VOLVO Complaints

The contact owns a 2022 Volvo VNL860. The contact stated that upon attempting to drain the driver’s side air tank, he noticed that the air tank flaring was loose. The service technician tightened the flaring. Additionally, the contact stated while driving at an undisclosed speed, he noticed that the screws of the visor light located outside the windshield were falling. The contact then noticed that the visor cover was vibrating. The contact veered to the side of the road and inserted the screws in the visor cover and attempted to tighten the screws; however, the failure persisted while driving. The contact used a plastic bag to hold the visor cover into place. Additionally, the contact stated while driving 5 MPH and depressing the accelerator pedal, the vehicle was making an abnormal sound and hesitated to respond. The contact veered to the shoulder of the road. The vehicle was taken to an unknown dealer, where it was diagnosed that the rubber located between the two metal turbo pipes needed to be replaced. The vehicle was repaired. Additionally, the visor light cover screws were replaced. The manufacturer was not notified of the failure. The failure mileage was approximately 168,000.

I just purchased car two weeks ago. Got home and tried to familiarize myself with the car. Very intricate car with lots of technology. It is a mainframe on wheels. To my shock, there is no written owners manual in the car. I have been trying to go to the dealership, and customer service, to get said owners manual. I offered to pay for one myself. I am told for environmental reasons that it does not exist. The owners manual is available on the center console of the vehicle. WHAT? What if I am on the side of the road and can't turn on my car, I can't access a manual. Can this be legal? This is not safe. How do we not have a law to require a manual be available for a car sold in the US?

The contact owns a 2015 Volvo XC60. The contact stated while driving 30 MPH, the vehicle inadvertently stopped without driver input. The contact was able to drive the vehicle to the residence. The vehicle was taken to an independent mechanic and the mechanic repaired the parking brake actuator. The manufacturer was not contacted. The failure mileage was 121,000.

The contact owns a 2018 Volvo XC90. The contact stated that after coming to a stop at a stop signal, the vehicle lost motive power. The contact stated that the vehicle was able to restart; however, the failure recurred. The vehicle failed to restart, and no warning lights were illuminated. The vehicle was taken to a local dealer, where it was diagnosed that the starter motor fuse needed to be replaced. The vehicle remained at the dealer awaiting the parts for the repair. The manufacturer was made aware of the failure. The approximate failure mileage was 101,000.

The hood will indicate it is latched but it only partially latches then while driving it will begin to vibrate violently

The first incident happened back in Oct 2022. I took the car to local Volvo dealer, Rusnak Pasadena, and they said I needed the secondary battery replaced. They replaced it and the car worked for a few weeks until the alarm regarding the power steering failure came on again while my wife was turning left. I brought the car home carefully since it was a short distance from home. My wife was very scared because she almost had an accident and she doesn’t want to drive it any more….We didn’t drive the car for more than a month. On Jan 5, 2023, I took the car to the Rusnak dealer in Pasadena Ca. and they diagnosed it as: “Internal failure in power steering rack” needed replacement (see attached). They quoted me more than $3,350 to be fixed and they were not sure if warranty of 4 years would cover it. We then took it to JK Volvo Specialists, who I have known for years . They made a special order via Rusnak Volvo for the steering gear unit and it took two weeks to get it …See attached invoice that details the repairs needed to be replaced and total cost of $2500. This caused us to have to rent a car for a week, while we waited for the part to arrive. An additional $235. We believe that the failure of this electrical power steering, was not due to our neglect or error, and according to NHTSA report which states : “Electrical system malfunctions run deep enough to put people in danger, and in fact Campaign number 18V00000 states that some models, such as xc40, have faulty Vehicle Connectivity Module software..."

We have experienced three major defects with this vehicle. First and most concerning is the intermittent blackout of the driver's instrument panel (aka driver's information module, DIM). Second most conerning is the defect in the trailer lighting control module that leaves stop, running and signal lighting on our trailer unreliable. Both of these defects appear to be design or manufacturing defects that can be corrected by upgrading the relevent parts. The third defect is in the design of the traction control system that has no physical switch readily accessible to the driver for temporary use in emergency situations, but rather is buried in the MyCar software selection, labeled "Sport Mode." This design requres a driver to override the traction control during the entire driving session, leaving the car without traction control when it might be needed during the same inclement road conditions that would warrant momentary deactivation of the system. Ie, in icy conditions one would want traction control on most times, but not when starting on ice or mounting snow berms at driveway exits, etc.

It has come to my attention my 2014 Volvo s60 has a well known and documented problem of excessive oil consumption internally. It has to do with the pistons and the pump rings and is well known by Volvo since 2013. It is not a leak but an issue with the manufacture which seems like an obvious reason to recall and make them fix it. How do we not know more crashes or fires aren't caused from this when the company is clearly trying to cover it up??!! I was not aware of it before I purchased the vehicle but received a letter from Volvo stating the issue and the extended warranty will be added from 8 years or 100,000 miles. However, the years start from when the vehicle was first sold, in my case 8/31/13 so even though I have not exceeded the 100K miles they will not fix my problem. They quoted me $9k for the repair and claimed they could do nothing else about it. How can it be a company knows for years this is an issue and doesn't warn buyers nor do they do anything to try and remedy the issue until they see a class action lawsuit coming..???? the NHTSA MUST GET INVOLVED TO HELP CONSUMERS. THIS IS A WIDLEY KNOWN AND DOCUEMNTED ISSUE. If I was not aware or cared about my car other then the scheduled oil change it could blow up and injure me or another driver easily if their is no oil in the car. That is absolutely unacceptable. How can you allow this to not be recalled? It has been known and is allowed to not be remedied? They are even reimbursing people who had already paid for this repair so it seem obvious they know its now right but until someone forces them to fix it, they can just quietly fix the bare minimum. The fact it is not known to the public should alone be a safety issue, people don't buy a $30k car to drive around with oil in the back and have to worry their car will explode if they don't add oil every 1k miles. As I said, I got a letter for an extended warranty that doesn't even apply and when I called volvo they said nothing can be done. PLEASE HELP

The contact owns a 2018 Volvo S60. The contact stated that the HVAC system fan was inoperable, and the front windshield could not be defrosted. The vehicle was taken to the local dealer who replaced the fan, and the failure was remedied. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 77,000.

The contact owns a 2022 Volvo XC40. The contact stated while dropping off her niece at school, the vehicle was at a complete stop with the brake pedal depressed; however, the vehicle accelerated unintendedly and drove over the pavement. The brake pedal was depressed but failed to respond. The vehicle crashed into the wall of the school and crashed into the school fence. The curtain air bags were deployed; however, the front driver's side air bag failed to deploy. The contact sustained pain in the right shoulder. The contact received medical assistance the following day. A police report was filed. The vehicle was towed to a tow lot. The manufacturer was notified of the failure and referred the contact to a Volvo Collision Center. The Volvo Collision Center took the vehicle to their location and informed the contact that they were awaiting a Volvo engineer to diagnose the vehicle. The vehicle was not diagnosed nor repaired. The failure mileage was approximately 7,000.