1998 VOLVO S70 Complaints

ABS BRAKE UNIT FAILED AT 60K MILES; ALL SERVICE WAS DONE AT DEALER. DOZENS AND DOZENS OF OWNERS HAVE REPORTED THIS TO NHTSA FOR EXACT SAME MAKE AND MODEL. NHTS SEEMS POWERLESS TO TAKE ON THIS ISSUE. HOW MANY DEATHS WILL IT TAKE TO GET SOME ACTION? VOLVO DEALERS AND FORD KNOW WELL THE PROBLEM -- JUST COUNT THE CASH THEY ARE MAKING ON THE REPLACEMENTS, AND THEN MULTIPLY BY 10 BECAUSE MOST ARE NOT WILLING TO PAY $1,000 FOR A $200 PART. *NM

DT*: THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS, THE ANTILOCK BRAKE LIGHT INTERMITTENTLY ILLUMINATED. THE VEHICLE WAS INSPECTED BY A DEALER WHO DETERMINED WHILE THE LIGHT WAS ILLUMINATED, THERE WAS A FAILURE OF THE ANTILOCK BRAKES. ALSO, THE DEALER DETERMINED THE COMPUTER NEEDED TO BE REPLACED. THE MANUFACTURER WAS ALERTED.

DT*: THE CONTACT STATED THE ABS AND TRACTION CONTROL LIGHTS ON THE DASH ILLUMINATED CAUSING BOTH COMPONENTS TO BE INOPERABLE. THIS OCCURRED INTERMITTENTLY. THE VEHICLE WAS DRIVEN TO THE DEALER WHO DETERMINED BOTH SYSTEMS NEEDED TO BE REPLACED. UPDATED 10/31/2006 -*NM

THROTTLE STUCK FULL OPEN WHILE DRIVING!!! THE CAR NEEDED TO BE TURNED OFF TO STOP THE ENGINE FROM REVVING TO MAXIMUM RPM. THIS IS THE SECOND TIME THIS HAPPENED IN ONE YEAR. *JB

DT*: THE CONTACT STATED ONCE THE PASSENGER SIDE DOOR AND BOTH REAR DOORS ARE LOCKED, THEY CAN NOT BE OPENED FROM THE INSIDE. IN ORDER FOR OCCUPANTS TO EXIT THE VEHICLE, WHILE THE DOORS ARE LOCKED, THE DOOR MUST BE OPENED BY SOMEONE FROM THE OUTSIDE. THE DEALER RECOMMENDED REPLACING THE AUTO WINDOW CONTROL AND LOCKS ON ALL THREE DOORS. THE DRIVER SIDE DOOR LOCK FAILED PREVIOUSLY. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER WHO REPLACED THE AUTO WINDOW CONTROLS AND LOCK TO REMEDY THE PROBLEM. THERE WERE NO WARNING INDICATORS PRIOR TO THE LOCK FAILURE.

CONSUMER 1998 S70 ENGINE HAS FAILED ON TWO DIFFERENT OCCASIONS, TIMING BELT SERPENTINE BELT HAS BEEN REPLACED. *TS ***NAR*** THE CONSUMER BELIEVED THIS WAS A PREMATURE FAILURE. THE WATER PUMP WAS LEAKING. THE FRONT SPRING SEAT WAS REPLACED. *JB

THE ABS ANTILOCK BRAKE SYSTEM IN MY 1998 VOLVO S70 FAILED. THE DASHBOARD LIGHT INDICATED ABS & TRACTION CONTROL (TRACS) FAILURE. NORMAL NON-ABS BRAKING REMAINED. RESEARCH ON SEVERAL VOLVO OWNERS WEB SITES (SUCH AS BRICKBOARD: HTTP://WWW.BRICKBOARD.COM/AWD/?MODEL=S70) SHOWED SYSTEMIC FAILURE OF THE ABS CONTROL MODULE VOLVO PART # 9162675 DUE TO PRINTED CIRCUIT BOARD SOLDER CRACKING AFTER 6 YEARS. THE CAR WAS TESTED BY A VOLVO DEALER CONFIRMING ABS CONTROL MODULE FAILEDURE. VOLVO CHARGES A TOTAL $650 TO REPLACE THE UNIT. THE "BRICKBOARD" OWNERS GROUP SUGGESTED A REPAIR SHOP IN CALIFORNIA THAT RESOLDERS THE CIRCUIT BOARD, REPLACES AND UPGRADES FAILED COMPONENTS, TESTS & RETURNS IT FOR $130 PLUS SHIPPING. WE HAD THE OLD BOARD REPAIRED, SINCE A NEW EXACT REPLACEMENT BOARD FROM VOLVO WOULD HAVE THE SAME FAILURE AFTER ANOTHER 5 YEARS. THE REPAIRED ABS CONTROL UNIT HAS BEEN REINSTALLED & THE CAR NOW WORKS PROPERLY, WITH FULL ABS AND TRACS CONTROL. THIS IS NOT THE FIRST PRINTED CIRCUIT FAILURE FROM VOLVO. OUR 1993 VOLVO 940 TURBO HAD TWO BOARD FAILURES: 1, THE RELAY BASE BOARD SOLDER CRACKED, AND RESULTED IN THE OVERDRIVE RELAY NOT WORKING; 2, CRUISE CONTROL OPERATED ERRATICALLY, DUE TO BAD BOARD SOLDER. BOTH OF THESE BOARDS WERE REPAIRED BY OUR LOCAL SERVICE SHOP. WE ARE VERY CONCERNED THAT TWO CRITICAL SAFETY ELEMENTS - THE ABS SYSTEM AND TRACTION CONTROL - ARE FAILING IN A RELATIVELY SHORT PERIOD OF TIME, & BECAUSE OF A FAILURE OF WHAT SHOULD BE A SIMPLE ASSEMBLY OF TESTED PARTS. FURTHER, WE ARE MOST DISTURBED THAT VOLVO'S REMEDY IS A VERY EXPENSIVE REPLACEMENT, WITH THE SAME FAILURE PRONE PART. WORSE, ALTHOUGH WE OPTED FOR A COMPLETE REPAIR, THERE ARE OWNERS WHO CANNOT AFFORD THE FIX. THESE WILL BE DRIVING WITH FAR LESS BRAKING AND CONTROL THAN THE CAR IS CAPABLE OF PROVIDING. *NM

DT: THE VEHICLE WAS LOSING POWER, IT SHUTS DOWN. USUALLY IT WILL START BACK. CAN CUT ACROSS TRAFFIC, AND IT WILL JUST STALL. TOOK IT TO THE DEALER MANY TIMES, AND THEY COULD NOT DUPLICATE THE PROBLEM. THEY PUT DIFFERENT PARTS ON IT TO NARROW DOWN THE PROBLEM. THERE IS NO POWER STEERING AFTER IT STALLS. BACK IN JANUARY THE TURBO WENT IT OUT AND THEY REPLACED IT. THE VEHICLE WAS STILL SKIPPING. THIS STARTED HAPPENING AROUND JANUARY 15, 2005. *NM THE ABS CONTROL MODULE WAS REPLACED. *JB

I HAVE A 1998 VOLVO S 70 WHICH HAS FAILED DC INSPECTION BECAUSE THE OBD SCANNER USED BY THE DMV CANNOT GET A READOUT FOR CATALYTIC CONVERTER, OXYGEN SENSOR AND A COUPLE OF OTHER EMISSIONS RELATED ITEMS. THE CAR ECU SIGNALS "NOT READY". THE CAR RUNS FINE. WE HAVE DRIVEN THE CAR IN ACCORD WITH VOLVO'S RECOMMENDED "STRUCTURED DRIVE" WHICH IS SUPPOSED TO RESET THE COMPUTER. THIS DID NOT WORK. ONE VOLVO SHOP BELIEVES THE ECU IS FAULTY. ANOTHER SAYS THE ECU IS FINE AND ITS THE SCANNER'S INABILITY TO COMMUNICATE WITH THE ECU THAT IS AT FAULT. THIS SHOP ALSO REPORTS THAT HE HAS SEEN SEVERAL SIMILAR MODEL VOLVOS OVER THE PAST MONTH OR TWO WITH THE IDENTICAL PROBLEM. MEANWHILE DV DMV SAYS THEY CANNOT PASS THIS CAR UNLESS THEIR SCANNER GETS POSITIVE AND ACCEPTABLE READINGS. *NM

ENGINE STALLED LEAVING ME STRANDED IN AN INTERSECTION IN RUSH HOUR TRAFFIC. ENGINE WOULD NOT RESTART. POLICE OFFICER HAD TO PUSH ME OFF THE STREET BECAUSE CAR WOULD NOT RESTART. DEALER STILL HAS NOT IDENTIFIED THE PROBLEM. *NM