2006 VOLVO S40 Complaints

Check engine light came on and stays in. Vehicle always sputters to start, acceleration is sometimes slow to respond, has stalled out on a rare occasion usual on hills. I’m afraid someday I might be involved in a crash because of a lack of acceleration.

Check engine light came on and has stayed on. Stalled out in traffic, turned the car off and it restarted and I continued. Happens two more times. Initial start up has a delay in the engine turning over. Gas pedal is slow to respond to acceleration. Verified at a garage with code reader. Suspect faulty wiring (corrosion) to fuel pump needing PEM replacement. No warning prior to first incident around 02/2022. I have had the check engine light reset on multiple occasions and each time the light comes back on within 2 days. Safety has been a concern at multiple times. Entered VIN number with Volvo, a Volvo dealer, and nhtsa.gov with no help in resolving issue.

IN SOME OCCASIONS CAR WON'T START AND WHILE DRIVING THE CAR IT WOULD SHUT OFF UNEXPECTEDLY CAUSING A DANGEROUS SITUATION. I BELIEVE IT'S THE PUMP ELECTRONIC MODULE WHICH IS ALREADY RECALLED IN SOME CARS. ACCORDING TO YOUR RECALL I HAVE THE EXACT SAME SYMPTOMS BUT MY VIN NUMBER IS NOT PART OF THE RECALL.

AFTER A LONG PERIOD OF RAIN, WATER POOLED ON REAR DRIVER AND PASSENGER FLOOR. WINDOWS WOULD NOT FUNCTION, DOOR LOCKS WOULD NOT FUNCTION, TURN SIGNALS DIDN'T WORK. INSTRUMENT PANEL FLASHED WARNINGS OF ENGINE PROBLEMS, BRAKE FAILURE, AIRBAG PROBLEMS. OFTEN LOST ENTIRE PANEL WHILE VEHICLE WAS BEING DRIVEN ON HIGHWAY, MEASUREMENTS GOING DEAD. THIS HAS BEEN GOING ON FOR MONTHS AND IS GETTING WORSE. *TR

I WENT OUT TO START MY CAR FOR WORK AND IT WOULD NOT START LIKE IT WAS OUT OF BUT I HAVE A HALF TANK OF GAS IN IT BUT FOR SOME REASON IT SOUNDS LIKE THE FUEL PUMP/MODULE IS NOT WORKING.

IVE HAD CAR 3 YRS AND WITHIN LAST FEW MONTHE NOTICE LARGE WATER PUDDLES ON REAR FLOORS WINDOWS WERE ALL CLOSED TOOK IT TO MY MECHANIC AND STATES CHANNELS FOR SUNROOF WERE FLAWED AS I LATER FOUND OUT UNDER COMPUTER CAR COMPLAINTS VOLVO HAD CLASS ACTION ON THIS FEW YRS BACK BUT I DID NOT OWN CAR THEN THERE WERE MANY COMPLAINTS FROM CAR OWNERS RE THIS ISSUE AND VOLVO WILL DO NOTHING IM HAVING NEW CHANNELS PUT IN TO DRAIN WATER BUT ITS ONLY TEMP AS ITS A FLAW THAT WILL CONTINUE TO HAPPEN MY ELECTRIS IS STARTING TO SHORT OUT CAR SMELLS MOLDY/MUSTY AND WILL BE WORTH VERY LITTLE I NEED SOME FEEDBACK ON THIS ISSUE AS CAR IS BECOMING TOTALLY WORTHLESS

TL* THE CONTACT OWNS A 2006 VOLVO S40. THE CONTACT STATED WHILE DRIVING AT 20 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AFTER SEVERAL MINUTES AND SEVERAL ATTEMPTS. THE VEHICLE WAS DRIVEN TO THE RESIDENCE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC BUT WAS NOT DIAGNOSED NOR REPAIRED. THE FAILURE RECURRED INTERMITTENTLY. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 114,000.

FOUND COMPLAINTS ON MULTIPLE SITES ABOUT ISSUE FOUND ON MY VEHICLE . THE OIL FILTER HOUSING CORRUGATED BREATHING HOSE WAS SO BADLY ROTTED WAS ONLY LITTLE PIECE LEFT REST FELL OFF SOMEWHERE WHILE OPERATING VEHICLE. ON TOP OF THAT ISSUE IM SSUMING DUE TO THISS PROBLEM AND IT ON GOING UNTIL I GOT CHECK ENGINE LIGHT IT HAS CAUSED OIL FILTER HOUSING ITSELF TO GO BAD IM ASSUMING IN PART TO ALL OIL BUILD UP FROM HOSE MISSING CAUSING VACUUM ISSUES' WHY ISNT HIS CAR THAT HAS SAME ISSUE AS OTHERS THAT WERE RECALLED WITH SAME EXACT OPERATING AND LOOKING PART WITH SAME EXACT HOSE ROTTING ISSUE CAUSING OIL FILTER HOUSING TO BECOME BUILT UP WITH GUNK CAUSING LEAKS BOTH AIR AND OIL.. .. PLEAE ANSWER THESE ISSUES FOR IT SHOWS HOW MUCH VOLVO CARES ABOUT QUALITY OF THERE PRODUCTS

EGR OR AKA. OIL TRAP HOUSING, TUBING IS BROKEN AND SUCKING IN AIR. IMPROPER VENTILATION IS TRIPPING OFF EMISSION CODE ON DASH. BRITTLE BLACK PLASTIC HOUSING, DEFECTIVE IN NATURE AND BY DESIGN. POTENTIAL OTHER ISSUES IS THE UNWANTED PRESSURE BUILD UP IN ENGINE WHICH CAN CAUSE PREMATURE FAILURE OF OIL CAM SEALS WHICH I ALSO EXPERIENCED.

WHILE DRIVING DOWN THE ROAD AT APPROXIMATELY 50 MPH I NOTICED MY DIM ( DRIVER INFORMATION MODULE) HAD COMPLETELY STOPPED WORKING. I WAS UNABLE TO READ MY SPEEDOMETER, RPM, FUEL LEVEL, AND ENGINE TEMPERATURE WHILE THE CAR WAS STILL RUNNING . AFTER RESEARCHING THIS ONLINE, IT APPEARS THAT THIS SEEMS TO BE A COMMON PROBLEM.