VOLVO Complaints

THE CAR DEVELOPED A RATTLE OVER BUMPS WHICH GOT WORSE WITH COLDER WEATHER TO THE POINT WE DETERMINED THE WINDSHIELD IS LOOSE ALMOST THE ENTIRE LENGTH ACROSS THE TOP AND PART WAY DOWN THE RIGHT SIDE. OUR LOCAL AUTO GLASS COMPANY SAYS IT SEEMS TO BE A FACTORY QUALITY CONTROL PROBLEM. UPON DOING SOME ONLINE RESEARCH IT APPEARS TO BE A SOMEWHAT COMMON PROBLEM WITH VOLVOS AND IT IS A PROBLEM WITH THE PRIMER APPLIED TO THE GLASS POSSIBLY BEING CONTAMINATED AND SEPARATING FROM THE GLASS AND NOT ACTUALLY A PROBLEM WITH THE ADHESIVE WHICH ATTACHES THE WINDSHIELD TO THE CAR. THE VOLVO DEALER SAYS I'M OUT OF WARRANTY AND I WILL HAVE TO PAY TO HAVE THE WINDSHIELD REMOVED AND RESET AND THAT IF IT BREAKS DURING REMOVAL A NEW ONE WILL BE AROUND $800.00. I THINK THIS IS A FACTORY DEFECT AND SAFETY CONCERN CAUSED BY LACK OF QUALITY CONTROL AND OTHER PEOPLE IN THE AUTO GLASS INDUSTRY HAVE EXPRESSED THE SAME THOUGHT. CHECK HERE HTTP://BERANEK.AGRRMAG.COM/?S=VOLVO+BOND+FAILURE I HAVE NEVER HEARD OF WINDSHIELDS BECOMING LOOSE ON VEHICLES BEING A COMMON OCCURRENCE. IT ALSO SEEM THAT IT WOULD BE CONSIDERED A SAFETY ISSUE. I WILL HAVE PHOTOS TOMORROW IF I CAN ACCESS THIS REPORT TO ADD THEM.

TL* THE CONTACT OWNS A 1999 VOLVO S80. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 30 MPH, THE VEHICLE BEGAN TO OPERATE ROUGHLY AND THE ENGINE STALLED WITHOUT WARNING. AFTER FIFTEEN MINUTES, THE VEHICLE RESTARTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. IN 2007, THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 06V441000 (VEHICLE SPEED CONTROL) HOWEVER, THE FAILURE RECURRED EIGHT YEARS LATER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNAVAILABLE.

CAR CAUGHT FIRE WITHOUT WARNING AS I WAS DRIVING IT. CAR HAD 93,000 AND HAD PASSED VA INSPECTION IN AUGUST. I PULLED OVER AND CALLED 911. BY THE TIME THE FIRE DEPARTMENT ARRIVED 3 MINUTES LATER, ENTIRE ENGINE WAS ENGULFED IN LARGE FLAMES. THE TEMPERATURE GAUGE NEVER INDICATED THE ENGINE WAS RUNNING HOT. USAA REMOVED THE VEHICLE, AND I DON'T KNOW WHETHER THEY WILL INSPECT IT FOR CAUSE, BUT I SUSPECT AN ELECTRICAL MALFUNCTION.

THE ANTI SKID SERVICE IS NOT FUNCTIONING. THE WARNING LIGHT KEEPS COMING ON AND OFF PERIODICIALLY.

TL* THE CONTACT OWNS A 2011 VOLVO S80. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 35 MPH, THE VEHICLE STALLED WITHOUT WARNING. IN ADDITION, THE CONTACT STATED THAT THE VEHICLE FAILED TO SWITCH GEARS. THE VEHICLE FAILED TO RESTART. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE COMPUTER SYSTEM FAILED AND NEEDED TO BE RESTARTED. IN ADDITION, THE BATTERY CABLE WAS FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 66,000.

FUEL PUMP LEAKED. SMELL GAS. SCARED IT MAY CATCH FIRE. EXPENSIVE REPAIR. VOLVO IS REFUSING TO HONOR RECALL BECAUSE (1) VEHICLE PURCHASED IN NJ (THOUGH HAS SPENT LIFE IN VA) AND (2) WORK DONE AT NON-VOLVO MECHANIC. DUE TO THE SEVERITY OF THE ISSUE, I TOOK IT TO THE NEAREST MECHANIC RATHER THAN RISK DRIVING IT TO DEALER AND HAVING IT CATCH FIRE.

I WAS IN AN ACCIDENT DRIVING ON A HIGHWAY DRIVING MY VOLVO XC60. I WAS TRAVELING AT APPROX 100KM/H AND RAN INTO THE BACK OF A SEMI THAT WAS TRAVELING AT AN APPROX SPEED OF 80KM/H. THE IMPACT WAS IN THE RIGHT FRONT (PASSENGER) SIDE OF MY XC-60 AND THE LEFT REAR OF THE SEMI. THE AIRBAGS FAILED TO DEPLOY ANYWHERE ON THE VOLVO. THANKFULLY, NOBODY WAS SERIOUSLY HURT AS ALL WERE WEARING SEATBELTS. BASED ON THE SEVERITY AND SPEED OF THE IMPACT, I AM VERY SUPRISED AND CONCERNED THE AIRBAG SYSTEM DIDN'T FUNCTION.

I HAVE SERIOUS QUESTIONS ABOUT HOW A SMALL BUMP THAT SCRAPED THE FRONT TIRE, BUT DID NOT EVEN SCRAPE THE EXTERIOR OF THE CAR COULD CAUSE THE ENTIRE REAR END SUSPENSION AND STABILIZATION BAR TO HAVE TO BE COMPLETELY REPLACED. ARE THERE STRUCTURAL PROBLEMS WITH THE VOLVO XC60S THAT COULD CASES THIS? THE CAR WASN'T MOVING MORE THAN 10 MPH AS IT WAS CROSSING AN INTERSECTION FROM A STANDSTILL AT A LIGHT IN A CITY WHEN THE RIGHT TIRE BUMPED SOMETHING IN THE ROAD. IT WAS GOING STRAIGHT.

MY COMPLAINT IS AGAINST SYLVANIA ULTRA HEADLIGHTS, PURCHASED FROM AUTOZONE. "THE HEADLIGHTS FAILED SHORTLY AFTER 2 MONTHS, THEY ARE THE MOST EXPENSIVE HEADLIGHTS THEY SELL (THINKING THEY ARE THE BEST) I PURCHASED A PAIR. HAD THEM REPLACED AT A LOCAL MECHANIC - THEY WERE INSTALLED CORRECTLY. - THIS ACTION WAS REPEATED FOR 3 SETS OF REPLACEMENTS. THE 4TH TIME AROUND I DID NOT PURCHASE HEADLIGHTS - I TOOK IT TOO THE MECHANIC AND ASKED HIM TO CHECK THE WIRING AND REPLACE THE HEADLIGHTS YET AGAIN. THE MECHANIC CALLED AUTOZONE - THEY ASKED DO YOU WANT THE GOOD ONES OR THE BAD ONES ? THE MECHANIC SAID LOOKING AT ME - THE GOOD ONES OF COARSE. THEN THE SALES PERSON ON THE PHONE DESCRIBED HOW SUCKY THE OTHER ONES ARE TO THE MECHANIC. ABOUT 30 MINS LATER - AUTOZONE DELIVERED THE HEADLIGHTS THAT WERE SYLVANIA BUT NOT THE ULTRA.WHEN I WAS IN AUTOZONE - THEY CLAIMED THESE ULTRAS ARE THE BEST. THESE BOGUS ULTRA HEADLIGHTS ARE A SAFETY HAZARD AND IT APPEARS THEY KNOW THEY ARE BAD - I SMELL A SCAM BEING PERPETRATED AGAINST THE PUBLIC PRODUCING A SAFETY HAZARD AND UNNECESSARY EXPENSE/RIP OFF.

WHILE DRIVING DOWN THE ROAD AT APPROXIMATELY 50 MPH I NOTICED MY DIM ( DRIVER INFORMATION MODULE) HAD COMPLETELY STOPPED WORKING. I WAS UNABLE TO READ MY SPEEDOMETER, RPM, FUEL LEVEL, AND ENGINE TEMPERATURE WHILE THE CAR WAS STILL RUNNING . AFTER RESEARCHING THIS ONLINE, IT APPEARS THAT THIS SEEMS TO BE A COMMON PROBLEM.