1998 VOLKSWAGEN PASSAT Complaints

BEGINNING IN JUNE 2002, I BEGAN REPORTING TO VW SERVICE CENTERS ISSUES WITH THE SUSPENSION AND DRIVETRAIN. MOST OF THESE ISSUES WERE REFERENCED BY THE NHTSA (SEE 99V248000). ON JANUARY 25, 2005 I WROTE TO VOLKSWAGEN OF AMERICA DETAILING THE SUSPENSION AND DRIVETRAIN ISSUES, INCLUDING REFERENCING THE NHTSA RECALL NUMBERS AND PROVIDING VOA WITH COPIES OF MY SERVICE RECORDS. VOA SUBSEQUENTLY RESPONDED BY SENDING ME A CHECK FOR $692.13, WHICH WAS OSTENSIBLY PROVIDED IN CONNECTION WITH THE LETTER I SENT. YESTERDAY, I WENT TO A VW SERVICE CENTER AND WAS TOLD THAT THE OUTBOARD CV JOINTS NEEDED TO BE REPLACED (VW PART NUMBER 8D0498099BX). WHILE WAITING IN THE SERVICE CENTER LOUNGE, I NOTED THAT TWO OTHER CUSTOMERS, ONE OF WHOM ALSO HAD A 1998 VW PASSAT, WERE TOLD THAT THEIR CV JOINTS AND OR BOOTS NEEDED REPLACEMENT. I HAVE RESEARCHED THIS ISSUE TODAY AND HAVE FOUND ANECDOTAL EVIDENCE THAT A PROPERLY MAINTAINED CV JOINT SHOULD NEVER HAVE TO BE REPLACED AND THAT IT SHOULD BE REGULARLY INSPECTED EVERY 50,000 MILES. I HAVE COMBED ALL OF MY SERVICE RECORDS AND NOT ONCE WAS THIS EVALUATION EVER PERFORMED. IT APPEARS THIS MAY BE A SERIOUS DEFECT OR FLAW IN CERTAIN VW PASSAT MODELS AND BECAUSE IT HAS SAFETY IMPLICATIONS, I WOULD APPRECIATE IT BEING INVESTIGATED. *JB

HAD A CREAKING SOUND IN THE FRONT END OF MY 1998 VW PASSAT 1.8T. TOOK IT IN TO THE DEALER AND WAS TOLD THE LEFT FRONT UPPER CONTROL ARM TIE RODS WERE BAD (AND DANGEROUS) AND HAD TO BE REPLACED AT MY COST. DID THIS AND 6 WEEKS LATER THE UPPER CONTROL ARM ON THE RIGHT FRONT SIDE FAILED WHILE DRIVING AND CAUSED ME TO HAVE AN ACCIDENT. DEALER "FIXED" THIS PROBLEM AT NO CHARGE AND NOW 4 MONTHS LATER THE SAME SOUND IS BACK AND NOW THE DEALER TELLS ME THAT THE MAJORITY OF THE FRONT SUSPENSION MUST BE REPLACED AND EXPECTS ME TO PAY FOR IT. *JB

ABS FAILED, FLASHING LIGHTS CONTINUALLY. SPOKE WITH DEALER IN SEASIDE, CA SAID COMMON EVENT AND NOT WORTH REPLACING. *JB

1998 PASSAT TIMING BELT PREMATURELY FAILED CAUSING VEHICLE TO DIE. *TS ***NO ANS REQUIRED*** *JB

I HAVE A 1998 VW PASSAT THAT HAS HAD IT ABS SYSTEM GO OUT. FROM WHAT I UNDERSTAND THIS IS A COMMON OCCURRENCE WITH THIS CAR. THE ONLY PROBLEM IS WHEN THE ABS MODULE GOES ON THE CAR IT HAS A HARD TIME MODULATING THE BRAKES CORRECTLY CAUSING A DANGEROUS SITUATION. I WILL HAVE TO EITHER BUY A NEW UNIT OR SEND IT OUT AND HAVE IT REPAIRED. *JB

1998 VW PASSAT WAGON 2 WHEEL DRIVE 4 CYL. 1.8 L ENGINE. MANUAL TRANSMISSION VIN: [XXX] THINGS BROKEN ON THIS VW. BLINKING ABS LIGHT ON DASH INDICATING ABS MALFUNCTION. IT INTERMITTENTLY GOES OFF ONCE OR TWICE A YEAR FOR A COUPLE OF MINUTES, INDICATING FUNCTION PROPERLY. TEMP. GAUGE ON DASH READS NO TEMPERATURE OR 0. IT INTERMITTENTLY COMES BACK ON AND FUNCTIONS PROPERLY. I NEED TO PULL SENDING UNIT WIRE AND CLEAN CONNECTOR. DRIVER'S AUTO DOOR LOCK BUTTON MALFUNCTIONS. WINDOW SWITCHES ON DRIVERS DOOR DOESN'T WORK WELL. STEREO PLAYS CD WITHOUT PUSHING THE BUTTON. (GOES ON BUY ITS SELF) LEFT REAR PASSENGER DOOR DOES NOT OPEN FROM INSIDE.. MOON ROOF MALFUNCTIONS. MAYBE WON'T CLOSE AFTER OPENING. BRAKE LIGHT'S DON'T LIGHT UP RIGHT AWAY WHEN YOU STEP ON THE BRAKES. OUTSIDE DOOR LOCKS STICK. WHEN IT RAINS, WATER GETS INTO THE LOCK AND MAKES IT DIFFICULT TO TURN THE KEY INSIDE THE LOCK. PLASTIC DIP STICK GUIDE IS PRONE TO CRUMBLING DUE TO HEAT. (THIS IS THE ORANGE PIECE OF PLASTIC THAT EXTENDS THE LENGTH OF THE DIPSTICK TUBE. ANTENNA GOT SCREWED UP IN RAIN AND WIND. DEC. -05. *JB UPDATED 07/17/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

WHILE CRUISING AT HIGHWAY SPEED IN MY 1998 VOLKSWAGEN PASSAT, 3 EVENTS OCCURRED SIMULTANEOUSLY: A 'POP' SOUND FROM THE ENGINE AREA, COPIOUS WHITE SMOKE (NOT STEAM) FROM UNDER THE HOOD, AND THE ENGINE CHECK LIGHT ACTIVATION. IMMEDIATELY PULLED OVER, AND WHITE SMOKE INCREASED SUBSTANTIALLY FROM (CLOSED) HOOD, FOLLOWED WITHIN 5 MINUTES BY OPEN FLAMES FROM THE PASSENGER FRONT WHEEL WELL. FIRE CREWS WERE ON SCENE WITHIN 10 MINUTES, BUT THE ENTIRE VEHICLE WAS ENGULFED AND A TOTAL LOSS. *NM

98 PASSAT, ABS PUMP IS NOT WORKING ANYMORE AT 106000 MILES. I WANTED TO REPLACE THE PART BUT THE DEALER TOLD ME I HAVE TO PAY $1200.00 JUST FOR THE PART. IS VW USA CONSIDERING A RECALL BECAUSE IN MY OPINION A $1200.00 PART SHOULD NOT FAIL TO WORK SO FAST. *JB

ABS UNIT FAILURE ON MY 1998 1.8 TURBO PASSAT GLS SEDAN AT 92,000 MILES. SENDING UNIT TO BE REFURBISHED BECAUSE VW OF AMERICA WON'T REPLACE IT UNDER A RECALL. *JB

I HAD THE SUNROOF OF MY 1998 PASSAT SPONTANEOUSLY SHATTER. I WAS DRIVING 60-65 MPH WHEN THIS HAPPEN. THE WEATHER WAS OVERCAST WITH LIGHT RAIN. THE TEMPERATURE WAS 37 F. THE GLASS APPEARS TO BE BLOWN OUTWARD. LUCKILY I HAD THE SUNROOF SHADE CLOSED WHICH PREVENTED ME FROM BEING SHOWERED WITH GLASS. *NM