VOLVO Complaints

AFTER A SIDE IMPACT THE SIDE/CURTAIN AIR BAGS FAILED TO DEPLOY. IMPACT TO THE PASSENGER REAR AND FRONT DOOR. THE IMPACT WAS BETWEEN 30-35 MILES PER HOUR. *TR

FUEL LEAK DEVELOPS AROUND FUEL PUMP AND TANK. RISK OF FUEL IGNITION AND VAPOR INHALATION TO DRIVE AND PASSENGERS. *TR

I HAVE A 2006 VOLVO C70 AND THE TIERS STARTED TO LOOSE AIR. WHEN I HAD THE VEHICLE INSPECTED I FOUND OUT THAT THREE OF THE FOUR 18' RIMS HAD CRACKS ON THE INSIDE OF THE RIM EDGE...WITH A LITTLE RESEARCH I HAVE FOUND THAT THIS IS A COMMON PROBLEM WITH THE 2006 VOLVO C70. IT IS AN OUTRAGE THAT VOLVO DOES NOT YET HAVE TO FIX THIS SAFETY ISSUE. WHO KNOWS HOW MANY ACCIDENTS HAVE OR WILL HAPPEN DUE TO A TIRE GOING FLAT ON THIS MODEL AND RIM SIZE. I KNOW THAT SOMETIMES RIMS CAN GET DAMAGED HOWEVER," ALL ARE CRACKING IN THE SAME AREA". I WILL HAVE TO REPLACE ALL THREE RIMS TO MAKE THE VEHICLE SAFE TO DRIVE. THANK YOU IN ADVANCE. R. SWANEY. *TR

2004 VOLVO S60 2.5T. PURCHASED THE CAR USED IN SEPT 07. 6-5-08 PANEL DISPLAYED OPEN REAR DOOR WHILE DRIVING 65MPH ON HIGHWAY, MY DOOR WAS NOT OPENED. CAR JERKED AS IF THERE WAS POWER LOSS, AC WENT OFF, BRAKE FAILURE LIGHT ON PANEL, POWER WINDOWS AND LOCKS DID NOT WORK, TEMP 105 , THEN DRIVER PANEL WENT BLACK. CAR JERKED 3 TIMES IN MID TRAFFIC, I WAS SCARED TO DEATH FOR MY LIFE. ARRIVED AT MY EXIT, PULLED OVER TO A GAS STATION, ENGINE STILL RUNNING BUT SLUGGISH, RADIO WAS STILL ON, POWER DOOR LOCKS AND WINDOWS DID NOT WORK, AC OFF. ENGINE STILL RUNNING SO I MADE IT A COUPLE OF MILES UP THE STREET TO MY HOME. CUT THE CAR OFF AND BACK ON, ALL POWER RETURNED, NOW CHECK ENGINE AND AIR BAG TROUBLE ON PANEL. WENT TO VOLVO DEALER NEXT DAY 6-6-08 NEAR MY HOME, THEY CAN NOT SEE MY CAR TIL NEXT WEEK TUESDAY. WENT TO PEPBOYS, BATTERY AND ALTERNATOR ARE OK, CAN NOT ACCESS ENGINE BOX, MUST GO TO DEALER. CALLED VOLVO FOR TUESDAY 6-10-08 APPOINTMENT. CAR DUPLICATED SAME PROBLEM MONDAY 6-9-08 ON DRIVE HOME FROM WORK ON THE HIGHWAY TEMP 105 ETC. SEARCHED FOR COMPLAINTS AND RECALLS, MY RECALLS WERE REPORTED COMPLETED WHEN I PURCHASED THE CAR, FOUND ALL OF THIS VALUABLE INFO ONLINE, WILL SEE DEALER TOMORROW AND TAKE THESE RELATED COPIES OF COMPLAINTS WITH ME. *TR

AT 92K MILES, THE DEALERSHIP BROKE THE NEWS ON APRIL 15, 2008, ABOUT SEEING LARGE CHUNKS OF METAL SHAVINGS WHEN CHANGING MY TRANSMISSION FLUID WITH MY 2003 VOLVO XC90. I GOT A BILL FOR $7500 (NEW TRANNY, NEW RADIATOR, LINES INCLUDING LABOR), BUT DEALERSHIP AGREED TO PAY 60% AFTER RELENTLESS COMPLAINTS AND DIRECTING THEM TO BELOW DISCUSSION FORUM ON ONGOING XC90 TRANSMISSION FAILURES HTTP://TOWNHALL-TALK.EDMUNDS.COM/WEBX/.F18A651/[email protected]@ REGARDLESS, I'M OBVIOUSLY EXTREMELY DISAPPOINTED PAYING, CONSIDERING MY XC90 IS LESS THAN 5 YEARS, AND HAVE BEEN CONSISTENT WITH MY REGULAR MAINTENANCE. MY BIGGEST CONCERN IS THE SAFETY OF MY 2 SMALL CHILDREN (3 & 5 YRS OLD), WHO WE TAKE TO SCHOOL DAILY. VOLVO TOUTS 'VOLVO FOR LIFE' AND STRONG SAFETY CAPABILITIES. THIS IS NOT THE CASE. *TR

HI, JUST HAD TO HAVE MY FUEL PUMP REPLACED TO THE TUNE OF WELL OVER A THOUSAND DOLLARS. COST AND PROBLEM FALL IN TO THE "UNREAL" CATEGORY. HARD TO BELIEVE THAT SOMETHING AS SIMPLE AS A FUEL PUMP HAS EVOLVED INTO A PIECE OF EQUIPMENT THAT APPARENTLY AS COMPLICATED AS SOMETHING THAT IS VITAL TO THE LAUNCH OF THE SHUTTLE. OH FOR THE DAYS WHEN A FUEL PUMP WAS ACTIVATED BY THE CAM SHAFT, HELD ON TO THE ENGINE WITH TWO BOLTS, COST FIVE DOLLARS, TOOK ABOUT TEN MINUTES TO REPLACE AND SELDOM FAILED. ACCORDING TO THE STEALERSHIP THAT DID MY WORK, IN ORDER TO GET TO THE FUEL PUMP, THEY HAD TO REMOVE THE REAR SEAT TO GET TO THE FUEL PUMP? I HAVEN'T HAD TIME TO SURVEY THE TOTAL AMOUNT OF DAMAGE THEY DID IN DOING THIS, BUT DO KNOW THAT THE HEADLINER AND STEERING WHEEL ARE COVERED WITH GREASY HAND PRINTS AND AFTER THREE DAYS THERE IS STILL A STRONG ODOR OF GASOLINE IN THE CAR. MY VOLVO IS AN 03 S80 WITH ONLY 45,000 MILES ON IT. IS THIS TYPICAL OF VOLVO DEPENDABILITY AND EXCELLENCE? GUESS I'M GOING TO HAVE TO GO JAPANESE. COMMENTS PLEASE. *TR

I DRIVE A 2004 VOLVO XC90 T6 AWD. SUV. AFTER 78,000 MILES MY TRANSMISSION HAS COMPLETELY FAILED WITHOUT WARNING. I WAS ON THE ROAD AND EVERYTHING WAS NORMAL . AFTER ACCELERATING AT A BUSY TRAFFIC LIGHT FIRST AND SECOND GEAR IN MY TRANSMISSION FAILED. THIS OCCURRED IN BUSY TRAFFIC. THE TRANSMISSION ENGAGED SUDDENLY AND THE CAR JERKED FORWARD WITHOUT WARNING OR CONTROL. THE ENTIRE TRANSMISSION HAS TO BE REBUILT. I SEARCHED ON LINE TO SEE IF THERE WERE ANY DISCUSSIONS ABOUT THIS AND THERE ARE. PLEASE CHECK EDMUNDS.COM VOLVO FORUM. THERE ARE OVER 35 SIMILAR COMPLAINTS SOME WHILE PEOPLE WERE DRIVING AT HIGH SPEEDS. APPARENTLY VOLVO USED A GM TRANSMISSION DESIGNED FOR A MUCH SMALLER CAR. THERE SHOULD BE A RECALL FOR VOLVO TO CHANGE OR REPAIR THIS VERY EXPENSIVE ISSUE. *TR

INVESTIGATED GASOLINE ODOR IN/AROUND CAR. RESULTING INSPECTION FOUND SIGNIFICANT GAS LEAK ON TOP SIDE OF FUEL TANK - PASSENGER SIDE. FURTHER INSPECTION BY REPAIR SHOP REVEALED CRACKED FUEL PUMP FITTING THAT WHEN POWERED SPRAYED FUEL ON UNDERSIDE OF VEHICLE. FUEL SPRAY / VAPORS WERE REACHING CLOSE TO IF NOT IN CONTACT WITH HOT EXHAUST COMPONENTS. IN ADDITION TO DANGERS (TO VEHICLE OCCUPANTS) RELATED TO INHALATION OF GAS FUMES THIS FAILURE RESULTING IN A CRITICAL AND POTENTIALLY CATASTROPHIC RISK OR FIRE/EXPLOSION. REPAIR INVOLVED REPLACEMENT OF FUEL PUMP ASSEMBLY, APPROXIMATELY $700. BOTTOM LINE - THIS IS A COMPLETELY UNACCEPTABLE FAILURE AT ANY MILEAGE AND COULD HAVE RESULTED IN INJURY OR LOSS OF LIFE. FURTHER, IT APPEARS THAT THIS IS NOT AN ISOLATED ISSUE (FROM READING OTHER COMPLAINTS FILED WITH NHTSA) AND ONE THAT MUST BE IMMEDIATELY ADDRESSED TO PREVENT FURTHER FAILURE(S) WITH SIGNIFICANT POTENTIAL FOR LOSS OF LIFE. OLD PART IS AVAILABLE FOR INSPECTION UPON REQUEST. *TR

I HAVE A VOLVO S40 2005 AND THE RADIO/CD PLAYER JUST BLANKS OUT. WHEN I START THE CAR THE RADIO/CD WON'T PLAY. IT WILL POWER UP AND THE DISPLAY WILL SHOW, BUT NO SOUND COMES ON. IT HAS DONE THIS THREE TIMES. I HAVE TO TOTALLY TURN THE CAR OFF AND LET IT SIT FOR A WHILE BEFORE IT WILL WORK AGAIN. *TR

AS I UNDERSTAND IT, THE ELECTRONIC THROTTLE MODULE (ETM) ON MY 2000 VOLVO S80 IS IN THE PROCESS OF FAILING. TWO YEARS AGO, I HAD MY VEHICLE SERVICED WHEN IT BEGAN SURGING FORWARD WHEN IDLING, EVEN WHEN I WAS BRAKING. AN ETM SOFTWARE UPGRADE WAS DONE AT THAT TIME AND THE ETM WAS CLEANED. NOW, JUST SHORT OF TWO YEARS LATER, I AM HAVING EXACTLY THE SAME PROBLEM AGAIN. AS I AM COMING TO A STOP, MY VEHICLE WILL SUDDENLY AND UNEXPECTEDLY SURGE FORWARD, EVEN WHEN MY FOOT IS ON THE BRAKE. I AM PETRIFIED THAT I AM GOING TO STRIKE THE BACK OF ANOTHER VEHICLE BEFORE I CAN ARRANGE TO GET MY CAR IN FOR SERVICE. FURTHER, WHEN I PUT MY CAR IN PARK OR USE THE AC SYSTEM, MY CAR COMES TO A NEAR STALL AND JUST LURCHES ALL OVER THE PLACE. IT SIMPLY CANNOT MAINTAIN AN EVEN IDLE WHEN IN PARK. LAST WEEK, FOR THE FIRST TIME, I BECAME AWARE OF THE NOVEMBER 2006 RECALL CONCERNING ETMS. THIS LED ME TO LOOK AT MY OLD SERVICE RECORDS, SINCE I WAS HAVING THE SAME FRIGHTENING PROBLEM THAT I HAD TWO YEARS AGO. SURE ENOUGH, THERE IT WAS AGAIN - "CUSTOMER STATES AT IDLE REVS UP AND SURGES." I HAVE ALREADY PAID FOR THIS REPAIR ONCE. THIS IS AN EXTREMELY SERIOUS MATTER AND MY VEHICLE SIMPLY IS NOT SAFE TO DRIVE. *TR