2010 BMW 535I Complaints

ENGINE VALVE COVERS CRACKED, LEADING TO ACCUMULATED OIL LEAK IN THE ENGINE COMPARTMENT. POSSIBLE FIRE HAZARD.

HORN, AIR BAG AND ALL STEERING WHEEL ELECTRONICS PERMANENTLY SEASED WORKING AFTER A SNAP NOISE FROMTHE STEERING COLUMN HAPPEN, DRIVER SYSTEM RESTRAIN ERROR LIGHT CAME ON. WHILE GOING IN REVERSE TO GET OUT OF PARKING SPOT THE STEERING WAS TURNED FAR LEFT TO GET INTO THE STREET. WHILE TURNING THE STEERING A NOISE THAT RESEMBLES PLASTICS BREAKING CAME FROM THE STEERING COLUMN COMPARTMENT AND CLICKING SOUND THAT STILL OCCURS TODAY WHEN TURNING THE STEERING WHEEL IS NOTICEABLE AND CONCERNING IF STEERING IS RELIABLE AND SAFE. WHEN THE ORIGINAL CRACKING NOISE OCCURRED THE COMPUTER WENT OFF WITH A DRIVER RESTRAINT SYSTEM FAILURE ERROR. SINCE THEN ALL COMPONENTS SUCH BUTTONS, HORN, CRUISE CONTROL, VOLUME, PHONE, AIR BAG ETC STOPPED WORKING. THE MOST CONCERNING COMPONENT THAT STOPPED WORKING IS THE HORN AND AIRBAG THAT OBVIOUSLY PRESENTS A SAFETY HAZARD AND A COMPONENT THAT IS NEEDED FOR SAFETY INSPECTION CHECKS. THE VEHICLE ONLY HAS BEEN DRIVEN FOR ABOUT 44000 MILES TOTAL AND THE COMPONENTS FAILURE CANNOT BE BLAMED TO DRIVER IMPROPER USE OF THE CAR THAT CAN BE FILED WITH INSURANCE. THE STEERING COLUMN ELECTRONIC COMPONENTS INVOLVING AIR BAGS, HORN AND OTHERS SHOULD BE RELIABLE AND STAY WORKING FOR MUCH LONGER THAN 44K MILES AND SHOULD BE A RECALL AT THE DEALERS EXPENSE. A BMW MASTER MECHANIC MENTIONED THAT THESE A REPLACEABLE COMPONENTS THAT GO INSIDE THAT STEERING COLUMN COMPARTMENT THAT ARE KNOWN FOR BREAKING AND THAT BMW HAS COME OUT WITH SEVERAL "IMPROVED VERSIONS" OF THE COMPONENT SINCE THE CAR FIRST WAS RELEASED IN 2010.

TAKATA INFLATORS- SHOWS ON MY SCREEN THAT THERE IS A PROBLEM WITH MY RESTRAINT SAFETY SYSTEM.

MANY TIMES DRIVER'S SIDE DOOR DOES NOT UNLOCK WHEN THE LEVER WAS PULLED TWICE. IT ONLY UNLOCKS WHEN THE ELECTRIC UNLOCK BUTTON IS PUSHED. IT COULD BE VERY DANGEROUS DURING AN ACCIDENT IF POWER IS LOST AND I COULD NOT UNLOCK THE DOOR. THIS PROBLEM HAS STARTED ON THE PASSENGER SIDE DOOR TOO.

SAFETY NOTE WARNING COMES ON DASHBOARD, EVERY TIME CAR IS STARTED AND STAYS ON, STATING THE AIR BAG ON HEAD RESTRAINT MAY EXPLODE AND RELEASE METAL FRAGMENTS THAT WOULD CAUSE INJURY.

16V-746 RECALL CAMPAIGN NO. BMW DOESN'T WANT TO REPLACE FUEL TANK PUMP, JUST EXTEND THE WARRANTY.

ENGINE OIL LEAKING FROM COMMON VALVE COVER LEAK. CAUSES SUDDEN POWER LOSS WHILE DRIVING.

TL* THE CONTACT OWNS A 2010 BMW 535I. WHILE DRIVING AT AN UNKNOWN SPEED, THE FRONT PASSENGER SEAT BELT AND AIR BAG SENSOR LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ELECTRICAL CABLE LOOSENED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE VEHICLE WAS REPAIRED ON TWO SEPARATE OCCASIONS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 67,000.

YELLOW ENGINE LIGHT CAME ON, WAS TESTED AND NOTHING WAS FOUND. IT STARTED USING MORE GAS THAN USUAL AND LONG-CRANKS STARTING THE ENGINE AND SHAKING AFTER THE ENGINE STARTED. THE DIAGNOSIS WAS ALL 6 FUEL INJECTORS NEEDED REPLACEMENT AS THEY WERE LEAKING GASOLINE, THEY ALL FAILED AT 73,000 MILES.

THE PASSENGER MIRROR WILL MOVE OUT OF POSITION ON ITS OWN WITHOUT TOUCHING ANY CONTROLS. THIS WILL ALSO OCCUR WHEN THE CAR IS TURNED OFF. AFTER REVIEWING VARIOUS INTERNET POSTINGS OTHER BMW OWNERS HAVE EXPERIENCED THE SAME PROBLEM. THIS IS A SERIOUS SAFETY ISSUE AS IT CAN ADVERSELY IMPACT THE DRIVER'S REAR VISION. *TR