2016 VOLVO XC90 Complaints

TL* THE CONTACT OWNS A 2016 VOLVO XC90. EACH TIME THE CONTACT ATTEMPTED TO FUEL THE VEHICLE, THE FUEL TANK DOOR DID NOT OPEN. THE CONTACT ATTEMPTED TO OPEN THE FUEL TANK DOOR WITH THE KEY FOB AND MANUALLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 62,000.

REAR DOORS ON THE 2016 XC90 CAN BECOME UNABLE TO CLOSE/LATCH UNDER CERTAIN CIRCUMSTANCES. IF THE WEATHER IS EXTREMELY COLD AND WATER HAS MADE IT INTO THE RUBBER DOOR SEALS DUE TO EITHER MELTING SNOW OR RAIN, THE WATER CAN FREEZE PREVENTING THE DOOR FROM CLOSING ENOUGH TO LATCH. THIS CAN LEAVE THE DRIVER AND THEIR PASSENGER STRANDED ON THE SIDE OF THE ROAD OR AT A REMOTE LOCATION AND UNABLE TO DRIVE THEIR VEHICLE UNTIL THE PASSENGERS ARE ABLE TO REMEDY THE ISSUE BY EITHER MELTING THE ICE OR REMOVING THE ICE FROM THE RUBBER DOOR SEALS. NOTE: THE ICE EXPANDING DOESN'T CAUSE THE DOORS TO OPEN ON ITS OWN, BUT IF ICE IS BUILT UP IN THE RUBBER DOOR SEALS, ONCE THE DOOR IS OPENED (WHETHER THE VEHICLE IS MOVING OR STATIONARY), THE DOORS MAY NOT CLOSE AGAIN DUE TO THE EXPANDED RUBBER DOOR SEALS WITH ICE BUILT UP INSIDE.

THERE IS SOMETHING CALLED AN ERAD, WHICH IS ESSENTIALLY THE VEHICLE CLUTCH FOR MY ELECTRONIC PLUG-IN HYBRID XC90. IT IS THE INSTRUMENT THAT SWITCHES BETWEEN ELECTRIC AND GAS. MINE FAILED. WHEN IT FAILS, WHEN YOU HIT THE GAS ENOUGH TO PUSH IT OUT OF ELECTRIC MODE TO GAS MODE, THE CAR ESSENTIALLY HESITATES FOR 1-2 SECONDS - IT FEELS LIKE IT'S TRYING TO FIGURE OUT WHAT TO DO THEN AN OVERRIDE TO GAS MODE HAPPENS. WHEN I IDENTIFIED THE PROBLEM, I WAS TRYING TO TURN OFF OF THREE LANES OF TRAFFIC TO A SIDE STREET AND THE CAR HESITATED (TEMPORARILY DOESN'T RESPOND TO THROTTLE INPUT) AS I WAS SITTING PERPENDICULAR TO TRAFFIC. THE ALL GAS MODE THEN TURNS ON AND TAKES OVER, BUT IT HESITATES WHICH COULD BE A SERIOUS PROBLEM. I COULD'VE BEEN HURT, BUT, THANKFULLY, I WASN'T. AFTER THAT, I DROVE IT IN FULL-TIME GAS MODE UNTIL IT WAS FIXED (NO PROBLEMS WHEN I DID THAT). IF THIS WERE AN ISOLATED INCIDENT, I WOULDN'T REPORT IT, BUT THERE WERE 4 OTHER VOLVOS SUFFERING FROM THE SAME ISSUE AT MY DEALERSHIP ALONE (VOLVO CARS OF BETHESDA) SO THEY COULDN'T TAKE ME FOR 3-4 WEEKS. THEY SELL FEWER THAN 5% OF THEIR TOTAL FLEET OF THESE T8 ELECTRIC HYBRIDS, SO FOR 5 TOTAL CARS TO HAVE THE SAME ISSUE (2016 - 2018) INDICATES A MAJOR PROBLEM. I'M CONCERNED SOMEONE WHO DOESN'T NECESSARILY HAVE MY AWARENESS OF CARS WHO MAY OTHERWISE FEEL SAFE IN THE CAR'S THROTTLE RESPONSE MAY TAKE AN UNNECESSARY CHANCE AND GET INTO AN ACCIDENT. PLEASE INVESTIGATE. THANKS!

VOLVO RECENTLY HAD A "SERVICE CAMPAIGN" FOR THE COOLANT EXPANSION TANK BLEEDER HOSE. WE MADE AN APPOINTMENT FOR THE REPAIR, BUT THE DAY PRIOR TO OUR REPAIR, VOLVO USA CANCELLED THE SERVICE CAMPAIGN. THIS HOSE THEN FAILED 1-2 MONTHS LATER, SPILLING TOXIC COOLANT ALL OVER OUR DRIVEWAY AND DOWN THE STREET, WHICH OF COURSE HAS MANY PETS AND YOUNG CHILDREN ON IT. THIS ALSOCOULD HAVE PUT OUR SAFETY IN JEOPARDY IF THIS HAPPENED OUTSIDE OR OUR NEIGHBORHOOD. WE PARTICIPATE IN SEVERAL CARPOOLS, AND OTHER PARENTS RELY ON US TO GET THEIR KIDS SAFELY TO THE DESTINATION AS WELL. OUR LOCAL DEALER WAS VERY PROMPT IN COMPLETING THIS REPAIR, BUT THEY ALSO INFORMED US THAT THERE WAS A RECALL ON THE SPARK PLUGS AS WELL. WE HAD NO NOTIFICATION OF SUCH A RECALL FROM VOLVO USA. I THINK VOLVO USA IS FAILING TO TAKE RESPONSIBILITY FOR THEIR VEHICLES GIVEN THE CANCELLATION OF THE SERVICE CAMPAIGN FOR A CLEARLY DEFECTIVE PART AND THE UTTER LACK OF NOTIFICATION OF THE SPARK PLUG RECALL. I AM VERY CONCERNED FOR ALL OWNERS OF THE NEWEST VERSION OF THE XC90, AND THINK VOLVO NEEDS TO BE HELD ACCOUNTABLE.

TL* THE CONTACT OWNS A 2016 VOLVO XC90. WHILE DRIVING 60 MPH, THE VEHICLE CAME TO A COMPLETE STOP ON ITS OWN. THE CONTACT MANAGED TO STEER THE VEHICLE TO THE SIDE OF THE ROAD. THE VEHICLE COULD NOT BE TURNED OFF AND THE GEAR COULD NOT BE PLACED INTO PARK. THE VEHICLE EVENTUALLY SHUT OFF ON ITS OWN. THE CONTACT WAITED A WHILE BEFORE RESTARTING THE VEHICLE AND THEN DROVE TO MONTROSE VOLVO OF CLEVELAND (9600 BROOKPARK RD BUILDING C, CLEVELAND, OH 44129, (216) 351-9999). THE DEALER REPLACED THE ELECTRONIC CONTROL MODULE (ECM). THE FAILURE RECURRED AND THE DEALER REPLACED AND REPROGRAMMED THE ECM AGAIN. THE CONTACT WAS IN THE PROCESS OF A BUYBACK CLAIM. THE MANUFACTURER INITIALLY DENIED THE CLAIM, BUT WERE CURRENTLY REVIEWING THE CLAIM. THE VEHICLE WAS LEFT AT THE DEALER. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 12,500.

ALL WHEEL DRIVE NOT WORKING... ALL WHEEL DRIVE IN THE OFF ROAD MODE IS NOT WORKING

I PURCHASED A 2016 XC90 IN JULY15. SHORTLY AFTER THE PURCHASE, I STARTED TO NOTICE ISSUES WITH THE BRAKES AND VARIOUS OTHER ISSUES. I HAVE TAKEN THE CAR INTO SERVICE 14 TIMES SINCE PURCHASE WITH ON A FEW FOR REGULAR MAINTENANCE. BRAKE PADS AND BOTH FRONT AND REAR ROTERS HAVE BEEN REPLACED, BUT THE BRAKE ISSUE HAS NOT BEEN RESOLVED. I STILL FREQUENTLY BUT RANDOMLY HEAR CLICKING SOUNDS NEAR TO THE BRAKE PADDLE. I AM MOSTLY CONCERNED THAT IT HAPPENS WHEN I AM DRIVING HIGH SPEED WHILE TRYING TO SLOW DOWN. IF ROOT CAUSE CANNOT BE IDENTIFIED AFTER SO MANY ATTEMPTS OF FIXING, I WORRY THAT ONE DAY THIS CAR WILL KILL SOMEONE. I HAVE ATTACHED SERVICE RECORDS AND A RECORDING OF THE CLICKING. IN ADDITION TO THE BRAKE, I ALSO HAVE MANY OTHER ISSUES WHICH CAN BE FOUND ON THE SERVICE RECORD, MOSTLY RECENTLY, THE CAR WAS ON BIG SMOKE WHILE I WAS DRIVING AND FIRE TRUCK HAD TO COME FOR ASSISTANCE. I AM SEEKING YOUR HELP TO SOLVE THE PROBLEM. AS I HAD SO MANY ISSUES WITH THIS CAR AND ONE STILL HAVEN'T BEEN FIXED, I HAVE NO CONFIDENCE TO CONTINUE TO DRIVE THE CAR

TL* THE CONTACT OWNS A 2016 VOLVO XC90. WHILE DRIVING AT AN UNKNOWN SPEED, THE ENGINE HARNESS WIRES SNAPPED AFTER BEING CHEWED THROUGH BY RATS. THE CHECK ENGINE WARNING INDICATOR BEGAN FLASHING AFTER THE FAILURE OCCURRED. THE VEHICLE WAS TAKEN TO 128 VOLVO CARS (614 NORTH AVE, WAKEFIELD, MA 01880, (781) 224-3700) WHERE IT WAS DIAGNOSED THAT THE WIRING HARNESS WIRES WERE SOY-COATED, WHICH ATTRACTED THE RODENTS. THE DEALER STATED THAT THE ENGINE WIRING HARNESS NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 19,000.

THE SUV HAS HAD LOTS OF PROBLEMS WITH THE ENGINE. THE ENGINE HAS STOPPED WITHOUT WARNING NUMEROUS TIMES WHILE IN MOTION. IT EVEN STOPPED ONE TIME ON THE HIGHWAY. THE VEHICLE LOSES POWER IN AN INSTANCE AND FEW TIMES WE HAVE HAD TO TOW THE VEHICLE TO OUR HOUSE AND TO THE DEALERSHIP FOR REPAIR. EVEN THOUGH THIS PROBLEM HAS OCCURED OVER AND OVER (WHICH THE DEALERSHIP HAS ATTRIBUTED TO THE PISTONS MISFIRING), THE DEALERSHIP CAN NOT SEEM TO REPAIR THE ISSUE. WE HAVE ASKED DEALERSHIP/VOLVO TO BUY BACK THE VEHICLE AS IT IS NOT DRIVEABLE AT ALL. EVERYTIME WE GET THE VEHICLE RETURNED AFTER THE REPAIR FROM THE DEALERSHIP, BETWEEN 100-300 MILES THE ENGINE LIGHT COMES ON AGAIN AND MAKES THE SUV NOT DRIVEABLE. WE HAVE COMPLAINED NUMEROUS TIMES TO THE DEALERSHIP TO NO AVAIL. THE SERVICE MANAGER HAS CONFIDED IN US THAT THIS ISSUE HAS OCCURED ON ALMOST ALL THE VOLVO XC90 FROM 2016 AND ONWARDS.

ON 22 DEC 2017, WHILE DRIVING MY VOLVO XC90 HYBRID R-DESIGN, I RECEIVED AN ERROR LIGHT THAT STATED 12 VOLT BATTERY HAD AN ISSUE. I CALLED THE VOLVO DEALERSHIP IN SARASOTA AND SPOKE TO THE SERVICE MANAGER, JOE RICE TO LET HIM KNOW ABOUT THIS ISSUE. WHILE ON THE PHONE, AN ADDITIONAL ERROR LIGHT "ABS" AND THEN A FEW SECONDS LATER A CAR WITH A SQUIGGLY LANES ERROR LIGHT CAME ON. I IMMEDIATELY LOST THE ABILITY TO BRAKE, I LOST THE ABILITY TO STEER, I LOST THE ABILITY TO PUT THE SUV INTO NEUTRAL, I LOST THE ABILITY TO PUT ON MY HAZARD BLINKING LIGHT. ALL I COULD DO IS TAKE MY FOOT OF THE GAS PEDAL BUT BECAUSE I WAS NOT ABLE TO PUT THE SUV IN NEUTRAL, AND HAD NO BRAKES, I CONTINUED TO MOVE. THE SCREEN ON MY FRONT CONSOLE WENT BLACK AND THE MIDDLE CONSOLE WENT BLACK. IF I WAS ON ANY BUSY ROAD OR EXPRESSWAY, I WOULD HAVE IMMEDIATELY BEEN IN AN ACCIDENT. LUCKILY AFTER MILES OF FORCED DRIVING, AND WITH THE HELP OF THE SERVICE MANAGER, APPLY MANUAL BRAKES BY FLOORING THE BRAKE PEDAL AS HARD AS POSSIBLE TO THE FLOOR AND TAP, NOT PUMP. THIS ELECTRICAL FAILURE DEFECT IS SO DETRIMENTAL THAT IT WILL CAUSE ACCIDENTS RESULTING IN DEATH. VOLVO HAS KEPT MY CAR SINCE 22 DEC AND THEY STATED THAT THEY ARE CHANGING OUT THE COMPUTER THAT CAUSED THIS ISSUE. I'M AFRAID THAT VOLVO MIGHT NOT DISCLOSE THIS DEFECT TO NHTSA AND THAT SOMEONE OR SOMEONE ELSE'S FAMILY WITH BE IN AN ACCIDENT RESULTING IN DEATH. THIS IS A VERY SERIOUS PROBLEM AND BEG NHTSA TO LOOK INTO THE MATTER EXPEDITIOUSLY TO RECALL VOLVOS WITH THESE DEFECTS. IF NHTSA MOVES QUICKLY, THEY HAVE THE ABILITY TO PREVENT ACCIDENTS AND DEATH. I'M AVAILABLE TO PROVIDE A SWORN STATEMENT TO THE INCIDENT AND WILLING TO HELP ANYWAY I CAN. THANK YOU FOR YOUR CONSIDERATION, VERY RESPECTFULLY, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).' *PM