TOYO OPEN COUNTRY TIRES Complaints

TL* THE CONTACT OWNS A 2004 CHEVROLET EXPRESS 3500 EQUIPPED WITH TOYO OPEN COUNTRY H/T TUFF DUTY TIRES, SIZE: LT245/75/R16 TIRES. WHILE DRIVING 65 MPH, THE CONTACT HEARD A LOUD NOISE AND THE REAR DRIVER SIDE TIRE BLEW OUT. THE VEHICLE WAS TOWED TO A DEALER WHO DIAGNOSED THAT ALL FOUR TIRES HAD CRACKS AND NEEDED TO BE REPLACED. IN ADDITION, MULTIPLE PARTS NEEDED TO BE REPLACED. THE TIRES WERE REPLACED, BUT THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE FAILURE MILEAGE WAS 120,187 AND THE TIRE FAILURE MILEAGE WAS 25,982.

TL* THE CONTACT OWNS A 1995 DODGE RAM 2500 EQUIPPED WITH TOYO TIRES OPEN COUNTRY A/T SIZE LT26570R17. THE DOT NUMBER WAS NOT AVAILABLE. THE CONTACT STATED THAT THE DRIVER'S SIDE FRONT PASSENGER TIRES BLEW DUE TO TREAD SEPARATION WHILE HE DROVE 45-65 MPH, CAUSING DAMAGED TO THE RUNNING BOARD AND BED. THE MANUFACTURER DENIED ASSISTANCE WITH THE REPAIR. THE PASSENGER SUFFERED INJURIES TO THE LOWER BACK. THE TIRES WERE REPLACED. THE TIRE FAILURE MILEAGE WAS 22,000. RK

I WAS TRAVELING DOWN AN INTERSTATE WHEN A REAR TIRE BLEW OUT. THE TIRE IS A TOYO CROSS COUNTRY A/T. HE TIRE SEPARATED COMPLETELY LEAVING THE SIDEWALLS ON THE RIM AND THE TREAD & BELTS & REST OF THE TIRE TORE OFF IN ONE PIECE. LUCKILY, THERE WAS NO ACCIDENT/ INJURY. I LOOKED UP RECALLS AND FOUND THERE IS A RECALL. I DID NOT RECEIVE A NOTICE. I HAVE TRIED TO CONTACT TOYO AND BEEN ON HOLD FOR OVER AN HOUR AT A TIME, LEFT MESSAGE WITHOUT RETURN CALL. THE TIRES HAVE LESS THAN 20,000 MILES ON THEM. I AM NOW VERY CONCERNED ABOUT THE SAFETY OF THE THREE REMAINING TIRES. THERE WAS ONLY MINOR PROPERTY DAMAGE TO THE TRUCK. *JB

TL* THE CONTACT OWNS A 2007 CHEVROLET SILVERADO 2500 EQUIPPED WITH TOYO OPEN COUNTRY ALL TERRAIN TIRES, LINE SIZE 37X13.5R20 DOT 73TEC7N2312. THE CONTACT STATED THAT THE TIRE SIDE WALLS WERE SEPARATING. THE CONTACT MENTIONED THAT ONE OF THE TIRES WAS REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ADDITIONAL ASSISTANCE SINCE THEY BELIEVED THE TIRES WERE NOT DEFECTIVE.THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 98,000 AND THE CURRENT MILEAGE WAS 100,000.

2011 TOYOTA HIGHLANDER WITH LESS THAN 13K MILES HAS TIRES WITH VERY LITTLE TREAD LEFT ON THEM. WAS TOLD BY TOYOTA TECH THAT IT NEEDS NEW TIRES. LESS THAN ONE YEAR OLD AND THE TIRES ARE BALDING. THIS POSES A SAFETY HAZARD AND IS NOT ACCEPTABLE. *TR

TOYOTA HIGHLANDER 19" RIMS WITH TOYO OPEN COUNTRY A20 TIRES ARE VERY UNSAFE. THIS TIRE/WHEEL COMBINATION WAS STANDARD ON 2008/09 LIMITED AND SPORT HIGHLANDERS. MY 2009 HIGHLANDER WOULD SLIP ALL OVER THE PLACE IN WINTER DRIVING. BY FAR THE WORST WINTER VEHICLE I EVER OWNED AND I'VE OWNED PLENTY THAT WERE NOT ALL-WHEEL DRIVE. LUCKILY THE TRACTION CONTROL SYSTEM IS GOOD AND SAVED ME FROM SEVERAL ACCIDENTS. TOYOTA USED VERY LARGE 19" RIMS AND PERFORMANCE TIRES ON THE VEHICLE. THE TIRES WERE WORN OUT AFTER 18 MONTHS AND 21,000 MILES. WHY TOYOTA THOUGHT BIG WHEELS AND PERFORMANCE TIRES WERE IMPORTANT TO AN SUV PURCHASER IS BEYOND ME. TOYOTA ALSO REFUSES TO STAND BEHIND THEIR SAFETY DEFECT (NOT TO MENTION THE TIRES ONLY LASTED 21,000 MILES). I PURCHASED 17" RIMS ON MY OWN AND TOYO PROVIDED CREDIT FOR 2 OF THE 4 NEW OPEN COUNTRY HT TIRES AND THE SUV IS NOW MUCH SAFER - IT NO LONGER FEELS LIKE I AM RIDING ON ROLLER SKATES! *TR

THE TIRES ON MY 2009 TOYOTA HIGHLANDER HYBRID FAILED AND HAD TO BE REPLACED. THE CAR WAS UNSAFE TO DRIVE IN THE SNOW EVEN THOUGH IT WAS AN ALL WHEEL DRIVE VEHICLE. *TR

THIS REPORT CONCERNS A 2008 TOYOTA HIGHLANDER LIMITED THAT WAS PURCHASED NEW AS A DEALER LEFTOVER. THE VEHICLE HAS JUST OVER 20,000 MILES AND THE TOYO OPEN COUNTRY A20 TIRES ARE SHREDDING AND HAVE PIECES OF THE TREAD MISSING. THIS IS ON ALL FOUR TIRES. THE TIRES ARE P245/55R19 WITH A DOT NUMBER CXHH-DK80508. I HAVE NOT YET CONTACTED TOYO, HOWEVER FROM OTHER COMPLAINTS NOTED, IT DOES NOT SEEM THAT THE MANUFACTURER WILL WILLINGLY ACCEPT THE DEFECT OF PREMATURE WEAR OF THIS TIRE. THE TIRE SIZE IS UNIQUE, WHICH CAUSES THE REPLACEMENT COST TO BE MUCH HIGHER THAN MORE STANDARD SIZES. *TR

TOYO OPEN COUNTRY A20 TIRES 245/55/19 WHICH CAME AS STANDARD EQUIPMENT ON 2008 TOYOTA HIGHLANDER HYBRID WORE SIGNIFICANTLY AND PREMATURELY. AT 18000 MILES THESE TIRES WERE WORN NEARLY TO THE WEAR BARS RESULTING IN EXTREMELY POOR WET AND SNOW TRACTION LEADING TO SLIDING AND HYDROPLANING. THE TREAD ALSO BEGAN TO PEEL ON ONE TIRE. I DID NOT NOTICE THE WEAR UNTIL IT WAS POINTED OUT BY A MECHANIC AS THEY LOOKED GOOD FROM A DISTANCE AND I DIDN'T THINK TO CHECK THE TREAD ON A 60,000 MILE WARRANTY TIRE AT ONLY 18000 MILES. TOYOTA STATES THAT THIS IS NORMAL WEAR AND TOYO DOES NOT HONOR A MILEAGE WARRANTY ON OEM TIRES. THESE ARE DANGEROUS TIRE AS THEY WERE SOLD ON ONE OF THE BEST SELLING FAMILY VEHICLES IN THE INDUSTRY AND COULD RESULT IN A SERIOUS ACCIDENT ESPECIALLY COMING INTO THE WINTER MONTHS AS OWNERS OF LOW MILEAGE VEHICLES MAY NOT REALIZE THAT THE TIRES ARE ACTUALLY COMPLETE WORN OUT ALREADY. *TR

TIRE FALLING APART AND FLAKING INCLUDING PREMATURE WEARING ON FACTORY OEM TOYO OPEN COUNTRY 245-55X19 A20 TIRES WHICH WERE ON MY 2008 TOYOTA HIGHLANDER PURCHASE BRAND NEW ON JUL 2008. APPROXIMATE CURRENT MILEAGE IS 20,195. ALL TIRES ARE SHOWING THE SAME ABNORMAL WEAR AS VERIFIED BY TOYOTA DEALER. THERE ARE NUMEROUS ONLINE COMPLAINTS OF SIMILAR OWNERS WITH PICTURES OF THE UNUSUAL WEARING. MINE ARE WORSE THAN ARE DESCRIBED AS CONCURRED BY TOYOTA SERVICE ADVISORS. *TR