2005 YAMAHA FZ6 Complaints

Hello, i ride this Yamaha FZ-6 motorcycle and I experience poor idling and engine stalls during riding, and last time this nearly led to accident, because the motorcycle slowed down in front of an overpassing automobile. I have bought this bike imported from USA. I am situated in Bulgaria, Europe. I saw there is a recall action about faulty TPS sensor. Kindly requesting any help for replacing this sensor by recall action. Thank you in advance for your kind support. [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

ENGINE OIL PAN CRACKED AFTER TORQUING DRAIN PLUG TO MANUFACTURERS SPEC. HAVE READ MANY OTHER COMPLAINTS OF THIS SAME OCCURRENCE. CONTACTED LOCAL DEALER AND YAMAHA AMERICA. BOTH DECLINED KNOWLEDGE OF DEFECT. YAMAHA AMERICA WAS QUITE SHORT, DID NOT WANT TO HEAR ANY DETAILS OF THE FAILURE, JUST STATED THAT THERE WERE NO RECALLS, ANY DEFECTS WERE NO LONGER UNDER WARRANTY. *TR

MY 2005 FZ6 RAN FLAWLESSLY TILL 4000 MILE THEN THE IDLE WAS DROPPING TO 600-800 AND THEN WOULD JUST DIE. I WOULD TURN KEY OFF AND TURN KEY ON AGAIN AND RESTART AND IT WOULD RUN FINE. IT HAPPENS TWICE A WEEK. ONCE ON WET PAVEMENT IT WAS FEELING BOGGISH I PULLED CLUTCH TO SEE AND IT WAS 600-800 AND DIED. I LET OUT CLUTCH AND ALMOST LOST IT. I READ ABOUT SEVERAL OTHER OWNERS EXPERIENCING SAME PROBLEM AND SOME RUMOR IT TO THE TPS SENSOR. *JB

MOTORCYCLE HAS BEEN IDLING POORLY AND STALLING WHEN COMING OFF INTERSTATE RIDING. GAS MILEAGE HAS ALSO BEEN DROPPING. ONLY RECENTLY, MOTORCYCLE STALLED IN CENTER LANE OF HIGHWAY AT TRAFFIC SIGNAL AT NIGHT, WOULD NOT RESTART. RECEIVED FAULT CODE 15 CORRESPONDING TO THROTTLE POSITION SENSOR. REPLACED PART. LEARNED OF SEVERAL OTHER 2005 FZ6'S WITH SIMILAR PROBLEM. *NM

I WAS RIDING HOME ON MY 2005 YAMAHA FZ6 MOTORCYCLE, WHEN THE ENGINE BEGAN IDLING VERY ROUGH. I HAD TO ROLL ON THE THROTTLE TO KEEP THE ENGINE FROM STALLING. THEN A FEW SECONDS LATER I PULLED IN THE CLUTCH AND THE ENGINE STALLED COMPLETELY. I WAS NOT ABLE TO RESTART THE ENGINE AFTER 4 ATTEMPTS. THEN I TURNED THE IGNITION OFF, AND TURNED IT BACK ON, AND THE ENGINE STARTED AS IF THERE WAS NO PROBLEM. OBVIOUSLY, TURNING THE IGNITION OFF AND BACK ON IS MERELY A BAND AID FOR THIS ISSUE, AND NOT A PERMANENT SOLUTION. PLEASE REFER TO THIS WEBSITE TO LEARN OF OTHER FZ6 OWNERS THAT HAVE EXPERIENCED THIS ISSUE. HTTP://FORUMS.SPORTBIKES.NET/FORUMS/SHOWTHREAD.PHP?T=7320 *JB

I AM AWARE OF SEVERAL DOZEN PEOPLE WHO HAVE HAD THE SAME PROBLEM I AM NOW HAVING WITH FAILURE OF THE THROTTLE POSITION SENSOR (TPS) ON A 2004-2005 YAMAHA FZ6. THIS CAUSES A NEW VEHICLE TO RUN POORLY AND STALL FREQUENTLY UNTIL THE PART IS REPLACED. *JB

METZLER Z4 MOTORCYCLE TIRE (FRONT) INTERNAL BELT BREAKING LOOSE AT 65 MPH IN MORNING RUSH HOUR TRAFFIC. THE TIRE IMMEDIATELY BECAME SO OUT OF ROUND THAT THE MOTORCYCLE COULD NOT BE RIDDEN MORE THAN 5 MPH. *NM

DT: THE CALLER SAID THAT WHILE HE RIDING THE ENGINE ON MOTORCYCLE BROKE OPEN AND ALL THE FLUID SPRAYED OUT. THE CALLER WAS GOING ABOUT 60 MPH. HE ALMOST LOST CONTROL ,BUT WAS ABLE TO STOP AND GET OFF THE MOTORCYCLE. HE HAD TO HAVE IT TOWED. DEALER , WHOSAID THEY WILL LOOK AT IT. THE CALLER CONTACTED THE MANUFACTURER AND LEFT A VOICE MAIL. MOTORCYCLE IS A YAMAHA R-1. *AK

THE MOTORCYCLE LOSES IGNITION, AS THOUGH THE "KILL SWITCH" WAS PRESSED. THE RPMS DROP TO ZERO AND THERE IS NO THROTTLE RESPONSE, ALTHOUGH LIGHTS AND GAUGES CONTINUE TO WORK. *JB

1) 2005 YAMAHA YZF R1. NORMAL EVERYDAY RIDING FOR 10,000 MILES. AFTER WORK I WARMED UP MY MOTORCYCLE TO 170 DEG F. 2) WHEN I SLOWED DOWN THE RPM'S DROPPED UNDER 1,000 AND THE MOTORCYCLE STALLS/DIES. IT DIED 3 MORE TIMES BEFORE I COULD GET TO A PLACE TO PULL OVER. AFTER I PULLED OVER I GOT OFF MY MOTORCYCLE AND THEN LET IT IDLE. THE IDLE WAS LOW BUT DID NOT DIE. I THEN RIDE MORE AND IT HAPPENED 1 MORE TIME. I HAD TO REV THE ENGINE TO KEEP IT FROM DYING. I STOPPED AND LET THE BIKE SIT FOR OVER 1 HOUR. AFTER I STARTED IT BACK UP EVERYTHING WAS RUNNING PERFECT AGAIN. I RODE ~80 MILES HOME WITH NO PROBLEMS. THE NEXT MORNING I STARTED THE MOTORCYCLE AND LET IT WARM UP TO 170 DEG F AGAIN. I TOOK OFF AND WHEN I WAS SLOWING DOWN THE BIKE JERKED MY FORWARD AND DIED. THE BIKE ALMOST FELL OVER. IT CONTINUED TO DO THEN WHEN I TEST RODE IT AROUND THE BLOCK. I THEN PARKED IT AND DROVE MY CAR TO WORK. I BEGAN DOING RESEARCH ON THE INTERNET AND FOUND THAT OTHER RIDERS ALSO HAD MY PROBLEM. AFTER I GOT HOME I TEST RODE MY BIKE AND EVERYTHING IS WORKING FINE. I ALSO RODE TO WORK TODAY WITH OUT ANY PROBLEMS. THIS IS COMMON WITH A PROBLEM THAT I READ ABOUT THE 2004 YZF R1 ALSO. IT LOOKS LIKE THE MOST COMMON FIX WAS REPLACING THE UPPER AND LOWER TPS SENSOR. I CALLED MY DEALER AND HE TOLD ME IT WAS MY THROTTLE BODY NOT IN SYNC. ALSO FROM WHAT I READ WAS A MISSED DIAGNOSED PROBLEM FROM YAMAHA. 3) I AM GOING TO MY DEALER TOMORROW TO FIX THE "THROTTLE BODY SYNC ISSUE" PLEASE REFER TO THIS WEBSITE AND THE ROUGHLY 100 OTHER RIDERS WITH THE 2004/2005 MODEL YAMAHA R1 HTTP://WWW.R1-FORUM.COM/FORUMS/SHOWTHREAD.PHP?S=&THREADID=98831&PERPAGE=20&PAGENUMBER=1. *JB