2001 VOLVO S40 Complaints

TL*THE CONTACT OWNS A 2001 VOLVO S40. THE CONTACT WAS NOTIFIED THAT THIS VEHICLE WAS NOT INCLUDED IN RECALL # 01V169000 CONCERNING EQUIPMENT:ELECTRICAL:AIR CONDITIONER DUE TO THE VIN ACCORDING TO THE MANUFACTURER. WHEN THE VEHICLE WAS BROUGHT TO DEALER TO BE SERVICED, VOLKSWAGEN INTERNATIONAL STATED THAT THE VEHICLE WAS EXCLUDED FROM THE RECALL AND COULD DO NOTHING TO HELP. THE CURRENT MILEAGE IS 92,000 ,AND FAILURE MILEAGE WAS 85,000. *AK UPDATED 05/23/07 *TR

TL* - THE CONTACT OWNS A 2001 VOLVO S40. THE VEHICLE HESITATED WHEN ACCELERATING. THE VEHICLE IDLED ROUGHLY. THE DEALER COULD NOT FIND ANYTHING WRONG. THE CHECK ENGINE LIGHT STARTED TURNING ON. THE FAILURE MILEAGE WAS 36,000. THE DEALER REPLACED THE O2 SENSOR THE VEHICLE CONTINUED TO HESITATE , AND THE CHECK ENGINE LIGHT STILL CAME ON INTERMITTENTLY. THE FAILURE MILEAGE WAS 29,000 AND THE CURRENT MILEAGE WAS 86000. *AK

A DEFECT HAS OCCURRED SINCE I PURCHASED THE CAR IN 2005. THE VEHICLE IS A 2001 VOLVO S40 . THE DEFECT IS WITH A RESISTOR FOR THE HEATER BLOWER MOTOR THAT OPERATES ERRATICALLY. THIS TYPE OF DEFECT WAS IDENTIFIED AS NHTSA RECALL NUMBER 01V169000. THE DEALER REFUSES TO REPAIR FOR FREE. THE RESISTOR THAT IS DEFECTIVE AND CAUSING THE PROBLEM. THEY CLAIM THAT THERE ARE NO OUTSTANDING RECALLS ON THIS VEHICLE. PLEASE CLARIFY IF THIS RESISTOR DEFECT IS INCLUDED UNDER THE RECALL. *JB

DT*: THE CONTACT STATED THE VEHICLE LOST POWER WHILE DRIVING 50 MPH AND ENTERED THE LIMP HOME MODE. THE VEHICLE WAS TAKEN TO A PRIVATE REPAIR SHOP, WHO WAS UNABLE TO DETERMINE THE PROBLEM. THE MANUFACTURER WAS ALSO NOTIFIED. THERE WAS A NHTSA RECALL #06V441000, WHICH PERTAINS TO THE VEHICLE SPEED CONTROL. THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN.

DT*: THE CONTACT STATED THE VEHICLE LOST POWER AT ANY SPEED DURING ACCELERATION. THERE WERE NO WARNINGS PRIOR TO THE FAILURE. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER, WHO COULD NOT IDENTIFY THE CAUSE OF THE PROBLEM.*AK

2001 VOLVO S40. WHEN YOU START THE CAR AIR BLOWS HARD INSIDE THE CAR EVEN THOUGH THE FAN KNOB IS ON "0". WILL NOT TURN OFF, DRIVE OR PARK. PROBLEM APPEARED ALL OF A SUDDEN 10 DAYS AGO AND IS PERSISTENT AND CONSISTENT. OTHER OWNERS OF THIS MODEL HAVE IDENTICAL ISSUE, FROM VOLVOFORUMS.COM. *JB

DT*: THE CONTACT STATED THE WINDSHIELD WIPER LINKAGES ARE OUT OF SYNC AND LOCK TOGETHER WHICH CAUSES A LOSS OF VISIBILITY. THIS PROBLEM OCCURRED ON BOTH THE DRIVER AND PASSENGER SIDE WINDSHIELD WIPER LINKAGE ARMS. AFTER THE FIRST INCIDENT THE CONTACT CALLED THE MANUFACTURER'S CUSTOMER SERVICE DEPARTMENT. THEY INSTRUCTED THE CONTACT TO OPEN THE HOUSING ON THE WINDSHIELD WIPER LINKAGE ARM AND TIGHTEN THE BOLT. THE CONTACT DID AS INSTRUCTED ON THE DRIVER'S SIDE AND THIS CORRECTED THE PROBLEM. AFTERWARDS, THE PROBLEM RETURNED TO THE PASSENGER SIDE LINKAGE. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT REPAIR SHOP, AND THEY PERFORMED THE SAME REPAIR THAT WAS INSTRUCTED BY MANUFACTURER'S CUSTOMER SERVICE DEPARTMENT. HOWEVER, THE PROBLEM RECURRED. *AK THE ENGINE WOULD HESITATE WHEN THE CONSUMER ATTEMPTED TO ACCELERATE. THE DEALER REPLACED THE OXYGEN SENSOR. UPDATED 01/25/06. *JB

CONSISTENT ENGINE PROBLEMS WITH 2001 VOLVO S40 RESULTING IN ENGINE DELAYS, IDLING, PAUSING, OVER HEATING AND BURNING WHILE ON THE FREEWAY AND AT BOTH ACCELERATED (65 MPH) AND RESIDENTIAL (35 MPH) SPEEDS. *NM

I OWN A 2001 VOLVO S40. IN EARLY APRIL 2005, MY VEHICLE WAS DIAGNOSED AS BEING IN NEED OF OXYGEN SENSORS, WHICH WAS THE REASON FOR MY "CHECK ENGINE" TO BE ACTIVATED. THE PROBLEM IS THAT MY CAR HAD APPROXIMATELY 25,000 MILES ON IT. AS OF MID OCTOBER 2005, THE "CHECK ENGINE" LIGHT HAS BEEN REACTIVATED AND THE VEHICLE WAS RECENTLY DIAGNOSED AT THE VOLVO DEALERSHIP AS NEEDING NEW OXYGEN SENSORS-AGAIN. CURRENTLY, MY CAR HAS 32,000 MILES AND IS GOING ON ITS THIRD SET OF OXYGEN SENSORS. THE PARTS AND LABOR THAT ARE REQUIRED TO FIX THE PROBLEM ARE TRULY EXPENSIVE. ALL MY COMPLAINTS TO VOLVO HAVE FALLEN ON DEAF EARS. I TRULY BELIEVE THAT THIS PROBLEM IS A RESULT OF POOR ENGINEERING SKILLS, OR WORSE YET, INTELLIGENT ENGINEERING THAT IS INTENDED TO KEEP THE CUSTOMERS SPENDING ON COSTLY REPAIRS. *JB

VEHICLE HESITATES UPON ACCERLERATION , ALMOST TO THE POINT IT FEELS AS THOUGH IT IS GOING TO STALL. I HAD THE VEHICLE TO MY LOCAL VOLVO DEALER BACK IN NOVEMEBER OF 2004, BUT AFTER $700.00 IN DIAGNOSTIC CHARGES NO PROBLEM WAS DETECTED.