1999 VOLKSWAGEN PASSAT Complaints

CLUTCH PEDAL WENT TO FLOOR IN VERY HEAVY TRAFFIC CAUSING POTENTIAL FOR AN ACCIDENT AND SEVERE INJURY. UPON INSPECTION, FOUND THAT CLUTCH HYDRAULIC HOSE ON THE V6 PASSAT IS INSTALLED SUCH THAT IT RESTS ON AN ADJACENT HOSE. THIS CAUSES ABRASION TO THE HOSE AND ULTIMATELY CATASTROPHIC FAILURE. THIS IN MY OPINION IS A DESIGN / WORKMANSHIP DEFECT THAT NEEDS TO BE CORRECTED. MR

THE VEHICLE DROPPED FROM THE HOIST WHILE BEING SERVICED, THE GM OF THE DEALERSHIP ATTRIBUTED THE ACCIDENT TO TOO MUCH ANTI-CORROSION COMPOUND BEING APPLIED TO THE VEHICLE AT THE TIME OF MANUFACTURING, THE MANUFACTURER WAS CONTACTED. NLM

CONSUMER STATES THAT WHILE DRIVING AND NO WARNING THE REAR COMPARTMENT CAUGHT ON FIRE CAUSING THE CONSUMER TO PULL OVER. DEALER NOTIFIED. NLM

THE LEAK DETECTION PUMP IS PART OF THE EVAPORATIVE EMISSIONS CONTROL ON THIS CAR. WITHIN 2 DAYS OF BUYING IT, THE CHECK ENGINE LIGHT CAME ON. DEALER DIAGNOSED AND REPLACED THE PUMP BUT LIGHT CAME BACK ON NEXT DAY. SAME PUMP REPLACED AGAIN. SEARCH ON INTERNET AND DISCUSSION W/DEALER INDICATES THIS PART (MADE BY SIEMENS) IS A COMMON FAILURE AND WARRANTY ONLY 24,000 MILES. COST WAS $275 FOR ME TO HAVE FIXED. IF NEW ONES COMMONLY FAIL AND THIS IS EMISSIONS RELATED, SHOULDN'T THERE BE A RECALL? IS THIS THE RIGHT PLACE TO REPORT THIS? NLM

VEHICLE HAS BEEN RUNNIING, IT FORCES ANTIFREEZE DOWN WIRING HARNESS, AND SHORTS OUT COMPUTER THAT CONTROLS TRANSMISSION. VEHICLE WILL START TO SHAKE AND STALL OUT. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK

WHILE DRIVING ON HIGHWAY AT 65 MPH GEAR WILL AUTOMATICLY GO INTO NEUTRAL AND SUDDENLY WILL SWITCH BACK INTO A LOWER GEAR. VEHICLE HAS BEEN TAKEN TRHEE DIFERENT TIMES TO DEALER, BUT PROBLEM STILL THERE.*AK

WHILE DRIVING THERE'S A SQUEAKING AND POPPING NOISE COMING FROM UNDER SIDE OF VEHICLE WHEN GOING OVER BUMPS IN ROAD. TOOK VEHICLE TO MECHANIC, AND THEY REPLACED THREE CONTROL ARMS. A SHORT TIME LATER POPPING STARTED AGAIN, AND CONSUMER NEEDED A FOURTH CONTROL ARM. CONSUMER CONTACTED DEALER, AND THEY STATED VEHICLE WAS NOT UNDER ANY RECALL. CURRENTLY, ALL EIGHT CONTROL ARMS HAVE BEEN REPLACED.*AK

CONSUMER HAD TO REPLACE BRAKES EVERY 6000 MILES, AND SHE THOUGHT THIS WAS A PROBLEM BECAUSE FOR THE SAME REASON VOLKSWAGEN ISSUED RECALL 99V131001. BUT WAS TOLD THAT THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. *AK

UPON REPLACEMENT OF THE BATTERY THE RADIO LOCKS DOWN TO PREVENT THEFT. LOCK OUT RESET CODE FAILS AND STEREO CAN NOT BE RESET FOR USE.*AK

WHILE TRAVELING ON THE HIGHWAY AND WITHOUT PRIOR WARNING, ACID START LEAKING FROM THE BATTERY. DEALERSHIP IS AWARE OF THE PROBLEM. *AK THE INVOICE STATED THAT THE BATTERY WAS LEAKING ACID DOWN ON TO THE POWER STEERING RACK CAUSING THE BOOT TO SPLIT, THROWING FLUID OUT OF THE RACK. ALSO THE DIP STICK PLASTIC WAS BROKEN. *SCC