2023 VOLVO C40BEV Complaints

Persistent steering wheel vibration at highway speeds (60-80 mph), present from the first drive within two hours of taking delivery of this Certified Pre-Owned vehicle on April 14, 2026 at 21,075 miles. No warning lamps or messages. The vibration is constant at highway speed, not intermittent, causing driver fatigue and distraction during sustained highway driving. This is a known defect documented in Volvo Technical Journal TJ 36752.3.0, classified under function group 4661 (drive shaft). Kline Volvo of Maplewood, MN confirmed the vibration and performed the TJ-prescribed repairs: tire balancing, tire replacement, and driver's airbag module replacement containing an oscillation damper. Volvo's own TJ notes this repair only "lessens" the vibration. The vibration improved but in my assessment has not been fully resolved. A second Volvo dealer's service manager independently acknowledged the issue and consulted Volvo's regional service representative, who confirmed no further fix is currently available beyond the TJ repair. I have escalated to Volvo executive leadership in writing and am awaiting response. The vehicle is available for inspection.

Car was parked at my house. After a heavy heavy rain, I saw 1/2" standing water on the passenger side floorboards. The cowl drainage had been blocked, and I was told water had found it's way into the cabin. It's an EV, so this is a serious issue. My climate control was inoperative, the tire pressure sensors also affected. And not sure what other systems may have been damaged. This had never happened before, and my repair estimate is $5,000.00. It is unfathomable that a car of this level (and price) could have a design that would allow this situation. Thank you for your attention.

I purchased a used 2023 Volvo C40 that was represented as Certified Pre-Owned. Shortly after purchase, the vehicle developed persistent grinding noises during braking, vibration, and mechanical noises that occur even after normal driving. The vehicle has been returned to the selling Volvo dealer multiple times for diagnosis and repair. Dealer service records state that brake rust was “cleaned” and that the issue was resolved; however, the grinding noise persisted immediately upon pickup. Multiple dealership employees acknowledged hearing the noise. The dealer drove the vehicle over 140 miles attempting to replicate the issue, but no permanent repair was made. I later observed significant corrosion and deterioration on brake and suspension-related components. In addition, the vehicle produces a loud thumping noise from the air conditioning system, which was documented via video and heard by dealership management, but the dealer stated they could not replicate the issue. Despite repeated service visits, the braking noise and mechanical concerns remain unresolved. I am concerned these conditions may affect braking performance, vehicle stability, and overall vehicle safety.

The contact owns a 2023 Volvo C40 BEV. The contact stated that while coming to a stop, the contact depressed the brake pedal and the vehicle lunge forward. The contact also stated that the steering wheel became inoperable with several unknown warning lights were illuminated. The contact stated that while driving to and arriving at the residence, the contact was unable to shut off the vehicle. The contact attempted to turn off the vehicle with the key fob and instrument panel, but the vehicle failed to shut off. The vehicle was towed to the dealer but was not diagnosed or repaired. The dealer was able to shut off the vehicle. The manufacturer was made aware of the failure. The failure mileage was approximately 11,100.

I was at a traffic light today and my rear passenger window just completely spider webbed, while my daughter was in the back seat. I had to pull over and clean as much glass from the window to prevent falling on her and causing any additional damage. There were no other vehicles or pedestrians around. The only thing I can think of is that it was temperature related from being in the sun for a few hours and then having the AC on for about 5 minutes. I have researched on different volvo forums and threads and see other owners having similar issues. [XXX] [XXX] Thermal stress and expansion: When exposed to high temperatures, the glass expands, and if this expansion is uneven (perhaps due to varying thicknesses or materials), it creates thermal stress, potentially weakening the glass. When I reported the incident to the dealership they denied any other complaints or recalls instantly put the blame on an external impact without even inspecting the vehicle. There has been no official inspection by any party. The soonest the dealer will see it is on 8/12/25 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Re. R10320 Volvo sent a recall notice regarding the rearview camera being unavailable when vehicle is placed in reverse. This is an issue that affects me/my car almost daily. The notice is dated June 27, 2025 and was told an Over The Air update would be available. I do not live nearby a Volvo dealer so rely on the ability to update the software remotely. However the OTA option is not recognized by my vehicle. When I called Volvo they told me there is no date by which the OTA update will be available and advised me to visit a dealer. Please encourage Volvo to make this important update available via OTA. Thank you.

After having our car repaired per NHTSA recall 25V-282 we are still having issues with malfunctions of the backup camera system including warning messages that the camera is unavailable during attempts to drive in reverse.

Cameras stopped working and getting message “camera temporarily not available”. But does not appear to be temporary. Lots of discussion of this issue on message boards but nothing from Volvo.

There are frequent errors with the infotainment. Often times, when backing up—the screen will say “back up camera not available.” Recently, I experienced a problem where the blinkers were not working until I reset the software on the car.

Three issues: 1) in One Pedal Drive mode car when fully stopped on level ground and in Drive (at traffic signal) will accelerate rapidly without any driver contact with accelerator pedal. This happens once to several times a month. In the first incident the car entered the intersection before I stopped the car with the brake pedal. In another incident the car did this when a pedestrian was in the crosswalk. If I had not intervened the car may have hit the pedestrian. 2) the lane keep assist function will steer the car TOWARD large vehicles in adjacent lanes. This happens most often on curved sections of highways with large slab sided vehicles such as passenger buses and semi trailers. Collision avoidance requires driver intervention to steer the car away from the adjacent vehicle. 3) the rear view camera display in the vehicle center screen has stability issues. The display either does not start upon placing car in Reverse or lags or crashes during reverse movement.