2016 VOLVO XC90 Complaints

My car started smoking on the road, I parked it. It smoked, Then it caught on fire.

My vehicle was signaling me to add oil every 600 - 1000 miles around 85,000 miles. The dealership charged me for a chemical treatment to stop the oil burning around 90,000 miles. At about 95,000 miles, my engine failed while driving on the interstate. There was no warning light or degradation of power. Suddenly, the engine lost power, went into limp mode and I could not maintain highway speed. The display flashes "Engine Performance Reduced." My SUV is now parked in my yard. I have paid two Volvo dealerships and a Volvo repair shop to inspect it. They reported oil burning, cylinder scoring and spark plug failure. There is scoring in the #3 cylinder and there is also no compression in the #3 cylinder. They further advised me that ALL engines that fit in my vehicle will experience this oil burning issue and the subsequent pathway to failure. I see evidence that this is a known issue with 2.0L and 2.5L Volvo engines between 2013-16. Of particular note is that several other owners have experienced failure in the #3 cylinder. There is an issue of clogged rings causing oil burning. Oil burning leads to damage to internal engine components like pistons, spark plugs, valves and etc..causing engine failure and ultimately engine fires. Oil burning extends into the exhaust system and also damages catalytic converters leading to failure of those components and even fires. I understand Volvo issued Tech Journals to dealerships but, to date, this information has not been published to the consumer that we may be made hole. This is a major design flaw that creates an expensive and extremely dangerous situation affecting numerous engine parts subject to high levels of heat during engine operation. Any of these parts are susceptible to spontaneously combusting during operation and without warning. It is an extremely dangerous situation. However, I see no evidence of a recall on my vehicle.

*the engine is the part that failed due to excessive oil consumption. *it became a safety risk once it started selecting its own driving speed after dropping driving speed to 31mph on [XXX in Raleigh. *the problem was confirmed by the dealer, Volvo of Cary *it has not been inspected by the manufacturer, police, insurance representatives or others *upon a service visit our technician, Ray Rancell of Volvo of Cary advised that the engine was leaking oil and engine failure would occur if we didn't take care of it so we did to a total of $2879.74 which would keep the engine from seizing. That means we paid to prevent exactly what happened anyway and as I found out later he did not perform an oil consumption test so he had no way of knowing the shape the engine was in but charged for this work anyway. The repair invoice says the customer stated oil leaking on timing belt but that is incorrect. I would have no way of knowing that as the only thing i know about cars is replinishg fluids. We did have to replinish oil often and advised Ray of that but he said it was normal. Thank God I was able to get into the slow lane and prevented any accident but my and my daughter's life was certainly put at risk. There is a known recall for excessive oil consumption which I fould out about later. When I questioned Volvo they said my VIN number was not included in the recall. Clearly, it should have been. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

On September 30, 2025, a 2016 Volvo XC90 T6 experienced sudden engine failure while driving westbound on I-75 (Alligator Alley) at highway speed. The vehicle abruptly went into reduced power mode (“turtle mode”) without warning. This forced the driver to stop on the roadside, creating a serious safety hazard in fast-moving traffic. Component/system that failed: Engine / Power Train. An independent repair facility performed diagnostics on October 6, 2025, including a compression test. Results confirmed that one cylinder had lost compression due to a failed cylinder head. The mechanic attributed this to excessive oil consumption from defective piston rings, a condition documented in Volvo technical bulletins. Inspection: The vehicle was inspected by an independent service center. Photos and test results are available for inspection upon request. The manufacturer was contacted and denied assistance, citing mileage, despite known oil consumption defects in this engine family. Safety risk: The sudden loss of power at highway speed put the driver and other motorists at risk of collision. With no advance warning, the driver was left stranded on a dangerous stretch of interstate. Reproduction: The failure has been confirmed through diagnostic testing and inspection by the independent service center. Manufacturer/police/insurance inspection: The manufacturer has been notified, but no inspection by Volvo has occurred to date. No police or insurance inspection was performed. Warning messages or lamps: Prior to the breakdown, no warning lamps or messages indicated impending failure. The first and only symptom was the sudden loss of power on the highway. Incident cause assessment: Based on mechanic’s findings, the underlying cause is piston ring/oil consumption defect leading to cylinder head failure. This defect is widely reported in Volvo vehicles with this engine and represents a safety-related condition.

Known supercharger leak on 2016 Volvo XC90 at 60,000 miles. Numerous reports of the same failure. Dealer and Volvo declined goodwill repair. Potential safety/fire issue if oil leakage worsens

The rear two car doors will not open. It started months ago with the left side and now is both doors. This is dangerous if anyone in the rear of the vehicle should need to exit in a timely manner. The dealership knows this is an issue, but says they are not obligated to fix it for free because there isn’t a recall yet.

SRS warning light and was told that is is due to a faulty misassembled wiring in the seat harness. Possibility of the airbags not deploying correctly in case of a crash. The dealer has confirmed that it is the seat harness that needs to be replaced. Due to the Month/Year of the vehicle it does not fall under the original recall which was only for vehicles that were manufactured between Jan/May 2015.

Backup camera not activating when in reverse sporadically. My recorded video of this happening: [XXX] Issue has been brought to the Volvo dealership service department. Remedy from the Volvo service has been to update software but it has not corrected the issue. Multiple of owners have encountered the same issue which is widely documented online. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

This car is consuming oil and has the potential to catastrophically fail, or catch fire.

I am filing a safety complaint regarding a failed rear door latch actuator in my 2016 Volvo XC90. This is a known issue among Volvo owners, yet there appears to be no recall or corrective action. The defect causes the door latch actuator to seize, rendering the affected rear door completely inoperable from both the inside and outside. This means passengers seated in the rear are unable to open the door to exit the vehicle. This is an extremely dangerous and potentially life-threatening hazard. In the event of an emergency—such as a fire, collision, or submersion—rear seat passengers would be trapped inside the vehicle with no way to escape. This failure compromises basic vehicle safety standards, as all doors should be fully functional to allow for emergency egress. I strongly urge the NHTSA to investigate this recurring defect in Volvo vehicles and require Volvo to address it promptly before it results in serious injury or death.