VOLVO Complaints

I stopped at a gas station and the fuel door would not open. I tried multiple times locking and unlocking the vehicle with the key fob. As I was driving home, I stopped at three other gas stations. All three times, I still could not open the fuel door. This happened when I initially purchased the car in 2019. I reported it to the Volvo dealer while standing at the gas station. I played with the key fob for about 20 minutes until it finally opened. I remember looking up this issue on the [XXX] and it had been reported numerous times. I stopped in at the Volvo dealership near me. When I told them what was happening, they asked if it was a 2024 XC40. So, the problem exists even in the current year's models. The dealership played around with the key fob, then pried the door open, I assume with a screwdriver, and charged me $50. I could have done that when I got home....for free. There is no option to open the fuel door manually, and there is no option to turn off the fuel door lock - which creates a safety issue! This car runs on gasoline. If I can't fuel my car, I am stuck. There should be an option not to lock the fuel door. I am not worried about anyone siphoning gas. I am worried about traveling on a highway or rural area and not being able to open the fuel door. I guess I'll keep a screwdriver in my car. My 2019 XC40 was the first year the car was introduced. The fact that 2024 models still have the same problem means Volvo knows the problem exists. Their mechanics know as well. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact's wife owns a 2005 Volvo S40. The contact stated the vehicle was difficult to start for several days. Eventually, the failure progressed and the vehicle was not able to start. The check engine warning light was illuminated. The vehicle was repaired by the contact, a previous Volvo technician. The contact stated the failure was due to the pump electrical module being located out of the vehicle. The contact spoke with the dealer. The contact referenced The manufacturer was made aware of the failure. The approximate failure mileage was 170,000.

Both front strut upper bearings failed with less than 30k miles. Continued noise coming from front end diagnosed as failed left strut, causing left upper bearing and strut to be replaced. Polestar 2, which uses the same assembly and Volvo have issues technical journals. Polestar is issuing an upgraded part, though it appears Volvo is not. Owner forums comment on this issue and it is well known with Volvo. A solution for the front suspension should be implemented under a recall as failure of these parts is premature and seems to represent a manufacturing defect.

The contact owned a 2006 Volvo S60. The contact received notification of NHTSA Campaign Number: 21V766000 (Air Bags) and would like to be removed from the recall distribution list. The manufacturer was not contacted.

Recently our 2017 XC90 experienced a significant coolant system leak via a part that was part of a recall campaign for the prior year model (2016 XC-90). The exact same part (a coolant bleeder hose - part #32249907) failed in our vehicle in a similar manner as the prior year component. There was no antecedent warning prior to its failure until after a significant amount of fluid was lost (literally sprayed about the engine compartment) leading to a low coolant level CEL. The safety concern, as stated in the prior recall, is that this particular part failure can cause coolant to leak on the catalytic converter heat shield insulation causing a fire hazard. The connector of the hose in our vehicle literally started to deteriorate and crumble at multiple locations. The vehicle is only 8 years old. This has to be a related failure of an already identified defective component. The prior recall is noted as: 19V-308 / R29936 The vehicle required towing and the component was replaced at the local dealership at standard cost. We are obviously concerned that others with our particular year and model could experience a more catastrophic end.

After two days of ownership and 148 miles, the car threw a check engine light w/ the following message: "SLOW DOWN. The vehicle will reduce speed. Propulsion system failure." followed by, "Propulsion system service required.". This consequently causes the car to go into 'limp mode' unexpectedly while driving, drastically reducing speed. We are then instructed to take it to a shop. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

What component or system failed or malfunctioned, and is it available for inspection upon request? The front warning collision comes on when a car is not even close. Engine, a part in the engine area has been replaced twice. Transmission, not shifting properly when 2/3. How was your safety or the safety of others put at risk? The unit will try to brake. The check engine light has come on more than once. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes and No. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives, or others? Yes by a Volvo Dealer. Were there any warning lamps, messages, or other symptoms of the problem before the failure, and when did they first appear? Yes, transmission service and check engine light. Also red warning light appears on the window.

There are many form online stating that Volvo has an issue with water leaking/water drainage line from the sunroof. The water leaked into some components of the airbag and electrical system. After the first time taking to the dealership they were no issue with the system and the vehicle was fine that incident happened back in 2020. The same issue happened again where water was leaking in from the sunroof area (I am assuming because it looks the same as last time) this time the water is in the driver side, and there was a puddle of water forming where the gas and brake paddles are. After noticing the water puddle I try to close the sunroof and turns out the sunroof no longer functions with the electronic control right in front of the sunroof. I also took the initiative to open some of the trims where the side air bags are and it turns out that the area are completely soaked. I do no know if this will cause an issue to the airbag or not but I am worries that prolong exposure to water will compromised the integrity of the airbag system. What's was is that since it affected the electronic for the sunroof what if it affect the sensors for the air bag system.

It started with the right rear passenger door not opening from the inside or outside of the car. At first you could lock the doors from the inside and then open the door, but now the door will not open at all. My left rear passenger door has started to do the same thing this week. It will only open about 50% of the time. The door handles are in good order, and this is not related to an accident. This is an extremely dangerous situation for my kids! If we were in a car accident or if there was a fire in the car they would not be able to escape. I have attempted to contact customer service, but have not been able to get a hold of them.

This Volvo was bought in Worcester, Massachusetts. We used to live in USA before moving to our home country The Netherlands. Taking the Volvo with us. For many months the car consumes extreme amounts of oil. Indicating low oil every time. We need to refill every 1200-2000 km. We notified our Volvo dealer over and over again when having scheduled maintenance. No thorough inspection was done. We felt unsafe when traveling long distances, afraid the engine would break down or insecure about the oil consumption and what was causing it. We had an independent Volvo specialist inspect the car and he knew there is a design flaw in the cylinder pistons. The full problem was described by Volvo in technical journal [XXX]. Due to the fact that the Volvo dealer did not take the problem seriously, we had been driving with this problem way too long causing extreme cylinder defects resulting in having to replace the entire engine with a new one. We feel this matter should have been addressed better by Volvo and we request compensation for the costs made. We also don’t understand why Volvo didn’t recall this batch of cars that were designed with too small cylinder pistons for the capacity of the engine causing heavy oil consumption. We look forward to your reaction. As we live in The Netherlands, kindly e-mail. The Volvo importer of The Netherlands was also contacted, but they redirected us to you as the car was bought in the USA. We have a full repair report that can be shared upon request. Also the faulty engine is still with the Volvo specialist as proof of the described problems. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)