1999 CHEVROLET ASTRO Complaints

WHILE BACKING INTO A PARKING SPACE THE RIGHT FRONT LOWER CONTROL ARM SNAPPED OFF DROPPING THE FRONT END TO THE GROUND. *TR

I HAVE 2- CHEVY ASTRO VANS. 1-1998, 1-1999. THE 1999 HAS CORRODED BRAKE LINES AND GAS LINES. THE MAIN BRAKE LINES ARE CORRODED INTO. I WAS COMING BACK FROM A LONG TRIP YESTERDAY AND I NOTICED THAT THE BRAKES WERE SOFT. WHEN I GOT HOME UPON INSPECTION I CHECKED THE BREAK FLUID AND IT WAS LOW. I FILLED IT. I NOTICED A PUDDLE OF FLUID BY THE BACK TIRE. AND LOOKED, I DISCOVERED ALL OF THE BRAKE AND GAS LINES WERE EAT UP WITH CORROSION. GM NEEDS TO TAKE THIS AS A VERY SERIOUS PROBLEM AND FIX IT IMMEDIATELY. I COULD HAVE BEEN KILLED , OR I COULD HAVE KILLED SOMEONE IF THE BRAKES FAILED TO HOLD. I INSPECTED THE 1998 ASTRO VAN TO SEE IF IT HAD A PROBLEM TO. AND UPON DOING SO DISCOVERED IT IS FINE, NO PROBLEMS. I HAVE PICS OF BOTH VANS THE PICS WILL SHOW THAT MY STATEMENT IS TRUE. I BOUGHT THE 1999 VAN (THE ONE WITH CORRODED LINES) IN THE STATE OF OHIO. AND I BOUGHT THE 1998 VAN IN ALABAMA.I DO NOT KNOW WHY THIS IS, BUT I KNOW I AM NOT THE ONLY ONE WITH A FAULTY GM PRODUCT WITH CORROSIVE BRAKE AND GAS LINES. I AM VERY THANKFUL I DISCOVERED THIS BEFORE TRAGEDY HAPPENED. THIS IS A POTENTIAL DEADLY PROBLEM, AND GM NEEDS TO RESOLVE THIS BEFORE SOMEONE LOOSES THEIR LIFE, NOT AFTER. ANY HELP WITH GETTING THIS RESOLVED IS GREATLY APPRECIATED! I JUST WANT TO LET UNSUSPECTING GM OWNERS KNOW ABOUT THIS DANGER! *TR

TL* THE CONTACT OWNS A 1999 CHEVROLET ASTRO. THE CONTACT STATED THAT THE VEHICLE CAUGHT ON FIRE. THE CONTACT APPROACHED THE VEHICLE AND NOTICED THAT THE ENTIRE FRONT END OF THE VEHICLE WAS ENGULFED IN FLAMES. THE FIRE DEPARTMENT FILED A REPORT STATING THAT THE FIRE WAS DUE TO ON ELECTRICAL ISSUE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 230,000. *TR

HAD CRUISE CONTROL ENGAGED PRIOR TO ENTERING A REDUCED SPEED AREA AND IT FUNCTIONED NORMALLY. AFTER DEPARTING THE REDUCED SPEED AREA, I ENGAGED THE RESUME FUNCTION AND THE VEHICLE ACCELERATED PAST THE SET SPEED AND KEPT SPEEDING UP. I WAS ABLE TO CONTROL THE VEHICLE WITH BRAKES ALTHOUGH THEY GOT VERY HOT AND SMOKED SEVERELY. ATTEMPTS TO TURN OFF THE CRUISE CONTROL FAILED, AS WELL AS TURNING OFF AND REMOVING THE KEYS FROM THE IGNITION. AFTER SUCCESSFULLY STOPPING THE VEHICLE, I CONTINUED ATTEMPTS TO DISENGAGE THE CRUISE CONTROL BUT ANY ATTEMPT TO START THE ENGINE RESULTED IN IMMEDIATE RACING OF THE ENGINE. I EXAMINED THE OWNER'S MANUAL AND DISCOVERED THAT FUSE NUMBER 6 WAS LABELED "CRUISE MODULE, CRUISE CONTROL SWITCH, ELECTROMECHANICAL MIRROR". THE FUSE WAS REMOVED BUT THE ENGINE RACED UPON ATTEMPTING TO START IT. I THEN DISCOVERED THAT FUSE NUMBER 18 WAS LABELED "VCM-IGN 3, VCM-BRAKE, 4WAL, CRUISE STEPPER MOTOR SIGNAL". UPON REMOVING THIS FUSE, I WAS ABLE TO START THE ENGINE, AND IT REMAINED IN NORMAL PARAMETERS. I DID NOTICE THAT THE ANTILOCK LIGHT WAS ON, BUT BELIEVE THIS IS RELATED TO THE VCM-BRAKE LABEL ON THE CIRCUIT BREAKER. I WAS THEN ABLE TO CONTINUE DRIVING THE VEHICLE HOME, AND WILL BE CONTACTING THE REPAIR SHOP TO DISABLE/REMOVE THE CRUISE STEPPER MOTOR, AS I REFUSE TO CHANCE ANOTHER UNINTENDED ACCELERATION EVENT. *TR

TL*THE CONTACT OWNS A 1999 CHEVROLET ASTRO. THE CONTACT STATED THAT THE PASS LOCK MODULE THAT TURNED OFF THE GAS TO THE ENGINE FAILED. THE VEHICLE WOULD START UP BRIEFLY BUT THEN SHUT OFF. THE DEALER STATED THAT IT WAS A COMMON PROBLEM BUT IT WAS NOT RELATED TO ANY RECALLS. THE FAILURE MILEAGE WAS APPROXIMATELY 110,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 125,000.

WILL NOT START WHEN WEATHER IS DAMP. WILL TAKE 3 OR 4 DAYS TO DRY OUT BEFORE STARTING AGAIN. NO MECHANIC HAS BEEN ABLE TO PIN POINT THE PROBLEM. TOWED TO SHOP VAN SITS INSIDE THE BAY DRIES OUT AND STARTS WITHIN 2-3 HOURS. HAPPENS EVERY TIME IT GETS DAMP. 10 YEARS BEEN DOING THE SAMETHING. *TR

ANTI THEFT SECURITY SYSTEM FAILURE. LOCKS OWNER OUT FROM STARTING VEHICLE IN WET WEATHER. BAD PLACEMENT OF COMPUTER SYSTEM PLACED UNDER BATTERY. CORROSION OF SECURITY SYSTEMS COMMUNICATIONS WIRING CAUSED LOCK OUT AND CAR WILL NOT START. *TR

TL*THE CONTACT OWNS A 1999 CHEVROLET ASTRO. THE POWER STEERING PUMP FAILED WHILE DRIVING APPROXIMATELY 10 MPH. THE CONTACT APPLIED THE BRAKES, BUT NOTHING HAPPENED. HE THEN DEPRESSED THE BRAKE PEDAL ALL THE WAY TO THE FLOOR, BUT THE VEHICLE DID NOT STOP. THE VEHICLE CRASHED INTO HIS HOME. THE VEHICLE WAS TOWED TO A SHOP AND THE MECHANIC STATED THAT THERE WAS FAILURE WITHIN THE POWERTRAIN. HE FURTHER STATED THAT THE POWER STEERING AND POWER BRAKES WERE CONNECTED TO THE SAME UNIT, CAUSING BOTH TO FAIL SIMULTANEOUSLY. HE CALLED GM AND A REPRESENTATIVE FROM THE ENGINEERING DEPARTMENT STATED THAT THE BRAKES SHOULD HAVE WORKED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 75,000 AND CURRENT MILEAGE WAS 120,000.

TL*THE CONTACT OWNS A 2000 CHEVROLET ASTRO. WHILE DRIVING 25 MPH THROUGH SNOW AND ICE, THE CONTACT LOST CONTROL OF THE VEHICLE AND SLID OFF THE ROAD. THE VEHICLE THEN STRUCK A TELEPHONE POLE. THE AIR BAGS FAILED TO DEPLOY. THE SEAT BELT FAILED TO RESTRAIN HIM AND HE STRUCK HIS HEAD ON THE WINDSHIELD. THE WOUND TOOK 24 STITCHES TO CLOSE. MOST OF THE VEHICLE WAS REPAIRED AT THE COST OF $4,500. THE MANUFACTURER'S INVESTIGATOR CONCLUDED THAT THE AIR BAG WOULD NOT DEPLOY AT 25 MPH. THE ARKANSAS POLICE DEPARTMENT FILED REPORT NUMBER 07-00343. THE CURRENT MILEAGE WAS 146,661 AND FAILURE MILEAGE WAS 125,000.

DT*: THE CONTACT STATED THE VEHICLE LOST POWER ASSIST STEERING & POWER ASSIST BRAKES SIMULTANEOUSLY WHILE DRIVING 3 MPH. THERE WERE NO WARNINGS PRIOR TO THE INCIDENT. THE VEHICLE WAS NOT INSPECTED BY A DEALER, HOWEVER, AFTER SOME RESEARCH, THE CONTACT DISCOVERED THE POWER STEERING PUMP HAD FAILED, CAUSING LACK OF PRESSURE TO THE BRAKES AND STEERING. UPDATED 10/25/2006 - THE SHAFT IN THE POWER STEERING PUMP SNAPPED. *NM