2002 CHEVROLET ASTRO Complaints

The contact owns a 2002 Chevrolet Astro. The contact stated that while driving at an undetermined speed, the accelerator throttle cable fractured in the stuck open position, causing the vehicle to accelerate to approximately 100 MPH independently. There were no warning lights illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted and notified of the failure. The approximate failure mileage was 258,300.

GOODYEAR VIVA 3 TIRES SUFFERED STONE PUNCTURES. TIRE SIZE 215/75R15. BOUGHT TWO NEW ONES 10/5/16 AND TWO MORE NEW ONES 3/7/17. THIS VEHICLE IS INFREQUENTLY DRIVEN AND ONLY OCCASIONALLY ON COUNTY MAINTAINED GRAVEL ROADS. ONLY DROVE 18300 MILES BEFORE FIRST STONE PUNCTURE 9/27/20. SECOND STONE PUNCTURE OCCURRED WITH ONLY 12/17/20 WITH 15800 MILES ON THAT TIRE. THIRD STONE PUNCTURE OCCURRED 1/17/20 WITH 16200 MILES. DOT NUMBER MD36JK1R4116 FOR TIRES BOUGHT 13/7/17. DOT NUMBER MD36JK1R1216 FOR TIRES BOUGHT 10/5/16.

WHILE VEHICLE WAS BEING DRIVEN.THE ALERT WARNING LIGHT FOR THE AIR BAGS ILLUMINATED. I WAS AFRAID TO DRIVE THE VEHICLE DUE TOO THE AIR BAG INFLATOR MIGHT RUPTURE OR UNDERINFLATE. IN THE EVENT OF A CRASH. AN UNDERINFLATED AIR BAG MAY NOT PROPERLY PROTECT THE OCCUPANT. THIS SCENARIO INCREASES THE RISK OF SERIOUS INJURY OR DEATH.

WHEN RAINING WIDSHIELD WIPERS DONT WORK AS DIRECTED, THEY DO WHAT THEY WANT. THEY STAY ON AFTER SHUTTING THEM OFF. AND DOOR LOCKS LOCK AND UNLOCK REPEATEDLY. WIPERS ALSO SHUT OFF IN THE MIDDLE OF LINE OF SIFHT INTERMITTENTLY. NEVER WORKS CORRECTLY

TL* THE CONTACT OWNS A 2002 CHEVROLET ASTRO. THE CONTACT STATED THAT ON SEVERAL OCCASIONS, THE BRAKE LIGHTS AND HAZARD LIGHTS FAILED. THE CONTACT STATED THAT IF THE BRAKE PEDAL WAS DEPRESSED AND THE HAZARD LIGHT SWITCH WAS MOVED AROUND THE LIGHTS WOULD FUNCTION AS INTENDED. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED OR REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V099000 (EXTERIOR LIGHTING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE. UPDATED 07/13/16*LJ THE CONSUMER STATED THE BRAKE LIGHTS ONLY WORKED, IF THE HAZARD LIGHT SWITCH WAS FORCED TO ONE SIDE AND HELD IN PLACE. UPDATED 07/13/16.*JB

I GOT IN MY VAN TO DRIVE TO A STORE AND THE BRAKE PEDAL WENT RIGHT TO THE FLOOR. THERE WAS BRAKE FLUID LEAKING FROM NEAR THE REAR TIRE. THE STEEL HARD BRAKE LINE RUNNING FROM THE ABS UNIT TO THE REAR AXLE IS RUSTED THROUGH AND IS LEAKING. THIS WAS A SUDDEN EVENT. ALSO THE FUEL LINES LOOK TO BE JUST AS BAD. I'M SURE STAINLESS STEEL LINES WOULD NOT HAVE ADDED MUCH TO THE VEHICLES COST AND WOULD HAVE PREVENTED THIS HAZARD AND EXPENSE. *TR

TL* THE CONTACT OWNS A 2002 CHEVROLET ASTRO. THE CONTACT STATED THAT THE DRIVER'S SIDE SEAT BELT WEBBING FAILED TO LOCK AND WAS ABLE TO BE PULLED FROM THE HOUSING. THE FAILURE RECURRED MULTIPLE TIMES. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 325,000.

I WAS DRIVING AND ALL OF A SUDDEN, THE DASH LIGHTS WENT OUT AND THE CAR DIED. I LOST POWER STEERING, AND I COASTED TO THE SIDE OF THE ROAD. COME TO FIND OUT THE FUSE BOX WAS HOT AND THERE WAS A FEW FUSES THAT WERE BLOWN. I REPLACE THE BLOWN FUSES AND DROVE HOME. WHEN I GOT HOME AND TURNED OFF THE VAN, I COULDN'T GET IT START I LOOKED AT THE SAME FUSE AND THEY WERE BLOWN AGAIN. THE VAN NOW SITS IN THE DRIVEWAY TILL I FIGURE THIS OUT. BECAUSE IT IS TOO DANGEROUS TO DRIVE. *TR

TL* THE CONTACT OWNS A 2002 CHEVROLET ASTRO EQUIPPED WITH GREMAX MAX 5000 TIRES (N/A), SIZE 215/75R15 AND THE DOT WAS JEHKDVP2312. THE CONTACT STATED THAT WHILE TRAVELING 40 MPH, THE FRONT PASSENGER SIDE TIRE BLEW OUT. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE TIRE AND VEHICLE FAILURE MILEAGE WAS 142,057.

VEHICLE LOST ALL ELECTRICAL POWER TO EVERY SYSTEM THAT IS CONTROLLED BY THE IGNITION BEING TURNED ON. DRIVER WAS IN THE PROCESS OF MAKING A U-TURN AROUND A CURBING ISLAND IN THE DIVIDED TRAFFIC ROAD WHEN ALL ELECTRICAL WAS INTERRUPTED WHILE THE STEERING WHEEL WAS TURNED ALL THE WAY TO THE LEFT. CONDITION CAUSED STEERING TO BECOME DIFFICULT, BRAKE PEDAL WENT CLEAR TO THE FLOOR, AIR CONDITIONING AND RADIO AND HEADLIGHTS ALL WENT OFF. CONDITION WAS REPEATABLE WITH EXCEPTION OF BRAKE PEDAL, EACH TIME STEERING WAS TURNED TO THE LEFT. INSPECTION UNDER VEHICLE FOUND THAT MAIN POWER CABLE IS ROUTED ACROSS FRONT SIDE OF MAIN FRAME MOTOR MOUNT MEMBER. THERE WAS A SLIGHT CURVE IN THE WAY THE WIRE WAS ROUTED AND EACH TIME THE STEERING WAS TURNED TO THE LEFT, THE INNER TIE ROD END FOR THE RIGHT WHEEL CAME IN CONTACT WITH THE WIRE HARNESS. AFTER MANY MILES, THE PROTECTIVE COVER AND THEN THE ACTUAL WIRE INSULATION WAS RUBBED THROUGH. THIS CAUSED A DIRECT SHORT TO GROUND THROUGH THE STEERING PARTS OF ALL (SWITCHED WHILE RUNNING) ELECTRICAL COMPONENTS OF THE VEHICLE. PROBLEM WAS CORRECTED BY TAPING THE WIRE INSULATION, THEN TAPING THE PROTECTIVE COVERING. I THEN HAD TO FABRICATE A BRACKET TO SCREW TO THE STEEL CRUMPLE MEMBER TO HOLD THE HARNESS BACK FROM THE STEERING LINKAGE. *TR