2010 BMW 535I Complaints

I was told by BMW that the high pressure fuel pump for these vehicles are under warranty for 100,000 miles or 10 years. I just purchased the vehicle to not only drive from new jersey to New York and shut down. Since then it caused an accident and the used dealer is just ignoring everything. I was also told there’s an electric water pump class action suit and also something with the trunk leaking. Now I do know that a vehicle is not supposed to be sold without recalls being stated and fixed. I’m already paid 10k for the car and then 1k for a starter . The vehicle is in the body shop having body repair due to the engine shutting down. If the engine shuts down it displays fuel pump malfunction and within 20-30 mins will start again. The BMW 535i has 96,000 miles on it and I don’t think it’s fair that I should be penalized for someone not following thru with repairs let alone having an accident on my insurance now. I’m asking please just help get the vehicle running again and all future service will absolutely be done through BMW. That’s how I handled my Mercedes’ and plan so with this vehicle. I’m a single father that just took a severe beating financially and had to sell the Mercedes’ and thought buying a BMW was a good choice being I had a similar issue with Mercedes’ and they honored the repair due to the amount of time owned and still being in the mileage range of the defective part. Please help . Email-[XXX] Cell- [XXX] [XXX] Thank you in advance INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

TL* THE CONTACT OWNS A 2010 BMW 535I. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 20-25 MPH, THE VEHICLE LOSS MOTIVE POWER. THE CONTACT COASTED AND MANUALLY STEERED THE VEHICLE TO THE SIDE OF THE ROADWAY. THE CONTACT STATED THAT THE FUEL PUMP WARNING LIGHT WAS ILLUMINATED. THE CONTACT HAD THE VEHICLE TOWED TO RALLYE BMW (1 BRUSH HOLLOW RD, WESTBURY, NY 11590, (516) 226-7947) WHO HAD REPLACED AN UNKNOWN PART HOWEVER, APPROXIMATELY A WEEK LATER THE FAILURE RECURRED WITH THE SAME WARNING LIGHT ILLUMINATED. THE CONTACT RETURNED THE VEHICLE TO THE SAME DEALER AND THE FUEL PUMP WAS REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

SEVERAL TIMES I WAS PLACED IN PERIL WHILE TRAVELING AT HIGH RATES OF SPEED THEN THE CAR STALLS ON US HIGHWAY 95. THERE WERE ALSO TIMES WHEN THE CAR STALLED WHILE DRIVING LESS THAN 35MPH. WHEN THIS HAPPENS I HAVE NO REAL CONTROL TO STEER THE WHEEL, NO PRIOR WARNING OR ISSUES WITH THE CAR TO INDICATE IT WOULD STALL. IT IS EXTREMELY TRAUMATIZING. TRAUMATIZING! MESSAGE OF "FUEL PUMP MALFUNCTION. MODERATE DRIVING POSSIBLE". CAR STALLS WHILE IN MOTION WHETHER IT IS 20MPH OR 65MPH. INITIAL MALFUNCTION IN JULY WAS AFTER 1HR OF DRIVING THEN SEVERAL TIMES AFTER THAT PERIODICALLY AS THE CAR ISN'T DRIVEN OFTEN DUE TO STAY AT HOME RESTRICTIONS. THE ISSUE COULD NOT BE DUPLICATED AT TWO AUTO MECHANIC SHOPS, IN FACT BY THE TIME THE TOW TRUCK ARRIVED, THE CAR STARTED AND WAS ABLE TO BE DRIVEN ONTO THE TRUCK. THERE IS NO PATTERN OF DRIVING BEHAVIOR OR MESSAGES BETWEEN FAILURE / STALL AND AS MONTHS WENT ON, THE TIME BETWEEN STALL AND INABILITY TO START THE CAR SHORTENED FROM DRIVING1HR TO DRIVING 10 MINUTES. BMW OF THE MAIN LINE REPLACED THE FUEL PUMP, FUEL FILTER AND STALL AND ERROR ISSUE REMAINS. WIRING TO FUEL PUMP ISSUE POSSIBLE. THERE ARE SEVERAL OPEN COMPLAINTS ON THE EXACT SAME ISSUE. MODEL YEAR 2010 SHOULD BE INCLUDED IN THE RECALL FOR 535I XDRIVE HTTPS://WWW.NHTSA.GOV/VEHICLE/2010/BMW/5%252520 SERIES/4%252520DR/RWD%25252F4WD#COMPLAINTS HTTPS://WWW.NHTSA.GOV/VEHICLE/2010/BMW/5%252520SERIES/4%252520DR/RWD%25252F4WD#COMPLAINTS WIRING ISSUE DETECTED AND MAY BE PART OF THE RECALL NHTSA RECALL NO. : 16V-746. IF THE FUEL PUMP BECOMES INOPERATIVE, A NO-START CONDITION OR, IN RARE CASES, A STALLING CONDITION WITHOUT THE ABILITY TO RESTART THE VEHICLE COULD OCCUR. STARTED JULY AND DEGRADED SEPTEMBER, OCTOBER, NOVEMBER THEN FINALLY DECEMBER. $$$$ IN REPAIR COSTS THAT DID NOT RESOLVE THE "FUEL PUMP MALFUNCTION. MODERATE DRIVING POSSIBLE" MESSAGE. HELP

RECEIVING P0087 LOW PRESSURE FUEL, CAR GOES INTO DRIVETRAIN MALFUNCTION. FIX IS REPLACING HIGH PRESSURE FUEL PUMP.

WHEN STARING UP, EXTENDED CRANK/SLOW STARTUP . CONTACTED BMW 'FUEL PUMP ISSUE'. NOT COVERED ON CURRENT RECALLS BECAUSE OF YEAR OF CAR. ALL OTHER 5 SERIES HAVE AN OPEN RECALL FOR THE SAME PROBLEM

TL* THE CONTACT OWNS A 2010 BMW 535I. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE BATTERY DISCHARGING MESSAGE DISPLAYED ON THE INSTRUMENT PANEL. THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE DRIVE BELTS, BATTERY, INTELLIGENT BATTERY SENSOR (IBS) SYSTEM, BOLTS, HOSE AND ENGINE COOLING SYSTEM NEEDED TO BE REPLACED. THE CONTACT REFERENCED THE FAILURE TO NHTSA CAMPAIGN NUMBER: 14V176000 (ENGINE AND ENGINE COOLING) HOWEVER, THE VIN WAS NOT INCLUDED. AN UNKNOWN DEALER WAS CONTACTED AND INFORMED OF THE FAILURE BUT PROVIDED NO ADDITIONAL ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS INFORMED OF FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000.*DT

I HAD THE CAR SERVICED BY A MECHANIC BECAUSE I HAD CHECK ENGINE LIGHT FAULTS. WATER PUMP AND THERMOSTAT WAS REPLACED. SPARK PLUGS AND COPS WERE REPLACED. SOME OF THE FUEL INJECTORS WERE ALSO REPLACED. MECHANIC ASKED ME TO DRIVE THE CAR FOR 100 MILES TO SEE IF ANY CHECK ENGINE ISSUES WILL REAPPEAR. THE VEHICLE FIRST BEGAN STATING IT HAD LOW OIL PRESSURE AND WOULD NOT ALLOW ME TO CHECK THE OIL LEVEL, IT WOULD CONTINUE TO JUST STOP AT 15%. I THEN RESTARTED THE VEHICLE AND THE INDICATOR WENT AWAY FOR THE LOW OIL PRESSURE. I DROVE ABOUT 10 MORE MILES AND DRIVE TRAIN MALFUNCTION APPEARED AND I PULLED OVER IMMEDIATELY. THE VEHICLE WAS TOWED TO THE MECHANIC. ENGINE WAS SEIZED. WHAT WAS FOUND IN THE ENGINE WAS "SHARDS OF METAL". MANY PEOPLE HAD THE SAME ISSUE WITH THE 5 SERIES BMW ENGINES. I THINK THAT BMW IS RESPONSIBLE FOR THESE ENGINE FAILURES. *TR

WAS DRIVING DOWN THE ROAD AND WAS PASSING A VEHICLE AND AS I WAS GETTING PAST OTHER DRIVER MY ONBOARD DASH POPPED UP SAYING CAR NEEDED TO GET SERVICED. DESCRIPTION OF FAULT WAS FUEL PUMP. ALL POWER WAS LOST AND WAS BARELY ABLE TO GET PAST OTHER MOTORIST TO GET TO THE SHOULDER. ONCE I SAT FOR ABOUT 20 MIN WAS ABLE TO RESTART VEHICLE AND GET TO MY DESTINATION 8 MILES DOWN THE ROAD. THIS MADE ME FEEL VERY U SAFE AND COULD HAVE CAUSED AN ACCIDENT WITH THE OTHER MOTORIST. I WAS ON A 2 LANES STATE ROAD WHEN THIS HAPPENED. THERE WAS ALSO ANOTHER VEHICLE BEHIND THE MOTORIST I WAS PASSING TO OVER TAKE. *TR

MY BMW 2010 5 SERIES GT ( CAMPAIGN 10V446000 ) HAS HAD ISSUES PERTAINING TOO A CHECK VALVE OF THE BREAK VACUUM PUMP THAT LEAKS A SMALL AMOUNT OF LUBRICATING OIL. OVER TIME THIS HAS CONTAMINATED MY BRAKE BOOSTER, AND ALSO THERE HAS BEEN ISSUES WITH THE POWER ASSIT BRAKING PERFORMANCE THAT HAS LED TOO LOSS OF POWER ASSIST BRAKING WHICH I'VE DONE RESEARCH AND THAT COULD POTENTIALLY INCREASE A RISK OF AN ACCIDENT. MY FUEL GUAGE HAS ALSO DISPLAYED A LARGER AMOUNT OF FUEL THAN WAS ACTUALLY IN THE TANK, WHICH COULD ALSO INCREASE MY VEHICLE TOO STALL AND INCREASE A CHANCE OF ME BEING IN A ACCIDENT.

WHEN ATTEMPTING TO BRING VEHICLE UP TO SPEED ON THE ON-RAMP OF THE HIGHWAY, THE "FUEL PUMP WARNING" WILL DISPLAY ON SCREEN. THIS IS THEN FOLLOWED BY A LOSS OF POWER IN THE ENGINE UNTIL THE ENGINE STOPS AND THE VEHICLE NO LONGER RUNS. VEHICLE HAS BEEN TOWED AND DIAGNOSED AS THE HIGH PRESSURE FUEL PUMP BE TECHNICIAN. TECHNICIAN ADVISED ME THAT BMW HAS RECALLED "CERTAIN" MODELS FOR THIS PROBLEM.