2012 BMW 528I Complaints

MY 2012 BMW 528I STALLED TWICE 2 WKS AGO WHEN I WAS SLOWING DOWN AT A TRAFFIC SIGNAL. THE DISPLAY SHOWED EITHER "DRIVETRAIN MALFUNCTION" OR "TRANSMISSION MALFUNCTION". IMMEDIATELY I TURNED ON THE HAZARD LIGHTS, SLOWLY CHANGED LANES SLOWLY AND COME TO A HALT, BY WHICH THE WARNING WAS GONE AND I DROVE HOME AT LESS THAN 15 MPH. THE NEXT MORNING THE CAR SEEMED FINE AND I WAS ABLE TO DRIVE IT TO A LOCAL MECHANIC, WHO ADVISED A BMW SERVICE. I TOOK THE CAR TO AN AUTHORIZED SERVICE CENTER (ASC) FOR VERIFICATION AND WAS DIRECTED TO COME BACK IN FEW DAYS; WITHIN THAT WEEK IT HAPPENED AGAIN. I WENT TO ANOTHER ASC TO HAVE IT FULLY DIAGNOSED. IT WAS DETERMINED THAT FAULTY GUIDES IN THE TIMING-CHAIN CAUSED IT. I HAD NO IDEA IT WAS DESIGN FLAW UNTIL I READ ABOUT IT IN ONLINE. THE SERVICE MANAGER ALSO SAID THEY HAVE SEEN IT HAPPEN IN MANY CARS AND SOMETIMES UNDER 30K MILES AND IN FEW INSTANCES NEEDING ENTIRE ENGINE REPLACEMENT FOR $15000. I SEE SEVERAL CUSTOMERS WITH N20 AND N26 ENGINES HAVING THIS ISSUE SAME AS WITH N63 ENGINES. I CONTACTED BMWUSA AND LODGED A COMPLAINT ABOUT THIS FOR REIMBURSEMENT REFERRING TO NHTSA TSB 110614, BUT WAS DENIED. I WAS TOLD BMW KNEW OF THIS ISSUE AND EXTENDED THE WARRANTY TO 7Y/70K. I WAS NOT AWARE OF THIS AND MYGARAGE ON BMWUSA IS NOT SHOWING IT. I HAVE RECEIVED SEVERAL MARKETING INFO ON NEW BMW AND LEASES INSTEAD. CLASS ACTION LAWSUITS HAVE BEEN LODGED IN NORTH AMERICA AND DEATHS IN IRELAND REQUIRING A COURT ORDER FOR MANDATORY RECALL. 1) WILLIAMS, ET AL. V. BMW OF NORTH AMERICA LLC, ET AL., CASE NO. 2:17-CV-1156. 2) GELIS, ET AL. V. BAYERISCHE MOTOREN WERKE AKTIENGESELLSCHAFT, ET AL., CASE NO. 2:17-CV-07386 3) WWW.STROSBERGCO.COM/CLASS-ACTIONS/BMW REFERENCE: INVOICE, BMW MYGARAGE PAGE, BLOG, NJ LAWSUIT ETC. WWW.BMWBLOG.COM/2013/09/29/BMW-RECALL-2012-14-MODELS-N20-N26-ENGINE WWW.THEJOURNAL.IE/CARS-SOLD-IRELAND-BMW-RECALL-4002999-MAY2018

SIX MONTHS I STARTED HEARING A HIGH PITCH NOISE AND IT ONLY GOT WORSE OVER THE FEW MONTHS. TWO WEEKS AGO (01/10/2020 AND 01/17/2020), IN THE NIGHT AROUND 8PM, MY BMW 528I CAR STALLED AT A TRAFFIC LIGHT IN CULVER CITY, CALIFIRNIA. IT FLASHED AN ERROR MESSAGE ON THE DISPLAY VERY BRIEFLY AND IT APPEARED TO BE "DRIVE TRAIN MALFUNCTION". STALLED IN THE MIDDLE OF THE STREET, MY FIRST REACTION WAS TO TURN ON THE HAZARD LIGHTS AND HOPE NOBODY HITS ME FROM THE BACK, AS I WAS NOT ABLE TO DRIVE FORWARD. BEFORE I COULD TAKE MY PHONE OUT AND TAKE A PICTURE OF THE SCREEN, THE ERROR SCREEN VANISHED. I PRESUMED THE "ERROR" WOULD BE SAVED IN THE SYSTEM AND SHUT THE ENGINE OFF, RESTARTED AND STARTED TO DRIVE AND PROCEED. AT BOTH THESE TIMES THERE WERE CARS BEHIND ME AND I TURNED ON THE HAZARD LIGHT TO WARN THE OTHER DRIVERS OF MY INABILITY TO DRIVE. I TOOK THE CAR TO TWO BMW SERVICE CENTERS. ONE OF THE SERVICE MANAGERS SAID HE CANNOT SAY WHAT THE ISSUE IS WITHOUT DOING A DIAGNOSIS, BUT THE PROBABLE CAUSE IS SOMETHING TO DO WITH THA OIL-PUMP OR THE CAM-SHAFTS AND RELATED TO TIMING. I TOOK THE CAR TO ANOTHER SERVICE CENTER AND HERE I LEFT THE CAR BEHIND FOR A SPECIFIC DIAGNOSIS. I WAS TOLD THE ISSUE IS RELATED TO TIMING CHAIN AND PLASTIC PARTS THAT HOLD THE CHAIN IN PLACE, DETERIORATE OVER TIME. I WAS TOLD THAT IT IS A COMMON ISSUE AND IT IS MY LUCK THAT THE TIMING CHAIN DID NOT RIP APART AND CAUSE AN ENGINE SEIZURE, WHICH WOULD HAVE COST ME $15000 IN REPAIRS THAN WHAT I WAS BILLED AROUND $6000. INCIDENTALLY, FEW MONTHS AGO THERE WERE OTHER PLASTIC PARTS THAT HOLD THE ENGINE IN PLACE ALSO DETERIORATE AND IT WAS SHAKING THE CAR. I HAD REPLACED THEM AT A CERTIFIED MECHANIC. THIS HAD COSTED ME ANOTHER $2000 PLUS IN REPAIRS. I HAVE MAINTAINED THE CAR IN GOOD CONDITION AND NEVER MISSED ANY SERVICE APPOINTMENTS. I HAVE BILLS OF ALL THE SERVICES PERFORMED ON THE CAR.

WHILE DRIVING DOWN THE 95 HIGHWAY MY CAR SHOWED A FUEL SUPPLY ERROR THEN POWERED DOWN AND STOPED AND WOULDN'T RESTART. I HAD IT TOWED TO A HOTEL AND THE FOLLOWING MORNING IT STARTED WHILE THE TOW TRUCK LOADED IT TO TAKE TO THE DEALER. I HAD A FULL TANK OF GAS AT THE TIME. I COULD HAVE BEEN KILLED WITH MY KIDS. TOWED IT TO BMW AND ALL THEY TOLD ME WAS TO REPLACE MY BATTERY EVEN THOUGH I HAD A PERFECTLY GOOD BATTERY AND THE AND EVERYTHING REQUIRING A BATTERY WORKED LIKE RADIO, LIGHTS ETC. I BOUGHT A NEW BATTERY FROM THEM AND THE TECH DROVE THE CAR FOR 30 MILES. WITHIN 2 HOURS AFTER LEAVING THE DEALERSHIP MY CAR DID THE SAME THING WHILE EXITING THE HIGHWAY AND SLOWING DOWN AT A STOP LIGHT. A DIAGRAM FLASHES ON THE CONSOLE AND THEN A MESSAGE ABOUT THE FUEL SUPPLY. I WAS ASSISTED BY CALLING 911 TO GET MY KIDS AND I TO SAFETY AND MY CAR OUT THE WAY. THERE IS A RECALL ON THE FUEL MODULE OR PUMP FOR MY YEAR AND MAKE BUT BMW CLAIMS MY VIN IS NOT INCLUDED. THIS IS DANGEROUS, PEOPLE CAN GET KILLED IF THE CARS ARE STALLING WHILE IN MOTION.

WHILE DRIVING MY CERTIFIED 2012 BMW 528I, WHICH HAS AN N20 ENGINE, THE "DRIVETRAIN MALFUNCTION, MAXIMUM OUTPUT NO LONGER AVAILABLE, DRIVE MODERATELY" WARNING LIGHT APPEARED ON MY DASH AND ALERTED ME THAT THERE WAS A POTENTIAL ISSUE WITH MY VEHICLE. PRIOR TO THE ALERT SIGNALING MY ATTENTION, I WAS DRIVING ON A HEAVILY TRAFFICKED HIGHWAY WITH SPEED LIMITS RANGING FROM 35 MPH TO 60 MPH. I DROVE APPROXIMATELY 20 MINUTES / 13 MILES TO MY DESTINATION BEFORE THE "DRIVETRAIN MALFUNCTION" INDICATOR LIGHT ALERTED ME. LUCKILY, I WAS NEAR A DRIVEWAY TO PULL OFF INTO A PARKING LOT WHEN THE WARNING LIGHT APPEARED. AS SOON AS THE WARNING LIGHT APPEARED MY CAR IMMEDIATELY BEGAN TO IDLE ROUGHLY, AND MY ENGINE WAS NOT RUNNING AT FULL CAPACITY. I WAS ONLY ABLE TO PULL INTO A PARKING STALL AND MOMENTS FOLLOWING THE "DRIVETRAIN MALFUNCTION" ALERT, AN OIL LIGHT ALSO ALERTED ME ON MY DASH. MY CAR IS UP TO DATE ON ALL REQUIRED SERVICES. I HAVE SERVICED MY VEHICLE AT MY LOCAL BMW DEALERSHIP. AT ALL SERVICE APPOINTMENTS I REQUESTED CURRENT BULLETINS. MY VEHICLE HAD NO KNOWN PROBLEMS, OR WARNING INDICATORS OR ALERTS THAT I WAS MADE AWARE OF. WHEN I SAFELY PULLED OFF THE ROAD INTO A PARKING LOT MY CAR SHUT DOWN COMPLETELY, WOULD NOT RESTART, AND LOCKED UP. I WAS NOT ABLE TO PUT MY CAR IN NEUTRAL. MY VEHICLE WAS TOWED TO THE BMW DEALERSHIP WHERE THE DEALERSHIP INSPECTED THE VEHICLE AND ALERTS. THE DEALERSHIP DIAGNOSED THE VEHICLE AND SAID THAT THE TIMING AND OIL PUMP CHAIN MALFUNCTIONED AND THE TOTAL COST ESTIMATE WOULD BE 13,651 + TAX. AFTER RESEARCHING SEVERAL ONLINE BULLETINS, BMW FORUMS AND NEWS ARTICLES, THE "DRIVETRAIN MALFUNCTION" HAS BEEN AN ISSUE WITH OTHER BMW CUSTOMERS, AND BMW NORTH AMERICA ISWAS AWARE OF THIS ISSUE AND HAZARD. EXPERIENCING THIS MALFUNCTION COULD HAVE POSED A RISK TO MY SAFETY AND THE SAFETY OF MY PASSENGER SINCE THE VEHICLE COMPLETELY SHUT DOWN AND LOCKED UP.

TL* THE CONTACT OWNS A 2012 BMW 528I. WHILE DRIVING AT A LOW RATE OF SPEED, THE DRIVE TRAIN MALFUNCTION WARNING INDICATOR ILLUMINATED. THE CONTACT PULLED OVER TO THE SIDE OF THE HIGHWAY AND SHUT OFF THE VEHICLE. THE VEHICLE WOULD NOT RESTART. THE CONTACT HAD THE VEHICLE TOWED TO AN UNKNOWN BMW DEALER WHERE IT WAS DIAGNOSED THAT THE ENGINE FAILED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN.

TL* THE CONTACT OWNS A 2012 BMW 528I. THE CONTACT NOTICED THAT THE VEHICLE WAS INCLUDED IN SEVERAL TECHNICAL SERVICE BULLETINS. HE WAS CONCERNED THAT BMW HAD SEVERAL LAWSUITS REGARDING THE TIMING BELT. THE MANUFACTURER EXTENDED THE WARRANTIES FROM 50,000 TO 70,000 MILES RELATED TO THE TIMING CHAINS, SPROCKETS, OIL PUMPS, TENSIONERS, AND GUIDES. THE CONTACT WAS CONCERNED THAT THE MANUFACTURER WAS NOT FULLY RESOLVING THE ISSUE. THE VEHICLE WAS CURRENTLY AT BMW OF FAIRFAX (8427 LEE HWY, FAIRFAX, VA 22031, (800) 641-4873) FOR THE TIMING CHAIN. THE CONTACT STATED THAT THE TIMING CHAIN WAS BEGINNING TO RUB AGAINST OTHER PARTS OF THE ENGINE. THE CONTACT WAS CONCERNED THAT THE REPAIR WOULD COST $12,000 TO $16,000 TO REPLACE THE ENTIRE ENGINE IF THE TIMING CHAIN FAILED. THE MANUFACTURER STATED THAT THE CONTACT'S VEHICLE DID NOT QUALIFY FOR THE EXTENDED WARRANTY SINCE IT WAS ALREADY OVER 70,000 MILES. THE FAILURE MILEAGE WAS 83,000.

TL* THE CONTACT OWNS A 2012 BMW 528I. THE CONTACT STATED THAT THE FUEL SUPPLY WARNING INDICATOR ILLUMINATED WHILE DRIVING VARIOUS SPEEDS. AFTER THE WARNING, THE VEHICLE STALLED AND THEN ABRUPTLY STOPPED. THE VEHICLE WAS ABLE TO BE RESTARTED. THE CONTACT TOOK THE VEHICLE TO BMW OF TULSA (9702 S MEMORIAL DR, TULSA, OK 74133, (918) 663-4444) WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 124,038.

DEFECTIVE DRIVE TRAIN - ON MARCH 11, 2019 MY DRIVE TRAIN MALFUNCTION AND WHICH DAMAGE MY ENGINE. THIS IS AN SAFETY CONCERN BECAUSE MY CAR STOP ON THE FREEWAY WHILE I WAS DRIVING. BMW MFG KNEW ABOUT THE DEFECTIVE DRIVE TRAIN PRIOR TO ME PURCHASING CAR FROM FIELDS BMW ON JULY 2013. BMW NORTH AMERICA OFFER TO PAY 21,000 FOR THE ENGINE REPLACEMENT AND THEY WANT ME TO PAY 6,000.00 AND I FEEL BMW KNOW ABOUT THE FAULTY DESIGN IN 2012 AND DID NOT INFORM THE CONSUMER. WHEN I PURCHASE THE CAR, IT HAD 18,000 MILES ON IT AND I PUT 62,000.00

TL* THE CONTACT OWNS A 2012 BMW 528I. WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE SUDDENLY SHUT OFF AND "DRIVE TRAIN MALFUNCTION" DISPLAYED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TOWED TO THE LOCAL DEALER (BMW OF DALLAS, 6200 LEMMON AVE, DALLAS, TX) WHERE IT WAS DIAGNOSED THAT THE ENGINE WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 80,000. THE VIN WAS UNKNOWN.

THE FRONT PASSENGER OCCUPANCY SEAT SENSOR IS DEFECTIVE/NOT WORKING EVEN THOUGH THE CAR HAS ONLY 25,000 MILES. THIS IS A SAFETY ISSUE AND THERE ARE SO MANY OWNERS HAS SIMILAR ISSUE WITH THIS DESIGN