2013 CAN-AM SPYDER Complaints

TL* THE CONTACT OWNS A 2013 CAN-AM SPYDER RT. THE CONTACT RECENTLY PURCHASED THE VEHICLE AND DISCOVERED THAT IT WAS INCLUDED IN NHTSA CAMPAIGN NUMBER 13V386000 (SERVICE BRAKES, HYDRAULIC). THE MANUFACTURER INFORMED THE CONTACT THAT THE VEHICLE WAS NOT REPAIRED. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

THERE IS EXTREME HEAT UNDER THE SEAT. I HAVE RECEIVED 1ST DEGREE BURNS ON MY RIGHT ANKLE AND RIGHT THIGH. THE GAS CAP GETS SO HOT ONE MUST USE GLOVES TO REMOVE THE GAS CAP WHEN PURCHASING FUEL. I CAN HEAR THE GAS BOILING OR BUBBLING IN THE TANK AFTER RIDING FOR SHORT PERIODS OF TIME. THE RAW GAS SMELL IS SO STRONG WHEN PARKING IN THE GARAGE IT MAKES ONES EYES BURN. I HAD THE LOCAL FIRE DEPARTMENT CHECK THE GAS VAPOR CONCENTRATION IN THE GARAGE AFTER RIDING AND FOUND IT WAS CLOSE TO BEING STRONG ENOUGH CONCENTRATION TO CAUSE A EXPLOSIVE SITUATION IF THE RIGHT SPARK WAS INTRODUCED, WAS CAUTIONED NOT PARK IN THE GARAGE UNTIL THE UNIT COOLED OFF, BY THE FIRE DEPARTMENT. THERE IS A SERIOUS HEALTH ISSUE INVOLVED ALSO, WAS ADVISED BY A UROLOGIST THAT CONTINUED EXPOSURE TO HIGH HEAT ON THE MALE GENITALIA, COULD PRODUCT MALE REPRODUCTIVE ISSUES AS WELL AS MALE PERFORMANCE PROBLEMS WAS TOLD TO REFRAIN FROM RIDING THE BRP CAN-AM SPYDER FOR PERIODS OVER AN HOUR AT A TIME TO AVOID EXPOSER TO HARMFUL HIGH HEAT. I HAVE HAD ALL THE RE-CALL, AND RECOMMENDED SERVICE DONE. THE DEALER HAS CONTACTED BRP AND THERE IS NO SOLUTION OFFERED. I HAVE CONTACTED BRP AND BEEN GIVEN THE RUN-A-ROUND, AND TOLD TO GO TO THE DEALER, DEALER IS AT A LOSS ON WHAT TO DO. I WAS TOLD BY THE BRP TECH. DEPARTMENT TO KEEP THE ENGINE RPM ABOVE 5000 WHICH I HAVE DONE, WHICH IS NEAR IMPOSSIBLE IN CITY TRAFFIC, THIS MADE NO DIFFERENCE IN THE EXTREME HEAT. BRP IS WELL AWARE OF THE PROBLEM BUT APPEARS THAT THEY ARE GOING TO WAIT TO TAKE CORRECTIVE ACTION UNTIL THERE IS A GARAGE EXPLOSION, SERIOUS INJURY, OR DEATH TO TAKE ANY CORRECTIVE ACTION. THE NHTSA NEED TO TAKE ACTION AND NOT WAIT TO LET THIS TURN INTO ANOTHER GM MESS WHERE PEOPLE ARE HURT OR DIE DUE TO NO ACTION. *TR

VEHICLE HAS NO MEANS OF RELEASING HEAT TRAPPED UNDER PLASTIC PANELING WHEN AT LOW SPEEDS OR WHEN VEHICLE IS STOPPED. HAD TWO BREAKDOWNS AT STOP AND GO SITUATIONS WHERE THE VEHICLE WAS NOT MOVING ALLOWING HEAT TO ESCAPE. THIS AFFECTED OTHER COMPONENTS (EVAPORATOR CANISTER...ECT) WHICH CAUSE FAILURE AND RENDERS THE VEHICLE UNSAFE. HAVING CONVERSATIONS WITH BRP I KNOW THEY ARE AWARE AND HAVE NO SOLUTION. THIS IS NOT AN ISOLATED INCIDENT BRP NOW HAS COME OUT WITH THE 2014 MODEL AND CLEARLY STATES IN ITS ADVERTISING CAMPAIGN THAT "ON OUR NEW MODELS WE ADDRESS THE HEAT ISSUE" SO YOU KNOW YOU HAVE IT... AND YOU FIXED IT ON THE NEWER MODELS WHILE BEHIND YOU LIES CUSTOMERS WITH OLDER MODELS THAT ARE CLEARLY DEFECTIVE AND QUITE UNSAFE... *TR

THIS VEHICLE HAS AN EXTREMELY DANGEROUS HEAT PROBLEM. HEAT BUILDS UP UNDER THE FIBERGLASS PANELS WHICH RESULTS IN THE GAS CAP BECOMING TOO HOT TO TOUCH WITH YOUR BARE HAND, AND GASOLINE BOILING IN THE TANK. ALSO, THE RADIATOR FAN BLOWS VERY HOT AIR ON MY RIGHT FOOT WHICH IS VERY UNCOMFORTABLE. ADDITIONALLY, I CAN SMELL GAS FUMES WHEN RIDING, AND THE FUMES ARE OVERPOWERING WHEN PARKING THE BIKE AFTER RIDING. I LEAVE THE BIKE OUTSIDE MY GARAGE UNTIL THE FUMES DISSIPATE, AS I FEEL THAT IT DANGEROUS TO PARK IN THE GARAGE WITH THE OVERPOWERING GAS FUMES. BRP AND THE DEALERS ARE AWARE OF THESE PROBLEMS, AND CAN OFFER NO FIX FOR THEM. THESE PROBLEMS HAVE BEEN ADDRESSED IN THE 2014 MODELS, SO OBVIOUSLY THERE IS A WAY TO REMEDY THEM. WHENEVER I AM ASKED HOW I LIKE THE BIKE, I TELL PEOPLE THAT THE GAS MILEAGE IS HORRENDOUS, THE HEAT PROBLEM IS UNCOMFORTABLE, AND THE GAS FUMES ARE UNBEARABLE AND DANGEROUS. I ADVISE THEM NOT TO BUY THIS VEHICLE. *TR

THIS VEHICLE HAS AN EXTREMELY DANGEROUS HEAT PROBLEM. HEAT BUILDS UP UNDER THE FIBERGLASS PANELS WHICH RESULTS IN THE GAS CAP BECOMING TOO HOT TO TOUCH WITH YOUR BARE HAND, AND GASOLINE BOILING IN THE TANK. ALSO, THE RADIATOR FAN BLOWS VERY HOT AIR ON MY RIGHT FOOT WHICH IS VERY UNCOMFORTABLE. ADDITIONALLY, I CAN SMELL GAS FUMES WHEN RIDING, AND THE FUMES ARE OVERPOWERING WHEN PARKING THE BIKE AFTER RIDING. I LEAVE THE BIKE OUTSIDE MY GARAGE UNTIL THE FUMES DISSIPATE, AS I FEEL THAT IT DANGEROUS TO PARK IN THE GARAGE WITH THE OVERPOWERING GAS FUMES. BRP AND THE DEALERS ARE AWARE OF THESE PROBLEMS, AND CAN OFFER NO FIX FOR THEM. THESE PROBLEMS HAVE BEEN ADDRESSED IN THE 2014 MODELS, SO OBVIOUSLY THERE IS A WAY TO REMEDY THEM. WHENEVER I AM ASKED HOW I LIKE THE BIKE, I TELL PEOPLE THAT THE GAS MILEAGE IS HORRENDOUS, THE HEAT PROBLEM IS UNCOMFORTABLE, AND THE GAS FUMES ARE UNBEARABLE AND DANGEROUS. I ADVISE THEM NOT TO BUY THIS VEHICLE. *TR

REPEATED PROBLEMS WITH ODOR OF FUEL AND INTERMITTENT STALLING. EVAP CANISTER WAS REPLACED TWICE (FUEL IN CANISTER) AND PURGE VALVE ONCE. APPEARS TO AFFECT RUNNING AS IT MISSES AND SURGES AT A CONSTANT SPEED (VERY SUBTLE). SINCE I PARK THIS IN MY ATTACHED GARAGE IT IS A CONCERN. VEHICLE HAS BEEN IN SHOP 5 TIMES FOR A TOTAL OF 2 1/2 MONTHS DURING MY 6 MONTHS OF OWNERSHIP. BRP HAS NOW TOLD ME THAT THEY WILL NO LONGER REPAIR THIS VEHICLE WHICH NOW HAS ONLY 2600 MILES. *JS

DURING ENGINE OPERATION; THE VEHICLE SENDS EXTREMELY HOT AIR OUT OF THE SPACE BETWEEN THE FORWARD EDGES OF THE SEAT AND UPPER AND SIDE BODY PANELS, THE UPPER SIDE PANELS ARE VERY HOT TO TOUCH, AND THE UNDERSEAT AREA ACCUMULATES AN EXCESSIVE AMOUNT OF HOT AIR ALLOWING THE FUEL CAP FOUND UNDER THE SEAT TO BECOME HOT TO THE TOUCH. THE SEAT HEAT PROBLEMS MAKE RIDING AND CONTROLLING THE VEHICLE DIFFICULT BECAUSE OF THE DISCOMFORT FELT BY THE DRIVER AND PASSENGER. IF THE DRIVER IS NOT WEARING THICK, PROTECTIVE GARMENTS COVERING THEIR LEGS THERE IS A POSSIBILITY OF BURNS ABOUT THE UPPER LEGS OR LOWER TORSO. THIS ISSUE IS ESPECIALLY EVIDENT WHEN THE OAT IS ABOVE 80 DEG FARENHEIT. *TT

WHEN STOPPING AT STOP SIGNS, TRAFFIC LIGHTS OR JUST STOPPING TO PARK THERE IS AN EXCESSIVE GAS SMELL COMING FROM THE VEHICLES EVAP CANISTER. THIS ALL STARTED WHEN THE OUTSIDE TEMPERATURES EXCEEDED 70 DEGREES. THIS SMELL OCCURS IF THE FUEL TANK IS FULL, HALF FULL OR NEARLY EMPTY. ON SUNDAY 4/13/14 WHEN COMING HOME FROM A LONG RIDE I DECIDED TO CHECK OVER SOME THINGS AND DISCOVERED THE GASOLINE IN THE FUEL TANK WAS BOILING! THE EXAUST PIPE ON THIS MACHINE RUNS VERY CLOSE TO THE FUEL TANK. *TT

HERE IS A LIST OF ISSUES WITH MY MOTORCYCLE, AND HUNDREDS OF CAN AM OWNERS 1- GAS SMELL 2- GAS BOILING AFTER RIDING 3- OVERHEATING, BURNING IF YOU TOUCH IT BOMBARDIER IS NOT FIXING IT, BUT THEY CHANGE THE DESIGN ON THE 2014 WITH NEW VENTS AND THEY ARE ASKING US TO PAY FOR THE FIX. MY BIKE IS SO HOT THAT MY WIFE HAVE ASK ME NOT TO RIDE ANYMORE, SHE ALSO ASK ME TO TO TAKE THE KIDS OR HER FOR RIDES BECAUSE OF THE SAFETY ISSUES, IF YOU CHECK ON THE SPYDERLOVER.COM FORUM YOU WILL SEE THAT BRP IS NOT DOING ANYTHING TO HELP THE HEAT ISSUES WE HAVE, MANY CALLS AND VISITS TO MY DEALER BAY HARBOR MOTORS IN NEW YORK, PLEASE HELP US BEFORE SOMETHING TRAGIC HAPPENS WHEN WE ARE RIDING A DEFECTIVE PRODUCT. *TT

RAW FUEL SMELL AFTER TRIKE WARMS UP AND COMES TO A STOP. RIGHT LEG AND FOOT ALOS BECOMES HOT WHILE RIDING. GAS CAP HOT WHEN REMOVING TO FILL UP. WAS TOLD BY DEALER THAT THERE IS NOTHING THEY CAN DO AND IS A VERY COMMON COMPLAINT. THE WARMER IT GETS THE WORSE THE RAW FEUL ODOR, AND HEAT BUILD UP GETS. DEALER CLAIMS THAT THE GAS ACTUALLY BOILS IN THE FUEL TANK AND VAPORIZE. THEY ALSO SAID THAT THERE IS NO FIX FOR THIS CURRENTLY. I WAS IN CONTACT WITH THE MANUFACTURE (BRP) AND THEY ISSUED ME A CASE NUMBER FOR REFERENCE WHILE DENYING ANY COMPLAINTS ABOUT THIS. MY FEAR IS THE TRIKE CATCHING FIRE, AS MY RESEARCH HAS FOUND THIS TO HAPPEN. I USUALLY HAVE A PASSENGER WITH ME AND I FEAR SHOULD A FIRE OCCUR MY PASSENGER WON'T HAVE ENOUGH TIME TO GET AWAY. THIS ALSO INCLUDES MYSELF GETTING AWAY. SEARCH SYDERLOVERS.COM AND YOU WILL SEE MANY POSTS ON THIS ISSUE. I FEEL THAT THE NHTSA NEEDS TO STEP IN AND TAKE A SERIOUS LOOK INTO THIS PROBLEM AND MAKE BRP ADDRESS THIS BEFORE SOMEONE GETS KILLED DUE TO SHEAR IGNORANCE. B *TT