VOLVO Complaints

WHILE BRAKING AT THIS SPEED OR HIGHER THE CAR STEERING WHEEL BEGAN TO SHACK AND PULL TO THE LEFT. TOOK IT TO VOLVO AND THEY SAID THE CALIBER WAS NOT RELEASING PROPERLY. HAD CALIBERS REPLACED SEVERAL YEARS PRIOR DUE TO A SIMILAR MALFUNCTION. *JS

I HAVE A GAS/FUME SMELL COMING FROM MY CAR ,I CAN SMELL THE FUMES WHEN I STAND NEXT TO VEHICLE. DO YOU KNOW WHAT I SHOULD CHECK OR ANY RECALLS FOR THIS VEHICLE. THANK YOU *TR

DRIVER'S SIDE SEAT STARTED SMOKING WITHIN A FEW SECONDS OF STARTING THE VEHICLE WHILE BACKING OUT OF PARKING PLACE. SEAT HEATER WAS ON. IMMEDIATELY STOPPED AND TURNED OFF SEAT HEATER AND SMOKING STOPPED. QUARTER SIZE HOLE WAS BURNED INTO THE LEATHER SEAT BOTTOM ON THE DRIVER'S SIDE OUTSIDE PANEL. TOOK IT TO DARRELL WALTRIP VOLVO/SUBARU IN FRANKLIN, TN, AND THEY SAID IT WAS THE SEAT HEATER AND TOOK THE FUSE OUT. SAID IT WASN'T COVERED UNDER WARRANTY AND NO RECALL OUT. HOPE NO ONE HAS THIS PROBLEM DRIVING DOWN THE INTERSTATE. BEST REGARDS AND THANKS FOR ALL YOUR HARD WORK, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 2001 VOLVO S40. THE CONTACT STATED THAT THE HEATER FAN STOPPED OPERATING AND THE DEFROSTER FUNCTION WAS AFFECTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 01V169000 (EQUIPMENT). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 113,000.

TIRES WERE SHAKY WHEN I BOUGHT A BRAND NEW C30 VOLVO. ASKED DEALER TO FIX-SALES MANAGER SAID NOTHING WAS WRONG (FT. MEYERS, FL VOLVO). AND HE WOULD TELL VOLVO I WAS CRAZY. TIRES WERE DESTROYED AT 10,000. WENT TO DIFFERENT VOLVO DEALER IN SARASOTA AND ST. PETE-NOTHING IS WRONG. DEALER REPLACED TIRES AT 10,000. CAR STILL SHAKING. NOW I AM ON MY 3RD SET OF TIRES AT 50,000. SOMETHING IS VERY WRONG WITH THIS CAR-DO NOT BUY ONE VOLVO WILL NOT FIX. *TR

WE SMELL GAS. WHEN STOP NOTICE FUEL LEAKING FROM FUEL ENTRY PIPE. WHEN GOT CLOSER LOOK IT WAS LEAKING FROM FUEL ENTRY PIPE THAT CONNECTED TO FUEL TANK. *TR

IN 2008, AT ABOUT 93K MILES, THE TRANSMISSION ON MY 2001 VOLVO S60 FAILED WHILE I WAS DRIVING ON A MAIN THOROUGHFARE. FORTUNATELY, I WAS ABLE TO AVOID BEING IN AN ACCIDENT. I HAD A VOLVO DEALER INSTALL A NEW VOLVO TRANSMISSION. IN 2014, AT ABOUT 123K MILES (OR ABOUT 30K MILES ON THE NEW TRANSMISSION), THE SECOND TRANSMISSION FAILED WHILE I WAS DRIVING ON A LOCAL STREET. AGAIN, I WAS ABLE TO AVOID AN ACCIDENT. A SEARCH OF THE NHTSA DATABASE AND OTHER ONLINE SOURCES SHOWED THAT THERE HAVE BEEN NUMEROUS EARLY TRANSMISSION FAILURES WITH VOLVOS LIKE MINE. VOLVO OF NORTH AMERICA REFUSED TO DO ANYTHING TO HELP FIX THE FAULTY TRANSMISSION DESPITE INFORMATION THAT THERE IS A PROBLEM WITH THE TRANSMISSION THEY HAVE BEEN USING. *TR

2005 XC90 V8 STALLED IN TRAFFIC. WOULD NOT RESTART, BUT STARTER WOULD CRANK. FUEL PUMP CONTROLLER WAS FOUND TO BE INTERNALLY CORRODED AND FILLED WITH DRIED SALT. THIS CONTROLLER IS MOUNTED FORWARD OF THE RIGHT REAR WHEEL WELL. MANY INSTANCES OF THIS CONTROLLER FAILING DUE TO SALT / MOISTURE INGRESS HAVE BEEN REPORTED BY OTHER OWNERS. THE CONTROLLER WAS RELOCATED TO THE INSIDE OF THE VEHICLE SOME MODEL YEARS LATER. *TR

THE BATTERY IN THE VEHICLE FAILS DUE TO A DRAIN IN THE POWER SYSTEMS BECAUSE OF A FAILURE IN SOFTWARE SYSTEMS ,THIS FAULT IS KNOWN TO VOLVO AND THEY REFUSE TO REPAIR .IF THE CAR IS NOT DRIVEN EVERY DAY THE ELECTRONIC SYSTEMS SEARCH FOR BLUE TOOTH PHONE SIGNALS AND SATELLITE RADIO SIGNALS CAUSING A DRAIN ON THE ELECTRICAL SYSTEMS ENOUGH TO KILL THE BATTERY ON A DAILY BASIS. VOLVO SAYS THEY HAVE A REPAIR FOR THIS AND SAY THAT I MUST PAY. THIS IS A KNOWN DEFECT TO VOLVO THEY SHOULD REPAIR THIS. *TR

I NOTICED THE TAIL LIGHT BRAKE BULBS WERE BURNING OUT QUICKLY. AFTER GETTING A TICKET I STOPPED DRIVING IT UNTIL I COULD DETERMINE THE CAUSE. VOLVO LISTS A BRAKE RELAY RECALL. BRAKE LIGHT FUSES AND RELAYS ARE IN 4 LOCATIONS IN THE CAR. THEY ARE: 1. UNDER THE HOOD IN THE ENGINE CONTROL UNIT ECU, 2.THE PASSENGER COMPARTMENT A. CENTRAL CONTROL UNIT CCU AND B. FUSE PANEL BY DRIVERS SIDE DOOR POST 3. REAR CONTROL UNIT IN THE CARGO COMPARTMENT. THE PROBLEM WAS AN ELECTRICAL ENGINEERING DESIGN WHERE A STEEL RACE THAT SURROUNDS THE TAILLIGHT BULBS TRANSFERS THE ELECTRICAL CURRENT IS DESIGNED TO FAIL. AS THE BULB HEATS UP IT TRANSFERS THE HEAT TO THE PLATE AND PLASTIC PINS THAT HOLD IT IN PLACE UNDER PRESSURE FROM THE SPRING STEEL PARTS OF THE REMOVABLE BULB SOCKET UNIT. AS THE PLASTIC PINS WEAKEN AND MOVE AWAY UNDER PRESSURE AND HEAT FROM THE BULB SOCKET SPRING STEEL KEEPERS, AND CONDUCTORS OF VOLTAGE AND CURRENT, THE CURRENT IS THROTTLED DOWN TO A PIN POINT AS THE PLATE MOVES AWAY FROM THE BULB CREATING MORE HEAT AND ARCING TO MELT THE STEEL RACE SURROUND THE BULBS THAT SUPPLY THE CURRENT. THE REPLACED BULBS SEEM TO WORK FOR A SHORT TIME AS THE CONNECTION IS REESTABLISHED WHEN THE BULB SOCKET IS REMOVED AND REPLACED, AND THE CONNECTION IS REESTABLISHED FOR A TIME, BUT IT WILL SOON OVER HEAT AND FAIL FROM THE WEAKENED AND MELTED PLASTIC LENS. BRAKE LIGHT FAILURE RESULTS NOT FROM A FAILED PART, RELAY, FUSE OR WIRE, BUT FROM AN ENGINEERING DESIGN FLAW THAT WAS RECOGNIZED AND ELIMINATED IN THE 2005 MODELS. FORD AND VOLVO NEVER MENTION THIS. A RECALL COULD AMOUNT TO SIX HUNDRED TO A THOUSAND DOLLARS PER CAR FOR THE 4 LENSES WITH LABOR. THE ARCING IN THE WIRING MAY ALSO CAUSE OTHER COMPUTER FAILURES AS THE TRANSMISSION ALSO HAS AN ELECTRICAL PROBLEM IN THE KICKDOWN PROCESS THAT CAUSES AN ABNORMAL DELAY IN NEUTRAL GEAR AND HARD ENGAGEMENT OF THE LOWER GEAR. *TR