WORKHORSE Recalls

Feb 25, 2015 – Farber Specialty Vehicles (Farber) is recalling various specialty vehicles modified by Farber and equipped with model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack.

Sep 19, 2014 – Navistar, Inc. (Navistar) is recalling certain model year 2011-2012 Workhorse W62 Commercial Chassis manufactured June 21, 2010, to October 2, 2012. In the affected vehicles, the weld joining the right hand side exhaust down pipe to the exhaust manifold may fatigue.

Oct 17, 2013 – Navistar, Inc. is recalling certain model year 2012 Workhorse Custom Chassis W42 and W62 vehicles, manufactured from July 13, 2012, through October 12, 2012, and equipped with hydraulic brakes. In the affected vehicles, the brake fluid level indicator (FLI) may not properly detect a low brake fluid level situation and warn the driver.

Feb 20, 2013 – Navistar is recalling certain model year 2011-2012 Workhorse Custom Chassis W42 and W62 vehicles, manufactured from July 18, 2011, through July 12, 2012, and equipped with hydraulic brakes. The brake fluid level indicator (FLI) may not properly detect a low brake fluid level situation and warn the driver.

Jun 15, 2011 – NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2011 W42 AND W46 WORKHORSE CHASSIS MANUFACTURED FROM JANUARY 1, 2011, THROUGH MAY 25, 2011. THE STEERING WHEEL COMPONENTS DO NOT MEET DESIGN SPECIFICATIONS. AS A RESULT, THE STEERING WHEEL INNER PIECE MAY SEPARATE FROM THE OUTER PIECE, WHICH MAY DECREASE THE DRIVER'S ABILITY TO CONTROL THE VEHICLE.

Jul 27, 2010 – NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2011 WORKHORSE W22 AND R26 TRUCKS MANUFACTURED FROM FEBRUARY 5, 2007 THROUGH MAY 24, 2010. THE FUEL-FILL CAP ASSEMBLIES USED TO SEAL THE UNUSED SIDE OF THE DUAL-FILL GASOLINE FUEL TANK WERE PRODUCED WITH A HOSE MATERIAL THAT DID NOT MEET DESIGN SPECIFICATIONS. DURING NORMAL USAGE THE HOSE MATERIAL MAY DETERIORATE WHICH MAY RESULT IN FUEL LEAKS.

Jul 06, 2010 – NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2008 WORKHORSE R20 CHASSIS MANUFACTURED FROM FEBRUARY 5, 2007 THROUGH SEPTEMBER 24, 2008, EQUIPPED WITH CATERPILLAR C7 ENGINES. THE #5 AND #6 FUEL LINES MAY CRACK AT THE FASTENING POINT TO THE COMMON FUEL RAIL AND CAUSE A FUEL LEAK.

Apr 16, 2010 – WORKHORSE IS RECALLING CERTAIN MODEL YEAR 2010 W42, W62 AND MODEL YEAR 2011 W22 TRUCKS AND BUILT WITH A GENERAL MOTORS GASOLINE ENGINE AND EQUIPPED WITH REMY ALTERNATOR. A LOW RESISTANCE ELECTRICAL SHORT IN THE ALTERNATOR'S VOLTAGE REGULATOR MAY OCCUR.

Nov 19, 2009 – CUES, INC. IS RECALLING CERTAIN MODEL YEAR 2007-2009 SERVICE VEHICLES BUILT ON VARIOUS CHASSIS EQUIPPED WITH CARRIER AIRV CEILING UNITS, MODEL NOS. 68RV0010BA, 68RV0012CA, AND 68RV0010EA. THE HEATER ELEMENT IN THESE ASSEMBLIES MAY BE DEFECTIVE WHICH COULD CAUSE THE UNIT TO CREATE SMOKE OR SPARKS.

Apr 03, 2009 – NAVISTAR IS RECALLING CERTAIN MODEL YEAR MY 2001-2008 WORKHORSE W20, W21 AND W22 CHASSIS AND CERTAIN MODEL YEAR 2009 THROUGH 2011 MONACO RV ADMIRAL, ARISTA, MONARCH, AND RIPTIDE RECREATIONAL VEHICLES EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG. THE DRIVER WOULD NORMALLY HAVE WARNING OF THE BRAKE DRAG IF UNDETECTED BY THE DRIVER.