VOLVO Complaints

DRIVING DOWN THE HIGHWAY, POWER STEERING WENT OUT ALL OF A SUDDEN MAKING IT VERY DIFFICULT TO STEER. HARD TO MAKE TURNS. HAD IT INSPECTED NEXT DAY- AND THE POWER STEERING LINE HAD RUPTURED. I NOW HAVE TO HAVE THE ENTIRE LINE REPLACED.

2015.5 VOLVO S60 T5 DRIVE-E, LESS THAN 13K MILES. BOTH THE LEFT AND RIGHT FRONT FENDER SURFACES, JUST BEHIND THE FRONT HEADLIGHTS, ARE EXTREMELY HOT TO TOUCH AFTER NORMAL DRIVING. BENDING DOWN TO LOOK UNDER THE CAR, I HAD PUT MY HAND ABOVE THE FRONT WHEEL AND NOTICED THE FENDER AREA WAS EXTREMELY HOT TO THE TOUCH. THE CAR HAD BEEN DRIVEN NORMALLY AND WAS IN MY GARAGE AT THE TIME; THE CAR WAS NOT IN THE HOT SUN. THE AMBIENT TEMP WAS APPROX. 78F. USING A HAND HELD NON-CONTACT THERMOMETER, THE FRONT FENDER SURFACE TEMPERATURE BEHIND THE FRONT HEADLIGHTS WAS MEASURED - IT APPROACHED 140F AT BOTH FENDER SURFACES. SINCE THESE FRONT FENDERS ARE READILY ACCESSIBLE BY SMALL CHILDREN, THESE SURFACES CAN BE POTENTIALLY DANGEROUS FOR SOME TIME AFTER THE ENGINE HAS BEEN SHUT OFF. AS NOTED IN ASTM C1055, SHORT DURATION BODILY CONTACT AT 140F COULD BE POTENTIALLY DANGEROUS CAUSING 1ST DEGREE BURNS. WHEN ONE OPENS THE ENGINE HOOD, IT APPEARS THE HOT FENDER SURFACES ARE THE RESULT OF VEHICLE DESIGN. A BLACK METALLIC UPPER BODY BRACE CONNECTS THE HOT RADIATOR TO THE LEFT AND RIGHT FENDER AREAS. BASED ON THIS OBSERVATION, ONE CAN ONLY ASSUME ALL 2015.5 VOLVO S60'S HAVE THIS ISSUE AND SHOULD BE EASY TO INVESTIGATE/VERIFY. I DON'T BELIEVE THE TEMP I OBSERVED (140F) ACCOUNTS FOR WORST CASE SCENARIOS, SUCH AS UNDETECTED ENGINE FAULTS (EXCESSIVE ENG TEMPS). UNDETECTED FAULTS COULD CREATE SIGNIFICANTLY HIGHER FENDER SURFACE TEMPS. NO WARNINGS OF HOT FENDER SURFACE TEMPS WERE FOUND IN THE 2015.5 S60 OPERATING MANUAL, NOR WERE THERE ANY STICKERS IN THE CAR NOTING SUCH. NHTSA WEBSITE INDICATED THAT THE MANUFACTURER HAD NOTED EXCESSIVE TURBO COOLANT HOSE TEMPS. SINCE THIS APPEARS TO BE A DESIGN ISSUE ASSOCIATED WITH THE CAR ITSELF AND THIS IS A POTENTIAL BURN ISSUE FOR UNSUSPECTING SMALL CHILDREN, THIS COMPLAINT SHOULD BE INVESTIGATED IMMEDIATELY.

SHORTLY AFTER MOVING TO NORTH CAROLINA, I BEGAN TO SMELL FUEL. I FIRST THOUGHT THAT IT WAS THE GAS CAP AND REPLACED IT. THE SMELL CONTINUED TO GROW STRONGER AND STRONGER, TO THE POINT I COULD NOT KEEP IT PARKED IN MY GARAGE IN MY TOWNHOME DUE TO THE SMELL OF GAS WHICH WOULD PERMEATE THE ENTIRE HOUSE. I ALSO NOTICED DURING THIS TIME A SUBSTANTIAL LOSS IN GAS MILEAGE. I TOOK THE CAR IN TO HAVE IT LOOKED AT. THE AUTO SHOP FOUND THAT THE FUEL PUMP WAS LEAKING AND SHOWED ME THE BACK OF THE FUEL TANK WHICH WAS COVERED IN GAS. DUE TO THE EXTREME RISK, THE AUTO SHOP STATED THAT THE PUMP NEEDED TO BE REPLACED IMMEDIATELY, ESPECIALLY SINCE I WAS ABOUT TO TAKE A 300-MILE TRIP. THE SHOP DID FIND THE RECALL: 09V483000 AND CALLED THE LOCAL VOLVO DEALER. THE DEALER STATED THAT MY CAR WAS NOT COVERED BY THE RECALL. I REQUESTED THAT THE FUEL PUMP BE GIVEN TO ME SO THAT I COULD REVIEW THE RECALL. I THEN REVIEWED ALL THE DOCUMENTATION ONLINE, SPECIFICALLY THE PICTURES OF THE PUMPS WHICH WERE COVERED VS. THE PUMP WHICH WAS BAD. MY PUMP MATCHES EXACTLY TO THE "BAD" PUMP. IN ADDITION, THE FACT THAT MY CAR WAS LEAKING GAS TO THE POINT OF COATING THE OUTSIDE OF THE FUEL TANK INDICATES THAT THIS SHOULD HAVE BEEN A COVERED INCIDENT.

TAKATA RECALL SOMETHING IS WRONG WITH THE AIRBAGS. I T IS SHOWING ME THAT IT NEEDS TO BE REPAIRED.

APPLIED BRAKE, ENGINE CONTINUED TO ACCELERATE. I HAD TO PUMP THE BRAKE SEVERAL TIMES RAPIDLY BEFORE THE ENGINE DECELERATED. THIS HAS OCCURRED ON SEVERAL OCCASIONS.

ENTIRE DASHBORAD HAS WENT BLACK GAS GAUGE,SPEEDODMETOR,TURNING SIGNALS AND HAZARD LIGHTS.

TL* THE CONTACT OWNS A 2001 VOLVO S60. WHILE DRIVING AT UNKNOWN SPEEDS, THE VEHICLE STALLED AND THE BRAKES AND POWER STEERING MALFUNCTIONED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 173,000.

WHILE DRIVING BETWEEN CINCINNATI, OH AND NASHVILLE, TN, WE STOPPED IN CAROLLTON, KY TO REFUEL AT A LOCAL GAS STATION. UPON ATTEMPTING TO OPEN THE FUEL DOOR, THE DOOR WOULD NOT UNLOCK. THERE IS NO BUTTON OR SWITCH TO USE TO OPEN THE FUEL DOOR ON THIS VEHICLE. DESPITE SEVERAL ATTEMPTS TO TURN THE LOCK AND UNLOCK THE CAR, THE FUEL DOOR WOULD NOT OPEN. WE CONTACTED VOLVO ONCALL, WHO ADMITTED THIS WAS A KNOWN ISSUE BUT THEY DID NOT HAVE SOLUTION. THE ONLY OFFER FOR ASSISTANCE WAS TO USE THE KEY REMOTE TO LOCK AND UNLOCK THE CAR 3 TIMES IN AN ATTEMPT TO RESET THE ELECTRONICS. THIS CAR ALSO COMES WITH A BUTTONLESS "KEY TAG," WHICH IS WHAT WE WERE USING AT THE TIME. VOLVO HAD NO AWARENESS OF THIS KEY TAG AND HAD NO OTHER SOLUTION TO OFFER. GIVEN OUR PROXIMITY TO LOUISVILLE, WE AGREED TO ATTEMPT THE DRIVE TO LOUISVILLE AND LEFT THE CAR WITH FRIENDS WHILE WE RENTED A CAR AND DROVE TO NASHVILLE TO GET THE KEY FOB WITH BUTTONS. THEN DROVE BACK TO LOUISVILLE TO TRY THE LOCK-UNLOCK OPTION TO NO AVAIL. WE THEN TOOK THE CAR TO THE LOCAL VOLVO DEALER WHERE THE DOOR WAS MECHANICALLY OPENED AND THE LOCK MECHANISM WAS DISASSEMBLED SO THAT THE CAR COULD BE REFUELED. THOUGH A KNOWN ISSUE BY VOLVO, THEY HAVE NOT COMMUNICATED WITH THE DEALERS AS THIS CAR HAD A 10,000 MILE SERVICE 2 DAYS PRIOR TO THIS EVENT. THE INABILITY TO FUEL THE VEHICLE AND CAUSE PEOPLE TO BE STRANDED SHOULD PROMPT A RECALL.

WHEN AT A FULL STOP, WITH FOOT ON THE BRAKE, ON A HILL AND IN GEAR (DRIVE) THE CAR ROLLS BACKWARDS WHEN REMOVING MY FOOT FROM THE BREAK PEDAL. THE TRANSMISSION DOES NOT ENGAGE UNLESS THE GAS PEDAL IS DEPRESSED. THE VOLVO OF SAN DIEGO "TECHNICIAN" CHECKED A 2013 VEHICLE WITH THE SAME TRANSMISSION AND FOUND THE SAME PROBLEM. UNFORTUNATELY, HE USED THIS TEST TO PROVE THAT THIS WAS NORMAL BEHAVIOR FOR THIS VEHICLE, AND THUS, THE TRANSMISSION WAS IN FINE CONDITION. .I DON'T SEE HOW A CAR ROLLING BACKWARDS WHILE IN A FORWARD GEAR COULD EVER BE CONSIDERED NORMAL BEHAVIOR. IT IS AT BEST, A DEFECT, AT WORST, A SAFETY ISSUE. VOLVO OF SAN DIEGO REFUSES TO FIX THE PROBLEM. IT SHOULD BE NOTED THAT THIS CAR HAS ONLY 46,000 MILES, AND IS STILL UNDER FULL WARRANTY. THERE ARE OTHER ISSUES WITH THIS TRANSMISSION, BUT THEY ARE DIFFICULT TO DESCRIBE IN THIS FORMAT, BUT THE PROBLEMS WERE VERIFIED BY THE VOLVO OF SAN DIEGO PERSON WHO WENT ON THE TEST DRIVE WITH ME, ON JUNE 15TH, 2016. THIS IS AN ONGOING ISSUE WHICH I HAVE BEEN DESCRIBING TO VOLVO OF SAN DIEGO SINCE DECEMBER 2015. TO DATE, THEY HAVE REFUSED TO EVEN ACKNOWLEDGE THAT THERE IS A PROBLEM.

1.) TIRE #1 WAS PUNCTURED BY A PIECE OF GRAVEL AT ABOUT 25,000 MILES 2.) TIRE #2 MECHANIC REFUSED TO ROTATE TIRES BECAUSE BELT WAS SEPARATING FROM TIRE. TIRES WERE BOUGHT NEW AUGUST 2014. TIRES HAVE LESS THAN 34000 MILES