASSAT 3.6, ENGINE DIED SUDDENLY AFTER PULLING OUT ACROSS A 45MPH STATE ROUTE, AFTER ENGINE FAILED, THERE WAS NO STEERING OR BRAKES, HAD TO PUSH CAR OUT OF TRAFFIC WITH MY 2 YOUNG SONS INSIDE. YOUNG VW, EASTON PA. STATED THE FAILURE AS A OIL PUMP BOLT THAT HAD BACKED OUT AND SHEARED OFF, CAUSING THE CATASTROPHIC ENGINE FAILURE. AFTER SOME RESEARCH I FOUND 58 FAILURE OF THIS TYPE OF THIS SAME YEAR AND ENGINE, AT: HTTP://FORUMS.VWVORTEX.COM/SHOWTHREAD.PHP?3462993-ATTN-3.6L-OWNERS-HAS-YOUR-ENGINE-FAILED , - THIS IS CLEARLY AN ISSUE VW WAS AWARE OF SEVERAL YEARS AGO, AS EVIDENCED BY THE REPLACEMENT OR REPAIR OF SO MANY, 58+ ENGINES THAT I CAN DOCUMENT, AND CHOOSES NOT TO RECOGNIZE THE ISSUE, I BELIEVE DUE TO FINANCIAL REASONS AS THIS FIX IS $3,000 IN LABOR ALONE. I CONTACTED VWOA, (REF. # [XXX]) AND VW AG, (,REF. NO.: [XXX]) WITH THIS ISSUE AND NEITHER HAD RECOGNIZED THIS AS A KNOWN ISSUE, MY VEHICLE IS OUT OF WARRANTY, AND VW ESTIMATED THE REPAIR AT $12,800 FOR A REBUILT ENGINE. ASIDE FROM BEING ABUSIVELY EXPENSIVE, THIS FAILURE SHOULD NOT BE ALLOWED TO OCCUR RANDOMLY, IN TRAFFIC OR ANYWHERE CREATING A VERY UNSAFE AND LIFE THREATENING SITUATION, VWOA SHOULD BE WELL AWARE OF THESE POTENTIAL PROBLEMS WITH THIS YEAR ENGINE, BY THE MANY THEY HAVE REPLACED OR FIXED AND SHOULD MAKE THE PUBLIC AWARE AND EFFECT A FIX TO PREVENT A LOSS OF LIFE DUE TO THIS KNOWN ENGINE DEFECT. MY VIN # [XXX], 2006 VW PASSAT 3.6L 4MOTION. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

I AM FILING A COMPLAINT REGARDING THE STALLING ISSUES I'VE EXPERIENCED ON MY 2006 VOLKSWAGEN PASSAT 3.6L MODEL. THE DESCRIPTION BELOW IS A HISTORICAL ACCOUNT OF THE PROBLEM AND HOW IT PROGRESSED TO THE CURRENT STATE. I FIRST NOTICED THE ISSUE AROUND 8000 MILES OR SO WHERE THE KEY FOB WOULD GET STUCK IN THE IGNITION. AFTER READING SOME POSTS ON VWFORUM, I WORKED AROUND THE INTERMITTENT ISSUE BY CLICKING THE GEAR SHIFT 3 TIMES TO DISENGAGE THE KEY FOB FROM THE IGNITION. AROUND 24K MILE OR SO, I NOTICED THE STALLING ISSUE IMMEDIATELY AFTER THE CAR WAS STARTED. THIS PROBLEM WAS INTERMITTENT AS WELL AND SEEMED TO OCCUR DURING EXTREME WEATHER CONDITIONS - COLD OR HOT. AT THIS TIME, THE ERROR 'STEERING COLUMN FAILURE' WOULD REGISTER INTERMITTENTLY. AROUND 60K THE PROBLEM PROGRESSED AND THE FREQUENCY OF OCCURRENCE INCREASED. I REPORTED THE ISSUE TO THE DEALERSHIP AND THEY WERE NOT ABLE TO REPRODUCE THE ISSUE. LOOKING BACK AT THE MULTIPLE BLOGS AND FORUMS ON THIS TOPIC, I BELIEVE THE DEALERSHIP SHOULD HAVE BEEN FAMILIAR ENOUGH WITH THE ISSUE THAT FURTHER RESEARCH INTO THE PROBLEM WOULD HAVE BEEN WARRANTED. I WAS NOT AWARE OF THE WIDESPREAD ISSUE AT THE TIME AND DID NOT INSIST ON HAVING THE DEALER RESEARCH THE ISSUE WHILE THE CAR WAS STILL IN WARRANTY. THE INSPECTION FEE WAS ENOUGH TO DETER ME FROM PUSHING FURTHER SPECIALLY IF THE PROBLEM COULD NOT BE REPRODUCED. CURRENTLY, AT 88K MILES, THE PROBLEM OF STALLING WHEN STARTING CAN BE REPRODUCED AT WILL. THERE IS A WORKAROUND POSTED ON THE SAME VW FORUMS OF SPECIFIC STEPS TO START THE CAR THAT I'M CURRENTLY USING. OTHERWISE, THE CAR DOES NOT START AND THE ERRORS 'STEERING COLUMN FAILURE 'IMMOBILZER DEFECTIVE' IS DISPLAYED CONSISTENTLY. WE ALSO EXPERIENCED TWO INSTANCES OF THE CAR STALLING WHILE DRIVING ON THE FREEWAY. I BELIEVE THIS IS CAUSED BY THE SAME IMMOBILIZER ERROR CAUSED BY THE STEERING COLUMN FAILURE AS THE TWO ERRORS DISPLAYED WHEN TRYING TO RESTART. THIS IS A SERIOUS AND LIFE THREATENING ISSUE. *TR

THE PROBLEM THAT I AM HAVING WITH MY 2006 VOLKSWAGEN PASSAT IS THAT WHILE I AM DRIVING THE CAR SHUTS DOWN COMPLETELY. THIS HAS HAPPENED TO ME ABOUT FIVE TIMES THIS YEAR. IT HAS ALMOST CAUSED ME TO BE IN TWO ACCIDENTS AND TO HAVE TO QUICKLY PULL OFF THE ROAD. THE DEALER WANTS ME TO PAY $1,700 TO REPAIR IT. *TR

2006 VOLKSWAGEN PASSAT - "STEERING COLUMN LOCK DEFECTIVE " ERROR MESSAGE. 1. CAR WILL NOT START IMMEDIATELY; SOMETIMES UP TO 20 MINUTES AFTER INITIATING THE STARTING PROCEDURE. 2. FAILURE OCCURS SEVERAL TIMES A WEEK. CONSEQUENCE FOR FIRST INCIDENT WAS A LOST CONTRACT FOR AN INDEPENDENT CONSULTING POSITION. CAR IS CURRENTLY OUT OF SERVICE REQUIRING ME TO USE PUBLIC TRANSPORTATION AND/OR WALK TO WORK AND APPOINTMENTS. 3. ISSUE HAS NOT BEEN CORRECTED. CAR IS CURRENTLY OUT OF SERVICE. *TR

ATTEMPTED TO START 2.0T ENGINE, HEARD ODD NOISES COMING FROM ENGINE BAY...SOUNDED LIKE A DIESEL ENGINE THOUGH IT WAS A GASOLINE/PETROL ENGINE, SHUT OFF AND TURNED ON AGAIN, CHECK ENGINE LIGHT AND LOW OIL PRESSURE LIGHT ACTIVATED...SHUT ENGINE OFF AGAIN AND HAD TOWED TO DEALERSHIP. BOLT THAT HOLDS OIL PUMP SHEARED OFF, OIL PAN SHOWS METAL DEBRIS, DRIVE SPROCKET LOOSE, ENGINE NEEDED TOTAL REPLACEMENT, ENGINE IS TOTAL LOSS, VW CLAIMS NO FAULT FOR REPAIRS, VW NEEDS TO RECALL ISSUE, WITHOUT DEALER WARRANTY, REPAIRS WOULD HAVE COST OVER $7K IF THIS HAPPENED ON THE ROAD IT WOULD HAVE RESULTED IN A LOSS OF POWER AND BECOME A POTENTIAL ROAD HAZARD/ACCIDENT. *TR

TL*THE CONTACT OWNS A 2006 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT THE REPAIR FOR RECALL 06V470000 (VISIBILITY: WINDSHIELD WIPER/WASHER: MOTOR) WAS PREVIOUSLY PERFORMED, THE WINDSHIELD WIPERS MALFUNCTIONED DURING A HEAVY RAINSTORM. THE CONTACT STATED THAT THE WINDSHIELD WIPER MOVED VERY SLOWLY AND MADE THE VEHICLE INCAPABLE OF BEING DRIVEN IN THE RAIN. THE CONTACT HAD TO PULL OVER AND WAIT FOR THE RAIN TO STOP. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO COULD NOT EXPLAIN THE CAUSE FOR FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 58,000. UPDATED 01/18/11 *BF THE DEALER AGREED TO REPLACE THE WINDSHIELD WIPER MOTOR. UPDATED 04/04/11

MY CAR IS 2006 VW PASSAT - 2.0T. AROUND 60,000MILES, CAR BECAME INCREASINGLY HARDER TO START. BUT IT WORKS. AND AT 75,000MILES IT LOOKS LIKE THE BATTERY DIED AND "STEERING COLUMN LOCK" IS DEFECTIVE. SO I TALKED TO THE DEALERSHIP SERVICE GUY, HE TOLD ME THE BATTERY HAD LOW VOLTAGE. SO I CHANGED, BUT IT HAPPENED SAME PROBLEM WITH NEW BATTERY. I DON'T KNOW WHAT HAPPENED ONLY MY CAR OR OTHER VW ALSO HAS SAME PROBLEM. I HAVE 73,000 MILES, I DID IT REGULAR MAINTENANCE SERVICE, AFTER THAT THE CAR WASN'T THE SAME BECAUSE WHEEL SIDE HAD MORE NOISE BUT I TRUSTED DEALERSHIP. DEALERSHIP DIDN'T SAY ANYTHING, SO I THOUGHT EVERYTHING WAS OK. BUT THE SAME PROBLEM HAPPENED. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

2006 VW PASSAT "DEFECTIVE STEERING COLUMN LOCK" WARNING SIGN AND THE CAR WON'T START AT ONCE. *TR

TL*THE CONTACT OWNS A 2006 VOLKSWAGEN PASSAT. WHILE DRIVING APPROXIMATELY 75 MPH, THE VEHICLE STALLED. THE CONTACT PULLED OVER BUT THE VEHICLE WOULD NOT RESTART AFTER SEVERAL ATTEMPTS. THEN A STEERING COLUMN LIGHT ILLUMINATED. AFTER TEN MORE ATTEMPTS, THE VEHICLE RESTARTED; THE CONTACT TOOK THE VEHICLE TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT THE STEERING COLUMN MODULAR NEEDED TO BE REPLACED. THE FAILURE WAS INTERMITTENT AND BECAME PROGRESSIVELY WORSE. THE KEY ALSO BECAME STUCK IN THE IGNITION BECAUSE OF THE FAILURE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 56,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 90,000.