2022 BMW X3 Complaints

The contact owns a 2022 BMW X3. The contact received notification of NHTSA Campaign Number: 26V438000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

2022 BMW X3 M40i. The Driver Assistance system appears to activate normally after startup with no warning or indication that a fault is present. However, within approximately 3–5 minutes of driving, a Check Control message appears stating “Driver Assistance limited. Camera vision.” The vehicle then identifies affected systems including Pedestrian Warning, Frontal Collision Warning, Side Collision Warning, Automatic Lane Change, Active Blind Spot Detection, and Steering Assistant. A separate message states that Active Cruise Control is reduced and there may be no brake intervention for stationary vehicles. The safety concern is that the system can appear active and available before the warning appears, even though at least some driver-assistance functions may already not be operating. Before the warning was displayed, I observed that Steering Assistant/lane-keeping did not intervene and I crossed out of my lane without steering correction or a lane-departure warning. There was no prior warning that the camera-based system was malfunctioning. I cannot confirm whether the other affected safety functions were operational during this interval. A BMW dealer inspected the vehicle and physically found the KAFAS camera hood/trim warped from heat. The warped component was removed and shown to me, and the dealer ordered a replacement. BMW has issued SIB 66 13 23 addressing KAFAS camera hood deformation on affected vehicles. Fault memory also contained KAFAS codes 800ABF, 800ABE, and 800AC4 for camera field-of-view disturbance and calibration failure. This creates a potential safety defect because the driver may reasonably believe lane-keeping and other camera-based safety systems are functioning until the vehicle detects the failure several minutes later. The vehicle/component can be made available for inspection

- Customer Reports: ac not cooling, stopped cooling yesterday while on the highway, approved evac and recharge if needed Caused by Leaking a/c hose from compressor to condenser Tech: CHRISTOPHER ARCHER (F88) Installed 64 53 9 868 421 : B1-Pressure hose assy c Installed 64 53 9 284 018 : B1BIMIRRZN-Gasket ring Confirmed concern. Performed vehicle

belt tensioner failed while on highway without warning, leading to complete shutdown of the engine. Car had to be towed for repair. Complete disintegration of the timing belt, the car only had 51,000 miles. Expensive repair

The contact owns a 2022 BMW X3. The contact stated that while driving at an undisclosed speed in hot weather, the air conditioner failed to operate as intended. The vehicle was taken to the dealer, where it was determined that the air conditioner line was rubbing against a pulley, presenting a fire hazard. The contact was informed that the air conditioner hose needed to be replaced. The manufacturer was made aware of the failure. The failure mileage was approximately 52,000.

On June 23, 2026 around 3:30pm, we were driving 70 mph on an interstate (I40) and the panoramic sunroof spontaneously shattered on our BMW X3. We were not struck by anything and there was no inclement weather or extreme heat. The sunshade was pulled so we were not hit by the glass, but we were very much in danger. My baby was in the backseat and he would have had glass all over him. We had to pull over on the highway and had to arrange for another car to take us home.

car starts emitting white smoke with plastic burning smell inside car and outside. no notifications on dash board before this happens therefore emitting this white smoke into car which we are subjected to inhaling further

regarding my 2022 BMW X3 due to ongoing issues involving low coolant warnings, coolant leaking, and repeated cooling system problems shortly after reaching approximately 55,000 miles. My vehicle began displaying “low coolant” warnings and has required frequent coolant refills despite normal driving conditions and regular maintenance.the vehicle appears to have an active coolant leak and ongoing cooling system malfunction that has not been permanently resolved.

The oil filter housing failed and needed to be replaced due to be leaking coolant.. after changed that the failure of the water pump started to failed and engine started to spike high temperatures..

Oil Filter Housing leak confirmed on my 2022 BMW X3 M40i. My current odomoter reading is at 47K miles and I was told that I could have a catastrophic failure of my engine if not repaired. I am several weeks out of my warranty expiration date and am frustrated that BMW won't honor a warranty claim for an issue known to take a long time to find symptons before being able to fix.