2002 BMW 530I Complaints

TL* THE CONTACT OWNS A 2002 BMW 530IA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V318000 (AIR BAGS) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL* THE CONTACT OWNS A 2002 BMW 530I. THE CONTACT STATED THAT WHILE DRIVING 15 MPH, THE HEATED SEAT WARMER WAS ACTIVATED TO A LOW SETTING WHEN THE SEAT BECAME EXTREMELY HOT. THERE WAS SMOKE AND AN ABNORMAL ODOR PRESENT. AS A RESULT, A HOLE BURNED THROUGH THE FRONT DRIVER'S SIDE SEAT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 76,000. THE VIN WAS UNAVAILABLE.

ON MAY 28TH 2012 ON THE HIGHWAY, THE BMW THREW A SERVICE ENGINE SOON LIGHT. USING A SCANNER, A CODE P0741 WAS THROWN. WHEN I SEARCHED ON GOOGLE, I FOUND IT WAS VERY COMMON FOR THE E39 BMW 530IA CARS HOUSING ZF MANUFACTURED TRANSMISSIONS TO HAVE THE TORQUE CONVERTER TURBINE SHAFT SEAL DETERIORATED CAUSING THE FAULT. IT IS UNREASONABLE TO HAVE BMW TO REPLACE THE TRANSMISSION AT A COST OF OVER $4000 FOR A SEAL THAT IS NO MORE THAN $25.00. THEREFORE IT SHOULD BE A GOODWILL REPLACEMENT DUE TO THE MANUFACTURE OF A FAULTY TRANSMISSION WITH A KNOWN PART FAILURE IN THE FIRST PLACE. *TR

THE FRONT SEAT GET TWISTED HERE IS A VIDEO: HTTP://WWW.YOUTUBE.COM/WATCH?V=WM3HKVKGLXM. *TR

AT 78,600 MILES THE CHECK LIGHT ILLUMINATED. DIAGNOSIS WAS P0741 (BMW CODE 48) WHICH IS A FAULT WITH THE TORQUE CONVERTER CLUTCH (TCC). THIS FAILURE UNTIL CORRECTED RESULTS IN LOWER FUEL MILEAGE, AND A GUARANTEED FAILURE TO PASS THE EMISSIONS TEST DURING STATE MANDATED VEHICLE INSPECTIONS. ADD TO THIS THAT CONTINUED USE OF THE VEHICLE WILL LIKELY RESULT IN TRANSMISSION DAMAGE SINCE THE TCC LOCKUP CLUTCH IS SLIPPING RESULTING IN DEBRIS BUILDING UP IN THE FLUID. THIS FAULT IS DUE TO A DEFECTIVE TORQUE CONVERTER CLUTCH SEAL THAT BMW HAS A HIDDEN SERVICE BULLETIN ON. SEE SI 24 03 06 DATED FEBRUARY 2008. REPLACEMENT OF THE TORQUE CONVERTER IS EXPENSIVE. BMW DEALER QUOTED A BIT MORE THAN $3000 FOR THE REPLACEMENT. I'VE SINCE DETERMINED THROUGH A BMW FORUM THAT THIS ISSUE IS WIDESPREAD WITH A LARGE NUMBER OF FAILURES TAKING PLACE. I WAS TOLD BY THE DEALER THAT THE SEAL IN QUESTION HAS NOT BEEN UPDATED AND THAT FAILURE OF THE SEAL WILL LIKELY TAKE PLACE AGAIN IN THE FUTURE. *TR *KB

I STARTED THE VEHICLE AND THE FAN EXPLODED. THE PLASTIC BLADES PIERCED THE HOOD AND IN ADDITION TO THE FAN AND FAN CLUTCH BEING GONE, THE FAN SHROUD IS GONE, AND IT CUT THE POWER STEERING, OIL FILTER, AND UPPER RADIATOR HOSES. *TR

I RECENTLY PURCHASED A 2002 BMW 530I ON AUGUST 24, 2011 AND ABOUT THREE WEEKS IN TO OWNING THE VEHICLE THE CHECK ENGINE LIGHT CAME ON. IT SEEMS THE CODE READS P0741 I.E. TORQUE CONVERTER SOLENOID CIRCUIT STUCK OFF. THE VEHICLE ONLY HAS 107K ON IT HOWEVER, DOESN'T SEEM TO HAVE ANY MISFIRE OR TRANSMISSION ISSUES WHILE DRIVING. I TOOK THE VEHICLE TO BMW FOR AN INSPECTION/CHECKUP TO BE SURE THERE WERE NO MAJOR ISSUES AND THEY GAVE IT A THUMBS UP HOWEVER, THIS WAS BEFORE THE CODE/CHECK ENGINE LIGHT WAS ENGAGED ON THE DASHED BOARD OF THE VEHICLE. BASED ON THE SERVICE BULLETIN FOR BMW IT APPEARS THIS SHOULD BE COVERED SINCE IT'S A COMMON OCCURRENCE. I NEED TO FIND OUT HOW TO GET THIS PROBLEM RECTIFIED. *TR

TL* THE CONTACT OWNS A 2002 BMW 530I. THE CONTACT STATED THAT WHENEVER THE VEHICLE WAS EXPOSED TO RAINY CONDITIONS, WATER WOULD ENTER AND FLOOD THE VEHICLE THROUGH THE DOORS. THE WATER WAS ABLE TO ENTER THE VEHICLE THROUGH THE DOOR PANELS DUE TO THE MATERIALS THAT THE PANELS WERE MANUFACTURED FROM, AS WELL AS IMPROPER SEALING. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 40,000.

HEATED DRIVER SEAT WILL BURN LEG OR BACK. HEATER HAS BURNED HOLE THROUGH LEATHER. PLAZA MOTORS / ST. LOUIS MO INFORMED ME THAT BMW WILL NOT FIX. HEATER IS A FIRE HAZARD AND SHOULD BE RECALLED. *TR

TL*THE CONTACT OWNS A 2002 BMW 530I. WHILE DRIVING APPROXIMATELY 30 MPH, A CLOUD OF SMOKE WAS EMITTED FROM THE HOOD AND THE VEHICLE STALLED. THE VEHICLE WOULD NOT RESTART SO IT WAS TOWED TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS TOLD OIL SEPARATOR FAILED, RESULTING IN A COMPLETE LOSS OF OIL. THE VEHICLE WAS REPAIRED. THE FAILURE OCCURRED THREE TIMES. AFTER EACH FAILURE, THE VEHICLE WAS TAKEN BACK TO AN AUTHORIZED DEALER TO BE REPAIRED. THE FAILURE MILEAGE WAS 40,000 AND THE CURRENT MILEAGE WAS 120,000.