2006 BMW 330XI Complaints

“The PCV valve heater (positive crankcase ventilation heater) on my 2006 BMW 330xi failed and caused an engine bay electrical fire. This component is under an active BMW safety recall for fire risk. The failure happened suddenly while driving, with no prior warning lights or symptoms. Smoke began coming from the engine area, followed by visible flames. My safety was put at risk, and I immediately exited the vehicle. The vehicle became inoperable and was towed by the City of Chicago. The car has since been declared a total loss due to the fire. The vehicle is currently in the city impound and available for inspection upon request. The problem has not been inspected by a dealer yet because the vehicle was destroyed before I received the recall repair.”

Takata Airbag Safety Recall Vin:[XXX] I live in Commonwealth of Pennsylvania which according to BMW and NHTSA is Zone B. My vehicle has a built date of 10/19/2005 330xi e90 model. The time in which the degradation to the propellant poses an unreasonable risk to safety is stated as a 10-15 year time frame. My car is almost 18 years old but BMW has NOT prioritized my vehicle's airbag. My vin number might not have made the list for zone A but its in zone B. I should have to wait until someone gets killed or injured. My name is [XXX] and can be reached at [XXX] My BMW dealer is Otto's BMW West Chester, PA 610399-8067 Please demand that BMW comply with the recall information listed on clearly on your NHTSA site and BMW of America's site. (Site Last updated 01/14/2019) Thank you. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

The contact owns a 2006 BMW 330XI. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2006 BMW 330XI. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Vin tool confirms remedy not yet available.

The contact owns a 2006 BMW 330XI. The contact stated that the air bags warning and seat belts warning lights illuminated intermittently. The contact took the vehicle to the dealer and was informed that the failure was related to NHTSA Campaign Number: 17V428000 (Air Bags) however, the VIN was not included. The vehicle was not repaired. The manufacturer made aware of the failure. The approximate failure mileage was 123,100.

The contact's brother owns a 2006 BMW 330XI. The contact stated while his mother was driving approximately 30-40 MPH, she smelled a burning plastic odor and the vehicle started to overheat. There was no warning light illuminated. The contact stated that the failure had been reoccurring while driving. The coolant temperature warning light illuminated. The contact veered to the side of the road. The vehicle was towed to an independent mechanic but was not diagnosed or repaired. The contact later received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure and referred the contact to the dealer for a diagnostic test. The vehicle was diagnosed or repaired. The failure mileage was approximately 75,000. VIN tool confirms parts not available.

The contact owns a 2006 BMW 330XI. The contact stated while driving 40 MPH, the vehicle began to overheat. The check engine warning light, the coolant temperature warning light, and other unknown warning lights were illuminated. The contact veered to the side of the road and waited. The contact then continued driving. The contact stated that the failure had been reoccurring increasingly while driving and smoke would come out from underneath the hood and through the vent inside of the vehicle while driving, and the vehicle would occasionally stall. Additionally, the contact also stated that the vehicle stalled and failed to restart twice. The vehicle was then towed twice to the contact's residence. The contact's father, who is an independent mechanic, could not determine the cause of the failure. The vehicle was not diagnosed or repaired. The vehicle remained at the residence undrivable. The contact then received notification of NHTSA Campaign Number: 22V119000 (Engine And Engine Cooling) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 300,000. VIN tool confirms parts not available.

We took our recently purchased BMW 2006 330xi in for recalls and a few fixes. However, the BMW service center wasn't able to fix one of the issues through the recall process since it doesn't show up for our vehicle. However, everything that I read suggests that it was a recall for this make and model. We are not sure if it was supposedly addressed before we purchased the vehicle and it is now a reoccurring issue or it is a first-time issue. The airbag/seatbelt warning light is present for passenger seat occupancy detector faults. The BMW service center said it was the sensor in the front passenger seat and offered to fix it for $1000 plus. We opted to not fix it until we checked further into the situation. The light for the passenger airbag saying that it is off is currently lit, and the airbag/seatbelt light remains on at this time. Looking for more information on this issue.

GOING THROUGH MY NEWLY PURCHASED, USED 2006 330XI, I FOUND SEVERAL WARNINGS FOR FRONT HEADLIGHT MALFUNCTIONS. FURTHER INVESTIGATION SHOWED ADAPTIVE FUNCTIONS WERE DISABLED AND THE LEFT LOW BEAM WAS STUCK POINTING LEFT. WHILE THE BULBS THEMSELVES WERE STILL FUNCTIONING, THE LIGHT WAS POINTED DIRECTLY AT ONCOMING TRAFFIC AND DID NOT ILLUMINATE THE ROAD IN FRONT OF ME. OPENING THE ACCESS PANEL AT THE REAR OF THE HEADLIGHT ASSEMBLY SHOWED MULTIPLE BARE WIRES INSIDE OF THE SEALED HOUSING, THE INSULATION HAD SIMPLY STARTED TO FLAKE OFF OF THE WIRES RENDERING ALL CENTERING AND LEVELING FUNCTIONS OF THE LIGHT INOPERABLE. RESEARCH HAS SHOWN THIS IS A WIDESPREAD PROBLEM WITH BMW HEADLIGHTS, FOR ADDITIONAL DOCUMENTED DATA AND CASES PLEASE REFERENCE THE FOLLOWING FORUM THREAD : HTTPS://WWW.BIMMERFEST.COM/THREADS/

I DIDN'T GET ANY PICTURES. MY SISTER HAS A 330 XI DRIVE TO DENVER AT ONE POINT OF THE DRIVE HURDLE A POP IN THE CAR. WHERE DRIVING FAST NO POT HOLES HIT. AFTER FURTHER INVESTIGATION WITH A MECHANIC FRIEND OF MINE. WE GOT UNDER THE CAR THE CAR AND NOTICED THE PASSENGER SIDE AXEL WAS RESTING ON THE FRAME OF THE CAR. THERE WHERE 3 MOTOR MOUNT BOLTS SHEARED OFF THE MOTOR MOUNT BRACKETS AN 1 LAYING ON THE SCID PLATE UNDER THE CAR. I HAVE READ SOME OTHER TESTIMONY ABOUT THIS PROBLEM ON THE INTERNET. I BELIEVE THIS COULD BE A DEFINITE PROBLEM SO I HOPE YOU LOOK IN TO THIS PROBLEM THANK YOU.