GOODYEAR WRANGLER TIRES Complaints

Concerning Goodyear Wrangler Trailrunner AT P275/65/20 tires that came stock with my 2022 GMC Sierra 2500HD, which currently has 42,000 miles on it. While driving a round trip of no more than 30 miles the evening of 11/29/24, I noticed a slight repetative jaring motion, which I initially attributed to a potential transmission issue. The bump rapidly worsened halfway though the drive. Upon inspection at the time, I could not see any visible damage to the tire. However, the issue escalated aggressively during my return home, resulting in the tire blowing out and detreading entirely. This failure caused significant damage to the body of my truck, amounting to an estimated $3,500 in repair costs. I believe this incident is due to a defect in the tire, as such occurrences are highly uncommon and unexpected from a product of your reputation. I have oil changes as recommended by the trucks service maunual and with ample tread left on the tire and good scores of inspection it begs the question on how a tire could fail so abruptly. I have 3 other tires with ample tread which should last at least another 10k miles but I'm gravely concerned with continued use of them for fear another blowout could cause a fatal accident.

The contact owns a 2011 Ram 1500 equipped with Goodyear Tires, Tire Line: Wrangler A/T, Tire Size: 265/70/R17, DOT Number: 1PL1YJC1R. The contact stated that while the vehicle was in for routine maintenance, the mechanic discovered that all four tires had sustained severe cracking and tread separation. The manufacturer and local dealer were notified of the failures. The failure mileage was 15,467.

Tires lt275/65r20 is the size. I purchased my truck Oct 2023. The day after i got home. I noticed a bulge in the sidewall of the front tire. I took it to the dealer the next day and they replaced it. But not after they accused me of hitting something. Luckily i had the picture the salesman had sent prior to me purchasing the truck and it was visible there. So a few weeks noticed 2 tires had same problem. Dealer again tried to say it was caused by an impact. They would not replace. so i called goodyear who had no problem replacing them at Belle tire. This past sunday, same tires that were replaced had a bulging in the side walls again! Belle tire replaced AGAIN under goodyear warranty but with 2 different good year tires. So I don't know if this is a good year defect or wrong tire being sold for these large trucks. The safety of my family is important to me, and these tires problems are scary. I purchased this truck from Hubler Chevrolet in Indianapolis.

Goodyear Wrangler All-Terrain Adventure, LT265/70R18. On [XXX] at 113806 miles, I discovered that the driver's side front tire on the vehicle was flat in my driveway. Investigation revealed a puncture in the tread of the tire, caused by a gravel stone still lodged in the tire. Based on the amount of protrusion of the stone and the lack of any visible wear on it, I concluded that the stone must have originated in my gravel driveway when returning home the night before. The tire had been installed on 6/20/2023 at 104513.5 miles, being in service for 1 year and 9293 miles, not even 20% into its expected life. Initial assessment of the damage to the tire, including the puncture size and longitudinal shape, suggests that repair will not be feasible and the tire will require replacement. While a flat tire due to foreign objects is commonplace, the safety concern here is that a simple small stone from a gravel driveway should not have been able to cause the failure of a 'Kevlar reinforced' all-terrain truck tire. I believe the materials or construction of these tires may be defective and may have insufficient tensile strength in the tread material, causing them to yield and fail at much lower forces than are to be expected from tires in highway use. At any rate a well-packed gravel driveway that has been in use for many years should not be a challenge to the safety and performance of a truck tire rated for highway use. This tire failure comes less than a month and 1000 miles after a more dramatic and catastrophic failure of another tire of the same model on the same vehicle. While coincidence cannot be ruled out, two failures of the same model tire, both related to weak or defective tread sections, points to possible defects that should be investigated. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Goodyear Wrangler All-Terrain Adventure, LT275/70R18 Tire installed new on [XXX] at 79892 miles. Tires were properly maintained including proper inflation and rotated. On [XXX] at 112745 miles the driver side rear tire suffered a sudden and catastrophic tread separation failure. At the time of failure, tire had been in service for 33 months and 32,853 miles, and had significant tread life remaining. Vehicle was travelling at approximately 55 mph on an asphalt highway on a hot, dry day. The separated tread damaged the rear body panel and severed the body structural support member in half. The vehicle was brought to a controlled stop, the separated tread was retrieved from the roadway, and the spare tire was installed. The tire was replaced the following day. Given that the tire was only about 50-60% into its usable life and well within the 50,000 mile warranty, this failure was unexpected. Goodyear has not provided any method to contact them directly and instead referred me to local retailers who have been unable to process the warranty claim. A second, much newer tire of the same model on the same vehicle failed in a different manner just 3 weeks and 1000 miles later, causing me concern of structural or material defects with these tires. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2011 Ram 1500 equipped with Goodyear Tires, Tire Line: Wrangler AT Adventure, Tire Size: 265/70/R17, DOT Number: PL1YJC1R0219. The contact stated while driving at an undisclosed speed, the TPMS warning light illuminated. The vehicle was taken to an independent mechanic, where the tires were diagnosed with tread separation. The contact was informed that all 4 tires needed to be replaced. The tires were replacement tires. The tires were not replaced. The manufacturer was not notified of the failure. The tire failure mileage was approximately 15,000. The vehicle failure mileage was unknown.

Goodyear Wranger At Trailrunner 275 65R20. I was heading home with my 14 year old daughter Sunday night. When I was merging on the on ramp to the highway and I felt a vibration. So I was in the process of slowing down and boom. My truck went broadside in the highway. I gathered it up and got all together. I don’t have a single dash light on or anything. The tire was still holding air. A matter of fact it still is. But when the tread came off it destroyed my bedside and bumper. My truck only has 32,473 miles on it. The tires are rated for 55,000. I just want something to happen to the manufacturer. If that would’ve happened to the right front it would’ve been bad. Or if it happened to a mom and kids. This is not good.

GOODYEAR WRANGLER LT275/65R20 LOAD E TREAD ON PASSENGER REAR TIRE PEELED OFF AND CAUSED DAMAGE TO VEHICLE AND THE TRAVEL TRAILER BEING TOWED.

The contact owns a 2022 GMC Sierra Denali 3500 equipped with Goodyear Tires, Tire Line: Wrangler, Tire Size: LT275/65/R20. The contact stated that while her husband was driving 60 MPH and hauling a camper, the passenger’s side rear tire experienced a blowout. The driver was able to change the tire. The tire struck the camper and caused damages. The vehicle was taken to a tire center, where it was determined that the tire was defective. The tire was replaced. The driver sustained injuries to his back, and medical attention was provided. There was no Police report filed. The manufacturer was contacted. The failure mileage was approximately 31,000. The approximate vehicle and tire failure mileage was 31,000.

The contact owns a 1998 Jeep Cherokee equipped with Goodyear Tires, Tire Line: Wrangler Radial A/S, Tire Size: 275/75/R15, DOT Number: 1PJHLFNWR. The contact stated that he had purchased two tires from Walmart that were installed in the rear of the vehicle. The contact stated while driving from a complete stop, the vehicle started wobbling. The contact stated that the failure occurred increasingly as he continued driving, causing him to pull to the side of the road. The vehicle was taken to Walmart, where it was inspected, and the contact was informed that the rear tires were out of round and the tread had separated. The manufacturer was notified of the failure and informed the contact that he needed to drive to the nearest Goodyear dealer for the tire replacements; however, the nearest Goodyear was 100 miles away. The tires were not replaced. The contact was awaiting a call back from the manufacturer. The tire failure mileage was approximately 200. The vehicle failure mileage was approximately 200,000.