VOLVO Complaints

TL*THE CONTACT OWNS A 2003 VOLVO S60. WHILE DRIVING 35 MPH, THE ENTIRE VEHICLE BEGAN TO SHAKE, THE SERVICE ENGINE LIGHT ILLUMINATED, AND THE VEHICLE SHUT OFF. THE WEATHER CONDITIONS WERE RAINY AT THE TIME OF FAILURE. THE FAILURE OCCURRED IN THE MIDDLE OF THE ROAD. THE CONTACT PULLED OFF THE HIGHWAY AND THE VEHICLE RESTARTED AFTER 2-3 MINUTES. THE DEALER REPLACED THE FUEL PRESSURE SENSOR, BUT THE FAILURE PERSISTS. THE POWERTRAIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 63,000.

A HISSING SOUND COMING FROM THE BRAKE PEDAL AREA BEGAN OCCURING AND I TOOK TO THE CAR TO THE DEALER AND WAS INFORMED THAT IT WAS A DEFECTIVE "BRAKE BOOSTER" AND THAT IT IS A VERY DANGEROUS SITUATION THAT IF NOT CORRECTED COULD LEAD TO TOTAL BRAKE FAILURE. THE CAR IS USED TWICE A WEEK AND THE BRAKE BOOSTER HAS NOT BEEN REPLACED AND IS AVAILABLE FOR INSPECTION. *TR

THE HEADLIGHTS CEASED OPERATING ON MY 1998 VOLVO V90. AFTER CHECKING FOR FAULTY BULBS AND FUSES, I FOUND NHTSA SAFETY RECALL # 04V504000 FOR 1998 VOLVOS OF THE S70/VIA/C70 SERIES. I TOOK MY CAR TO THE DEALER TO CHECK THE REASON FOR THE FAILURE OF MY HEADLIGHTS TO OPERATE. THE DEALER FOUND THE HEADLIGHT SWITCH TO BE FAULTY AND REPLACED THE HEADLIGHT SWITCH. V90S ARE NOT CURRENTLY COVERED BY MENTIONED RECALL. *JB

I OWN A 2001 VOLVO S60. I SMELLED GASOLINE WHEN I STARTED THE VEHICLE, BUT THE MANUFACTURER HAS NOT INDICATED A PROBLEM. WHEN I REVIEWED THE RECALLS FOR THIS VEHICLE ON WWW.NHTSA.GOV, I NOTED THE FOLLOWING PROBLEM UNDER REVIEW: PE06-053 2001 VOLVO S60 FUEL PUMP LEAKAGE 15-NOV-2006 I BELIEVE THE PROBLEM I AM EXPERIENCING IS RELATED TO THIS ITEM. I WISH TO BE CONTACTED IF THIS BECOMES A RECALLED ITEM BY THE NHTSA. *JB

TL*THE CONTACT OWNS A 1998 VOLVO VN610. WHILE DRIVING 55 MPH, THE VEHICLE LOST STEERING POWER. THE CONTACT LOST CONTROL AND CRASHED INTO A GUARD RAIL. THE VEHICLE WAS TOWED FROM THE SCENE. THE DEALER WAS NOTIFIED, BUT THE VEHICLE WAS NOT BROUGHT IN FOR INSPECTION. THE CONTACT STATED THAT THE BALL JOINT THAT WAS ATTACHED TO THE DRAG LINK FELL APART. THERE WERE NO INJURIES. THE ENGINE SIZE WAS UNKNOWN. THE CURRENT MILEAGE WAS 430,000 AND FAILURE MILEAGE WAS 428,000. UPDATED 10/16/07 *TR

TL*THE CONTACT OWNS A 1993 VOLVO 940. THE VEHICLE HAS DUNLOP TIRES, SIZE P205/60R15. THE CONTACT STATED THAT THE VALVE STEMS ON THREE OUT OF THE FOUR TIRES WERE BAD AND CAUSED THE TIRES TO FLATTEN. HE STATED THAT THE TIRES HAD ONLY BEEN ON THE ROAD FOR SIX MONTHS, WHEN DURING THE COURSE OF ONE WEEK, THE VALVE STEM FAILED ON THREE DIFFERENT TIRES. THE TIRES WERE REPLACED AT THE MANUFACTURER'S EXPENSE. THE CONTACT WAS UNCERTAIN OF THE DOT NUMBER (P072ARO OR CR54606-2). THE VIN, PURCHASE DATE, ENGINE SIZE, AND SPEED WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 128,000.

TL*THE CONTACT OWNS A 2001 VOLVO S60. THE CONTACT NOTICED GAS LEAKING FROM HIS VEHICLE AFTER IT HAD BEEN PARKED OVERNIGHT. THE MANUFACTURER STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA RECALL NUMBER 07V152000 (FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP). THE VEHICLE HAS NOT BEEN INSPECTED BY A DEALER. THE FAILURE MILEAGE WAS 100,000 AND CURRENT MILEAGE WAS 104,000.

TL*THE CONTACT OWNS A 2000 VOLVO V70XC. THE CONTACT BELIEVES THAT THE ELECTRONIC THROTTLE MODULE IS A SAFETY HAZARD. SHE STATED THAT THE VEHICLE WILL SUDDENLY HESITATE AND COME TO A COMPLETE STOP. WHILE DRIVING 60 MPH, THE VEHICLE HAD A SUDDEN LOSS OF POWER. ALL OF THE INSTRUMENT PANEL LIGHTS ILLUMINATED AND THE POWER STEERING FAILED. THE SPEED DECREASED FROM 60 MPH TO 0. SHE WAS ABLE TO PULL OFF THE ROAD AND STATED THAT THE ENTIRE ELECTRICAL SYSTEM WAS NOT WORKING. THE VEHICLE WAS TOWED TO A SHOP AND THEY STATED THAT THE CAUSE OF FAILURE WAS ELECTRICAL. THE VIN AND ENGINE SIZE WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 51,247.

7/26/07 TRAVELING ON I-77 AND THE CAR RAN GREAT. SUDDENLY, IN SAME MANNER AS CAR DID APPROX 2 YRS AGO ON SAME INTERSTATE RPMS DROPPED, CAR LOST SPEED, NO RESPONSE AT THROTTLE, AND WITHIN A FEW SECONDS WE LOST POWER, BRAKES, STEERING. SINCE THIS SEEMED JUST LIKE 2 YRS AGO (WE REPORTED THIS INCIDENT IN 2005) WE THOUGHT MAYBE THE CAR WILL START IN 10-15M. AFTER 15-20 M OF ATTEMPTS WHERE CAR STARTED & IMMEDIATELY STALLED CAR DID START AND RAN FINE. SINCE 2 YEARS AGO DEALERS WERE UNABLE TO DIAGNOSE & CORRECT WE CONTINUED TO DRIVE THAT EVENING AND AGAIN THE FOLLOWING DAY. THE FOLLOWING DAY THE CAR STALLED AGAIN ON I-? NEAR ATLANTA, BUT THIS TIME IN MORE TRAFFIC WITH DIFFICULTY GETTING CAR TO SIDE SAFELY. AGAIN CAR STARTED LIKE THE EVENING BEFORE. AGAIN-SIMILAR FUEL LEVEL. WE TRAVELED 2 1/2 MORE HOURS ON INTERSTATE. AT DESTINATION AND LOCAL DEALER FOUND NO FAULTS SO NO CORRECTION WAS MADE. AFTER THIS 2ND OCCURRENCE WE FILLED UP MORE OFTEN 1/2 FULL OR MORE. 2 DAYS LATER AND 7 MORE HRS ON ROAD WITHOUT ANY PROBLEM.. AS WE ARRIVE. CHECK ENGINE LIGHT CAME ON. ALTHOUGH CAR RAN FINE WE TOOK CAR TO LOCAL DEALER 1 HOUR AWAY. THEY SAID THEY HAD A CATALYTIC CONVERTER ERROR BUT THEY DIDN'T HAVE ONE IN STOCK. I TOLD THEM I WASN'T SURE THIS WAS THE PROBLEM THAT WAS CAUSING THE STALLING BECAUSE IT STALLED 2X (+1X 2 YEARS AGO) BEFORE THE CHECK ENGINE LIGHT CAME ON. I CALLED MY LOCAL DEALER TO DISCUSS AND HE SAID HE DIDN'T THINK THE CATALYTIC CONVERTER WAS CAUSING THE STALLING. AGAIN, NO DEFINITIVE ANSWERS. AFTER WE LEFT THE DEALER, THE CHECK ENGINE LIGHT WAS OFF AND IT HAS STAYED OFF. A COUPLE OF DAYS LATER WE DROVE THE CAR 9-10 HOURS ON THE INTERSTATE TO GET HOME. AGAIN, I KEPT THE FUEL LEVELS APPROXIMATELY 1/2 TANK AND ABOVE. THE CAR PERFORMED FINE. WE ARE VERY CONCERNED ABOUT THE STALLING. WHEN I CHECK OTHER COMPLAINTS LISTED IT APPEARED THAT SOMEONE ELSE MAY HAVE HAD A SIMILAR ISSUE WITH LOW FUEL STALLING. PLEASE DON'T HESITATE TO CALL TO DISCUSS. *JB

1. SEVERE SUMMER THUNDERSTORMS AND RAIN. 2. DROVE APPROXIMATELY 1 MILE AND RIGHT BLINKER STAYED SOLID GREEN AFTER TURNING. DROVE ABOUT A MILE FURTHER ONTO HIGHWAY ENTRANCE RAMP AND CAR INDICATOR LIGHTS FLASHED ABS BRAKE FAILURE AND AIR BAG FAILURE, THEN ALL CAR INSTRUMENTS (GAS GAUGE, SPEEDOMETER, TACHOMETER, ETC) FAILED FOR ABOUT FIVE MINUTES. INSTRUMENTS CAME BACK ON BUT ABS BRAKE AND AIR BAG FAILURE CONTINUED TO FLASH FOR ABOUT 1 MORE MINUTE. DROVE DIRECTLY TO DEALERSHIP. 3. SERVICE DEPARTMENT TOOK THE CAR RIGHT IN AND APPLIED GREASE TO THE HARNESS CONNECTOR WHICH SHOULD ALLEVIATE PROBLEMS AS THEY ARE KNOWN TO GET WET AND CORRODE. PLEASE NOTE THIS IS A 2006 MODEL AS I HAVE READ ON THE WEBSITE THAT THE 2004 MODEL HAS THE EXACT SAME PROBLEM. ADDITIONALLY, DRIVER SIDE DOOR LOCKS AND POWER WINDOWS INTERMITTENTLY INOPERABLE LEADING UP TO THIS FAILURE. HAD A SCHEDULED APPOINTMENT TO REMEDY THIS SITUATION BUT BROUGHT THE CAR IN EARLY AS THE CAR WAS INOPERABLE WITHOUT INSTRUMENTS. *JB