2009 BMW M3 Complaints

TAKATA RECALL HELLO MADAM/ SIR, I RECEIVED A SAFETY RECALL NOTICE - 16V-071 REGARDING FAULTY DRIVERS SIDE AIRBAGS IN MY 2009 BMW M3. THE NOTICE (ATTACHED) CLEARLY STATES THAT IN AN EVENT OF AIRBAG GETTING DEPLOYED, THE AIRBAG MIGHT EXPLODE CAUSING SERIOUS INJURY OR DEATH.BMW SAYS THAT THEY DON'T HAVE ANY INFORMATION OF WHEN NEW PARTS WILL BE AVAILABLE. TO AVOID ANY POTENTIAL ISSUE OF SOMETHING HAPPENING, I HAVE BEEN RENTING A CAR FOR A WHILE. I HAVE ALSO CONTACTED BMW AND HAVE BEEN UNSUCCESSFUL SO FAR TO RECEIVE ANY HELP. BMW TOLD ME THAT BMW DEALERSHIP OF ANN ARBOR WILL CONTACT ME FOR ALTERNATE TRANSPORTATION AND THEN BMW OF ANN ARBOR TOLD ME THAT THEY ARE NOT SUPPORTING THIS RECALL. I HAVE JUST BEEN GOING BACK AND FORTH WITH BMW AND THE DEALERSHIP WITHOUT ANY ASSISTANCE. HOW AM I SUPPOSED TO DRIVE A VEHICLE WHEN THE RECALL CLEARLY STATES THAT EXPLOSION OF AIRBAG MIGHT EVEN CAUSE DEATH? I CAN'T JUST AFFORD TO CONTINUE RENTING A CAR. ANY HELP FROM NHTSA WOULD BE GREATLY APPRECIATED. I AM HAPPY TO PROVIDE MORE INFORMATION. KIND REGARDS, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

ERROR MESSAGE: FAULT IN - PASSENGER RESTRAIN SYSTEM AFFECTING AIRBAG, BELT TENSIONER, OR BELT FORCE LIMITER. THIS IS CAUSED BY FAULT SEAT MAT SENSOR IN THE PASSENGER SEAT, WHICH MAY CAUSE THE AIRBAG NOT TO FUNCTION PROPERLY.

S65 V8 ENGINE IN A BMW M3 E90/92/93 AND M5'S WITH A V10 HAS TWO THROTTLE VALVE ACTUATORS THAT FAIL PREMATURELY AT 40-80K MILES. BOTH THE INTERNAL NYLON GEARS AND ELECTRONICS WILL FAIL, AFFECTING ACCELERATOR PEDAL RESPONSE AND CAUSING HESITATION, ESPECIALLY WITH THE DCT TRANSMISSION. THESE PARTS ARE NOT A MAINTENANCE ITEM. WHEN FAILED, THE ENGINE MALFUNCTION, EXCESS EMISSIONS, SKID CONTROL, AND ABS BRAKING WARNING LIGHTS ARE TRIGGERED. ENGINE GOES INTO LIMP MODE. THIS IS DANGEROUS WHEN IT HAPPENS WHILE DRIVING IN RAINY, SNOWY, AND ICY ROAD CONDITIONS. THE THROTTLE VALVE ACTUATOR DESIGN DEFECT SHOULD HAVE TRIGGERED A BMW RECALL. REPLACEMENT PARTS ARE $1000-1300 EACH PLUS $1000 LABOR AND HAVE NEVER BEEN REDESIGNED BY BMW/BOSCH. SO THE REPLACEMENT PARTS ARE ALSO DEFECTIVE AND WILL FAIL PREMATURELY. REPAIRS OCCURRED ON DEC. 2012 AT 80K MILES FOR $2000 AND ON JAN. 2016 AT 140K MILES FOR $3000. A BMW M3 AND M5 RECALL AND REDESIGNED PARTS ARE WARRANTED. BMW TECHNICAL SERVICE BULLETINS SHOULD BE ISSUED FOR THIS DESIGN FLAW. 8YR/80KM FEDERAL EMISSIONS WARRANTY SHOULD COVER THESE REPAIRS AS WELL.

VEHICLE LOST POWER WHILE TAKING A TURN. I WAS ABLE TO RESTART IT AND DRIVE TO A NEARBY PARKING LOT. I DROVE AROUND SLOWLY TO TEST AND NOTICED KNOCKING NOISE FROM THE ENGINE. I ALSO NOTICED ENGINE TEMPERATURE WAS ABOVE NORMAL, NOT QUITE TO THE NEXT MARKER, BUT CLOSE. AT THAT POINT, I HAD THE CAR TOWED TO A BMW SERVICE SHOP. THEIR DIAGNOSIS WAS ROD BEARING FAILURE WHICH LED TO CRANKSHAFT DAMAGE, RESULTING IN AN ENGINE, WITH ONLY 57K MI, THAT IS NO LONGER REUSABLE. I AM NOW FACING ENGINE REPLACEMENT COSTS OF $15-25K.

WHILE TRYING TO EXIT MY E92 2009 M3 FROM INSIDE THE VEHICLE BY DOUBLE PULLING THE HANDLE IT WOULD NOT UNLOCK THE CAR. THE LOCKING BOLT STICKS UP PARTIALLY WHEN YOU PULL THE HANDLE BUT DOESN'T UNLOCK. I HAD TO HIT THE LOCK BUTTON FROM THE DASHBOARD TO UNLOCK THE CAR. THIS IS A SAFETY CONCERN IF YOU ARE PANICKED AND CAN'T GET OUT OF THE VEHICLE UNDER HEAVY STRESS. *TR

400 MILES OUT OF WARRANTY, THE ELECTRICAL SYSTEM FAULT WARNING BEGAN TO COME ON. WHEN THIS HAPPENS ALL GAUGES BOTTOM OUT QUICKLY THEN RETURN TO NORMAL. SOMETIMES, THE RESTRAINT SYSTEM, EDC OR OTHER WARNINGS WILL START. I DON'T EXPERIENCE ANY PROBLEMS DRIVING THE VEHICLE. THE BATTERY HAS BEEN REPLACED AND ALTERNATOR HAS BEEN TESTED AND IS PERFORMING AS IT SHOULD. WHEN CONNECTED TO THE BMW COMPUTER FOR ERROR CODES IT DOESN'T SHOW ANY CODES OR THAT THE WARNINGS HAVE GONE OFF. I HAVE DRIVEN IT FOR 18000 MILES TRYING TO FIND JUST ONE COMMON THING THAT WILL MAKE THIS HAPPEN. I HAVE FOUND NOTHING TO CAUSE THIS WARNING. IT MAY GO OFF CONSTANTLY ONE DAY AND NOT HAPPEN AGAIN FOR 2 WEEKS. SOMETIMES, AFTER GOING OFF FOR SEVERAL TIMES, THE GAUGES FOR RPM, TEMP WILL DROP TO THEIR LOWEST INDICATIONS AND THE SPEEDOMETER WILL STICK AT WHATEVER THE SPEED IS AT THE TIME. I HAVE EMAILED BMW OF NA AND THEY INFORMED ME THAT THE RECENT RECALL FOR THIS PROBLEM DOES NOT INCLUDE THE M SERIES. I WAS TOLD THAT IT COULD COST UP TOWARDS $5000 TO FIND A LOOSE WIRE. DIDN'T THINK I SHOULD HAVE TO PAY THAT MUCH SINCE IT WAS JUST 400 MILES OUT OF WARRANTY. I DON'T THINK THAT IT IS A LOOSE WIRE BECAUSE I WOULD HAVE NOTICED THAT AS A COMMON FACTOR, LIKE HITTING A BUMP IN THE ROAD. AFTER READING MANY BMW FORUMS, THIS SEEMS TO BE A PROBLEM ASSOCIATED WITH THE M3 AS WELL AS THE OTHER SERIES. *TR

SHORTLY AFTER PURCHASING MY BMW 2009 M3, I NOTICED A RARE BUT VERY DISTURBING PATTERN ON TAKE OFF. I HAD CAR CHECKED IN DEALER AND I WAS TOLD IT WAS LIKELY SECONDARY TO MY DRIVING STYLE! THIS UNCONTROLLED TAKE OFF IS LIKE HI REV AND RAPID ACCELERATION PERIODICALLY ALTERNATING WITH DECELERATION FOR FEW SECONDS. I HAD THIS HAPPEN PROB A DOZEN TIME SO FAR(36K ON CAR). ON DAY OF MY ACCIDENT, IN STOP AND GO TRAFFIC WITH SPEED LESS THAN 5 MILES PER HOUR, CAR LITERALLY WENT OFF ON ME. IT ACCELERATED TO HIT THE CAR IN FRONT AND THEN MANAGED TO PUSH THE CAR INTO ANOTHER 3 CARS IN FRONT, BEFORE IT CAME TO A STALL. I AM NOT SURE IF IT WAS EXACTLY LIKE MY PREVIOUS EPISODES BECAUSE THE DISTANCE BETWEEN MY CAR AND NEXT CAR WAS SHORT. WHAT I AM SURE IS THAT I HAD NO CONTROL ON CAR. *TR

TO WHOM IT MAY CONCERN, I AM VERY HAPPY TO SEE YOUR ORGANIZATION TAKING AN INTEREST IN THIS ISSUE. IT IS A VERY DANGEROUS PROBLEM WITH THIS VEHICLE THAT BMWNA IS WELL AWARE OF, BUT INSISTS THAT IT IS "NORMAL BEHAVIOR" FOR MY CAR/TRANSMISSION. I BROUGHT THE CAR INTO THE DEALER, AND THEY WERE ABLE TO REPRODUCE IT, BUT THEY WERE TOLD BY BMW THAT THIS WAS "NORMAL BEHAVIOR." THE PROBLEM OCCURS WHEN YOU SLOW DOWN- LIKE FOR A TURN, BUT DO NOT COME TO A COMPLETE STOP. THE DCT TRANSMISSION SEEMS TO HAVE TROUBLE FIGURING OUT WHAT GEAR TO SELECT BECAUSE WHEN YOU STEP ON THE GAS TO ACCELERATE, THERE IS A VERY SIGNIFICANT DELAY IN THE ONSET OF POWER- UP TO 2-3 SECONDS. BY THIS TIME, THE DRIVER IS USUALLY REALLY DIGGING INTO THE THROTTLE. THE TRANSMISSION FINALLY PICKS A GEAR, WHICH RESULTS IN THE CAR SUDDENLY LURCHING FORWARD, SOMETIMES INVOKING THE ANTI-SKIP CONTROL. THE DANGER IN THIS BEHAVIOR OCCURS WHEN MAKING A TURN INTO ON-COMING TRAFFIC AFTER SLOWING DOWN TO AROUND 10-15 MPH. AFTER THE TURN, THE CAR IS POSITIONED IN THE TRAFFIC LANE, BUT YOU HAVE NO POWER TO ACCELERATE INTO THE FLOW OF TRAFFIC. THE ONCOMING CARS ARE NOW CLOSING IN ON YOUR CAR AT A FAST RATE, AND YOU'RE BASICALLY STUCK. THIS SITUATION IS MOST PRONOUNCED IN THE "AUTO" MODE OF THE DCT TRANSMISSION, BUT ALSO OCCURS TO A LESSER DEGREE WHILE IN THE MANUAL MODE WHEN YOU SELECT SECOND GEAR IN PREPARATION FOR THE TURN. IT IS ALSO VERY REPEATABLE IN BOTH MODES. THESE PROBLEMS STARTED OCCURRING AFTER A PREVIOUS RECALL ON THIS TRANSMISSION WHERE THE ENGINE WOULD STALL UNDER HARD BRAKING OR NOT SHIFT UNDER HARD BRAKING. THE RECALL FIXED THAT PROBLEM, BUT INTRODUCED THIS PROBLEM, WHICH OCCURS ALMOST EVERY DAY WHEREAS THE PREVIOUS PROBLEM ONLY OCCURRED DURING A SPECIFIC SITUATION. THANK YOU FOR LOOKING INTO THIS DANGEROUS MATTER. *TR

INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) DEAR [XXX], I AM VERY HAPPY TO SEE YOUR ORANIZATION TAKING AN INTEREST IN THIS ISSUE. IT IS A VERY DANGEROUS PROBLEM WITH THIS VEHICLE THAT BMWNA IS WELL AWARE OF, BUT INSISTS THAT IT IS "NORMAL BEHAVIOR" FOR MY CAR/TRANSMISSION. I BROUGHT THE CAR INTO THE DEALER, AND THEY WERE ABLE TO REPRODUCE IT, BUT THEY WERE TOLD BY BMW THAT THIS WAS "NORMAL BEHAVIOR." THE PROBLEM OCCURS WHEN YOU SLOW DOWN- LIKE FOR A TURN, BUT DO NOT COME TO A COMPLETE STOP. THE DCT TRANSMISSION SEEMS TO HAVE TROUBLE FIGURING OUT WHAT GEAR TO SELECT BECAUSE WHEN YOU STEP ON THE GAS TO ACCELERATE, THERE IS A VERY SIGNIFICANT DELAY IN THE ONSET OF POWER- UP TO 2-3 SECONDS. BY THIS TIME, THE DRIVER IS USUALLY REALLY DIGGING INTO THE THROTTLE. THE TRANSMISSION FINALLY PICKS A GEAR, WHICH RESULTS IN THE CAR SUDDENLY LURCHING FORWARD, SOMETIMES INVOKING THE ANTI-SKIP CONTROL. THE DANGER IN THIS BEHAVIOR OCCURS WHEN MAKING A TURN INTO ON-COMING TRAFFIC AFTER SLOWING DOWN TO AROUND 10-15 MPH. AFTER THE TURN, THE CAR IS POSITIONED IN THE TRAFFIC LANE, BUT YOU HAVE NO POWER TO ACCELERATE INTO THE FLOW OF TRAFFIC. THE ONCOMING CARS ARE NOW CLOSING IN ON YOUR CAR AT A FAST RATE, AND YOU'RE BASICALLY STUCK. THIS SITUATION IS MOST PRONOUNCED IN THE "AUTO" MODE OF THE DCT TRANSMISSION, BUT ALSO OCCURS TO A LESSER DEGREE WHILE IN THE MANUAL MODE WHEN YOU SELECT SECOND GEAR IN PREPARATION FOR THE TURN. IT IS ALSO VERY REPEATABLE IN BOTH MODES. THESE PROBLEMS STARTED OCCURING AFTER A PREVIOUS RECALL ON THIS TRANSMISSION WHERE THE ENGINE WOULD STALL UNDER HARD BRAKING OR NOT SHIFT UNDER HARD BRAKING. THE RECALL FIXED THAT PROBLEM, BUT INTRODUCED THIS PROBLEM, WHICH OCCURS ALMOST EVERY DAY WHEREAS THE PREVIOUS PROBLEM ONLY OCCURED DURING A SPECIFIC SITUATION. THANK YOU FOR LOOKING INTO THIS DANGEROUS MATTER. *TR

WITH THE DUAL CLUTCH AUTOMATIC TRANSMISSION IN D MODE, WHEN SLOWING FROM 50 OR 60 MPH TO 15-20 MPH THE TRANSMISSION WILL NOT DOWNSHIFT AND STAYS IN 6TH OR 7TH GEAR. EVEN WITH THE ACCELERATOR TO THE FLOOR THE CAR WILL NOT SELECT AN APPROPRIATE GEAR WHICH MAKES THE CAR BARELY ACCELERATE AT ALL CREATING A SAFETY HAZARD. THIS CAR HAS LITTLE TO NO TORQUE (BY DESIGN) AT VERY LOW RPMS, AND IT BASICALLY JUST SITS THERE AND DOESN'T MOVE. A DRIVER OFTEN SLOWS LIKE THIS WHEN MAKING A LEFT OR RIGHT HAND TURN AND HAVING THE CAR JUST SIT THERE UNDER THOSE CONDITIONS PRESENTS A HUGE SAFETY ISSUE IN TERMS OF BEING EITHER REAR-ENDED OR BEING HIT BY ONCOMING TRAFFIC. THE ENTIRE NATURE OF THE AUTOMATIC PROGRAM ON THIS CAR IS UNPREDICTABLE; IN SOME CASES IT WILL DOWNSHIFT, IN OTHERS (AS DESCRIBED ABOVE) IT WILL NOT, WHICH ADDS TO THE UNSAFE NATURE OF THIS DEFECT. IT DOES NOT BEHAVE LIKE ANY AUTOMATIC TRANSMISSION I'VE EVER OWNED. THE SOFTWARE CONTROLLING THE TRANSMISSION WAS UPDATED IN DECEMBER 2009. PRIOR TO THAT, IN EITHER MANUAL OR AUTOMATIC MODE THE CAR WOULD DOWNSHIFT INTO A LOWER GEAR, BUT THERE WAS A 1-2 SECOND PAUSE BEFORE ANY POWER WAS DELIVERED (THE ENGINE WOULD NOT "GO" EVEN ACCELERATOR TO THE FLOOR). THIS ISSUE HASN'T RECURRED, BUT THE SITUATION IS STILL NOT RECTIFIED (AS NOTED IN THE DESCRIPTION ABOVE) AS THE "NEW" ISSUE WITH FAILING TO DOWNSHIFT IN D MODES HAS SURFACED. *TR