2012 VOLVO S60 Complaints

The front windshield has a faulty gasket, I put sealant from Autozone but didn’t help. Water falls down the windshield causing skewed vision. I’m also afraid that there may be some type of short, which can cause damage either parked or driving.

On December 1, 2021 I was driving my 2012 Volvo S60 T5, that I purchased 3/2021 with 99,489 miles on it, on the highway and it stalled without warning after almost crashing. There were no warning alerts or check engine light that came on the dashboard and the car had 1,000 miles until the next oil change. After browsing the internet, we realized that the car had a recall because their vehicles were not warning the driver that there was low oil pressure allowing the driver to continue driving until the engine seized (Recall #R29436; National Highway Traffic Safety Administration campaign #13V592000). The recall was repaired by Prestige Auto on 1/2014. I contacted Volvo of North America who opened up a case and then had the car towed to Portland Volvo in Scarborough, Maine for an appointment on December 14, 2021. On December 15, 2021 Portland Volvo informed us that the vehicle’s engine was beyond repair because of an unfortunate mechanical failure due to lack of lubrication. Later that evening I received an email from Volvo of NA stating that they would cover $750 of the repairs. I emailed back asking to wait for a quote from Portland Volvo on how much it was going to be to repair the vehicle. On December 16, 2021 I was informed by Portland Volvo that she spoke with the district manager and that a used engine costs between $10-14,000. Volvo of North America has now decided to retract their $750 offer to help because the car is now out of warranty but it was due to a manufacturer's defect. I spoke with Prestige Auto (the dealership who fixed the repair) and was told that if the repair was actually fixed then it would have done its due diligence and alerted the driver that there wasn't any oil pressure. I have also read articles on these kinds of issues and it states that a recall is to be repaired until it fixes the issue, and obviously the issue wasn't fixed the first time. I asked for an appeal, was denied and now Volvo wont respond back to emails or calls.

I have a 2012 S60R. I just received the recall notice for the front seat belts last week. In September of 2021, the warning light on the dash board intermittently comes on with a warning sound stating that my rear seat belt is not in use. This happens while starting the car and driving. There are no passengers riding in the rear seats of my car when this happens. I have tried to fasten the rear seat belts, but they do not fasten. I can not have passengers in the car due to the malfunction of the rear seat belts which is a safety issue. My vehicle is available for inspection upon request.

My wife and I were driving to BWI airport for a 10:30am flight from Virginia Beach in the Express Lane on I-95N going 75mph when all of a sudden at 8:30am the engine seized and I got a message telling me I would experience "Reduced Engine Performance" as my car puttered to a stop with white smoke pouring out of the exhaust. Prior to this message I had no warnings or messages on my dashboard. I got out of my car to check my oil and it was completely evaporated, so I called AAA. While we are 1 hour into waiting (it is now 9:30am) on the narrow shoulder of two Express Lanes for a tow truck to take our car to a shop at 11:40am and for a Lyft driver to figure out how to get to us, two VDOT employees told us we had to move our car by 11am otherwise the state police will tow us. I managed to call a local tow company who finally arrived by 10:55am, so we had been stranded in an Express Lane watching cars fly by at 85mph for almost 2 and a half hours before we were able to move. After the first shop took a look and told me the engine was damaged and that they couldn't replace it, I had it towed to a Volvo dealership. 5 days and a $375 diagnostic later, they find that the turbocharger has an internal oil leak and that this and the catalytic converter would have to be replaced for $6k. Aside from now being carless 4 hours from the dealership and missing my wife's birthday celebration without refund, I now have a $6,375 bill that I had no way of preventing due to a manufacturing design flaw in 2012 Volvo S60 T5. I SHOULD have been warned of a low oil situation so I could have at least pulled over and properly tended to it. I SHOULD NOT have to be liable for a Volvo design flaw that may involve faulty piston rings that has apparently affected countless others. This incident put both my wife and I in danger on an Express Lane on a very busy highway. Volvo needs to be accountable for this design flaw.

It looks as if my car should have been included in the 62Vin recall for engine sensor not stating low oil. Car started to knock and shutoff with no warning for low oil pressure. Diagnostic show oil was issue but even when completely drained car still does not display low oil which caused motor to blow. Contacted volvo and they would not add vehicle to recalls even though car year manufactured period and engine vin matched recall.

When I first bought this Volvo there was condensation in both of the headlights then took it for a test drive and I really liked it and when I got back the dealer said if I was to buy it he would take care of both headlights so I assumed that he did but I bought it and left and was driving and then a code came on in the car saying low beam out I was like oh [XXX] so took it back to them they had me go buy $120 light bulb and that wasn't the problem they did some working and testing and said that it was the low beam ballast so I bought 1 for the drivers side and that fixed that problem but then not even a week later the same light came on saying low beam out, took it back and they said that it was the same thing on opposite side on passenger side so they said order the part and we'll fix it I did that took it back to them and they said it was fixed not even a day later and the light was back on swing low beam out I'm thinking that there is an issue that has to deal with some kind of recall with these lights cause there is no way that they should break that easy or quick so please get back to me and let me know thank you INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

This in regards to a vehicle I purchased on March 30, 2021. It is a 2012 Volvo S60 T5 VIN #[XXX]. When I purchased the car it had 99,489 miles on the odometer and when the vehicle became an issue it was at 104,409 miles on the odometer. I purchased it on Craigslist from a physician in Maine. On December 1, 2021 my husband was driving the vehicle on the highway and it stalled without warning after almost crashing. He was able to pull over, start the car back up and drive it home. There were no warning alerts or check engine light that came on the dashboard. After browsing the internet, we realized that the car had a recall due to an oil consumption level issue in 2014 (Recall #R29436; National Highway Traffic Safety Administration campaign #13V592000). I contacted Volvo of North America who opened up a case (case #[XXX]) and then had the car towed to Portland Volvo in Scarborough, Maine for an appointment on December 14, 2021. On December 15, 2021 Portland Volvo informed us that the vehicle’s engine was beyond repair. Later that evening I received an email from [XXX] at Volvo of NA stating that they would cover $750 of the repairs. I emailed her back asking her to wait for a quote from Portland Volvo on how much it was going to be to repair the vehicle. On December 16, 2021 I was informed by [XXX] at Portland Volvo that she spoke with the district manager and that a used engine costs between $10-14,000 and that Volvo of North America has decided not to help because the car is now out of warranty but [XXX] from Portland Volvo admitted it was a manufacturer's defect. Not only has the car been seen periodically throughout its lifetime at Volvo dealerships and was seen in July 2021 due to two recalls that needed to be fixed at Volvo in Exeter, NH. They did a multi-point inspection on the car and everything passed and only 3,500 miles had been put on the car since. I have all the paperwork proving all of this. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

When I purchased the 2012 volvo S60 back in June we started to drive and it said low beam out and later found out that it was the drivers side low beam took it back and they tried a new headlight but didn't work but we found the problem it was the ballast to the hid bulb was bad changed it bam fixed 2 days later the light came back on and said low beam out but this time it was the passenger side took it back and they checked and said that it was the samething the low beam hid ballast so got that they changed it and bam fixed well left there and less than a week later the light comes back in saying low beam out and only its the same side again this time the passenger side, so my question and concern is I can't ve the only one having this issue with my headlights causing me to drive with high beams on which isn't safe so please get back to me with an answer I believe there is something faulty with these S60 r-design hid low beam headlights please help

The contact owns a 2012 Volvo S60. The contact stated while driving 35 mph, the oil pressure warning light was illuminated. The contact pulled over and parked on the side of the road and turned off the vehicle but it was unable to be restarted. The contact stated the vehicle was not drivable. The vehicle was not diagnosed or repaired. A dealer was not contacted. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 13V592000 (Engine and Engine Cooling) however, the VIN was not included in the recall. The manufacturer had not been informed of the failure. The failure mileage was approximately 133,000.

I had the car about 3 months from a dealership. I was driving through the hills near my house, at first no problem. After about 4 turns or so this red light would come on saying something like low oil pressure and the car would stall a bit til I was out of the turn. Didn’t say anything about needing oil or anything. I would have gone straight to a gas station had there been one. My only option was to turn around when I could at the bottom of the hill and go back. The car did the same thing on the way back. I got the car home without further problems parked it and planned to have it checked out first thing when a drove the car again. A couple days went by I decided it was time to have the car checked out. Got in the car started the car and the car started making an extreme rattling noise. I thought maybe something came loose I popped the hood and the rattling increased the the car stalled and stopped running before I got a chance to have it checked out. I started looking on line and found that the were hundreds of people with this same year make and model that the same happened to them . I tried to get my insurance to pay for it but they wouldn’t go for it. I went back online and learned that this issue is something Volvo knew about for many years and said it was limited to models 2012 with vin62 which my car is but only for like a three month period of time during 2012 . I thought they are obviously trying to limit the amount of responsibility they have to people like me who unknowingly purchased a Volvo expecting to have a quality car that would last many years. If you read the hundreds of blogs from people who’s cars engines failed exactly the way Volvo said of the cars Volvo was willing to recall and repair because it is Volvo’s responsibility to do so. I got lucky that the engine didn’t fail as I was driving through the hills. I and others could’ve been hospitalized or killed Thanks to Volvo only informing a very limited few of this issue