VOLVO Complaints

I need new rear brakes and rotors at 26,296. I have leased cars for the past twenty plus years and never had to replace brakes/rotors after a year and a half.

While driving the vehicle the "SRS Airbag" warning light comes on, I took the vehicle to the dealership which indicated the "seat harness" would need to be replaced. The seat harness has a integrated chip to alert the airbags to work properly. Volvo has had previously recalls for this issue on 2016 XC 90 vehicles but my VIN isn't included in the recall, I feel they need to expand the recall knowing their are several vehicles having this exact issue. Air bags are federally regulated and this is a safety related issue.

This has happened multiple times on the highway going 60 mph. And at slow speeds, last time on an entrance ramp onto the highway. The vehicle will shut off, as if the key has been turned off. But it hasn't been touched. Steering becomes difficult and I have to try and get off the road. Once I get pulled over and put it in park, it will start and run normally for a time. It most often happens when i turn to the right fairly tight. But not exclusively. Today after driving it approximately 120 miles with one shut off, my check engine light came on and it was difficult to get started again. This is absolutely a Hazzard to others and myself

The contact owns a 2020 Volvo VNL-860. The contact stated that her husband was driving at 65 MPH and towing a 53-foot trailer, and the steering wheel would overcompensate while making adjustment, left or right to stay centered in lane. The failure lead to constant steering adjustments. The contact stated no warning light was illuminated. The contact took the vehicle to the dealer to be diagnosed. The contact was informed that the leaf springs and bushings needed to be replaced. The failure persisted and the vehicle was taken to a second dealer were it was diagnosed and had the gear box replaced. The contact stated that the failure recurred. The manufacturer had been informed of the failure. The failure mileage was approximately 90,000.

Driving down the interstate in rush hour at 30 mph, the entire entertainment system as well as the dashboard went black and went through a system restart. The dashboard, including spedometer and related controls were black and unusable for approximately 10 seconds. Approximately 3 minutes later, the system reboot again and all visual aids were unusable for 10 seconds or so.

On December 1, 2021 I was driving my 2012 Volvo S60 T5, that I purchased 3/2021 with 99,489 miles on it, on the highway and it stalled without warning after almost crashing. There were no warning alerts or check engine light that came on the dashboard and the car had 1,000 miles until the next oil change. After browsing the internet, we realized that the car had a recall because their vehicles were not warning the driver that there was low oil pressure allowing the driver to continue driving until the engine seized (Recall #R29436; National Highway Traffic Safety Administration campaign #13V592000). The recall was repaired by Prestige Auto on 1/2014. I contacted Volvo of North America who opened up a case and then had the car towed to Portland Volvo in Scarborough, Maine for an appointment on December 14, 2021. On December 15, 2021 Portland Volvo informed us that the vehicle’s engine was beyond repair because of an unfortunate mechanical failure due to lack of lubrication. Later that evening I received an email from Volvo of NA stating that they would cover $750 of the repairs. I emailed back asking to wait for a quote from Portland Volvo on how much it was going to be to repair the vehicle. On December 16, 2021 I was informed by Portland Volvo that she spoke with the district manager and that a used engine costs between $10-14,000. Volvo of North America has now decided to retract their $750 offer to help because the car is now out of warranty but it was due to a manufacturer's defect. I spoke with Prestige Auto (the dealership who fixed the repair) and was told that if the repair was actually fixed then it would have done its due diligence and alerted the driver that there wasn't any oil pressure. I have also read articles on these kinds of issues and it states that a recall is to be repaired until it fixes the issue, and obviously the issue wasn't fixed the first time. I asked for an appeal, was denied and now Volvo wont respond back to emails or calls.

The contact owns a 2011 Volvo XC90. The contact stated that the check engine warning lights was illuminated. The vehicle was not taken to a local dealer. The manufacturer was informed of the failure and suggested that the vehicle be taken to a dealer to be diagnosed. The failure mileage was approximately 128,000.

Complete power failure of the vehicle. Inability to start or move the car. Car cannot be locked, wheels are locked, no power to the vehicle

Almost once a month my car with think there is something in front of it and activate the emergency brakes. It causes huge strain to the brakes and almost makes me crash and puts the people in front of me and behind me at risk. I've turned the setting to a lower sensitivity to try to avoid this but it doesn't matter. The car does the worst on turns as well and thinks cars in the opposite lanes while turning are in your lane and will cause the system to react. On small roads the car will try to move your car to correct in the lane but it's too small and runs the risk of going off the road or go into oncoming traffic. Most of the time I just have to turn this setting off entirely since it's more dangerous than helpful.

My XC40 has 24, 500 miles on it, and it has already had three sets of brake rotors replaced. The dealership reported "warped rotors" on my front brake rotors in the summer of 2021 at 15,000 miles and replaced them. Now at 24,500 miles, both the front and rear rotors were again "warped" and replaced by the dealership noting that the "rotors had pad transfer marks".