2013 CHEVROLET AVALANCHE 1500 Complaints

MY DEALER WORKED ON MY AC COMPONENTS IN 2015 (NOT SURE OF THE EXACT DATE) TO REPLACE THE AC CONTROLLER COMPONENTS, SHORTLY AFTER THE REPAIR MY DASH CRACKED WHILE SITTING IN MY DRIVEWAY ABOUT TO CRANK THE VEHICLE. ON THE DRIVER SIDE OVER THE LAST 3 YEARS IT HAS CONTINUED TO INCREASE IN SIZE AND NOW IS CRACKED COMPLETELY CAUSING THE DASH TO BE TWO SEPARATE PIECES. SAFETY ISSUES AND CONCERNS ARE IF A CRASH OCCURS WILL THE OCCUPANTS OF THE VEHICLE BE SAFE OF SHARP FLYING DEBRIS WITHIN THE CAB. MY CONCERN IS NOT ONLY FOR MYSELF BUT MY PASSENGERS. I HAVE INQUIRED SEVERAL TIMES ABOUT REPLACING THE PART BUT IT WAS NOT COVERED UNDER THE EXTENDED WARRANTY AT THE TIME IT INITIALLY CRACKED. MILEAGE OF INITIAL CRACK WAS APPROX 75,000.

THE ADHESIVE SECURING THE 4 PIECES OF DOOR TRIM IS BREAKING DOWN AND THE TRIM PIECES WILL EVENTUALLY FALL OFF ON THEIR OWN, A POTENTIAL HAZARD TO OTHER MOTORISTS DEPENDING ON WHEN AND WHERE IT HAPPENS. THESE ARE SUPPOSED TO BE A NO MAINTENANCE ITEM. REPORTED TO CHEVROLET, CASE # 8-4199057982, AND THEY DO NOT SEEM TO BE CONCERNED THAT THIS "LIFE OF THE VEHICLE" INSTALLATION IS DEFECTIVE AS THE 3 YEAR BUMPER-TO-BUMPER WARRANTY IS EXPIRED. AS A PRINCIPLE ENGINEER IN BOEING'S RESEARCH AND TECHNOLOGY DIVISION (WE TEST STUFF TO MAKE SURE IT'S SAFE), MY INFORMED OPINION IS THE DEFECT IS CAUSED BY POOR SURFACE PREPARATION PRIOR TO BONDING, ADHESIVE MATERIAL USED PAST IT'S WORKING LIFE, ADHESIVE MATERIAL PAST ITS SHELF LIFE, OR USE OF AN ADHESIVE MATERIAL WHICH IS NOT DESIGNED FOR THE INTENDED ENVIRONMENT. AS THIS SAME TRIM IS INSTALLED ON NUMEROUS CHEVY, GMC AND CADILLAC TRUCKS AND SUV MODELS ANY CAUSE OTHER THAN THE FIRST TWO I LISTED WOULD INDICATE A PROBLEM WITH NUMEROUS VEHICLES.

AT +/-83000 MILES THE DASH DEVELOPED A CRACK LEADING INTO THE PASSENGER AIR BAG HOUSING. IT ALSO IS BROKEN AND, WHEN DRIVING, LOOSELY VIBRATING BETWEEN THE INSTRUMENT PANEL AND THE PASSENGER AIR BAG HOUSING. GIVEN THE DANGERS ASSOCIATED WITH AIR BAGS, THIS IS A CLEAR AND PRESENT DANGER TO ANYONE IN THE VEHICLE.

SERIOUS LARGE CRACKS APPEARING IN PLASTIC DASHBOARD, AROUND AIRBAG AND INSTRUMENT CLUSTER ABOVE STEERING COLUMN.

THIRD BRAKE LIGHT NOT SEALED ALLOWING THE LIGHT TO GET IN MOISTURE AND RESULT IN FAILURE OF LIGHT TO FUNCTION AS REQUIRED BY LAW. MANUFACTURING DEFECT ALLOWS THIS LIGHT TO FAIL AT ANY TIME WHICH COULD RESULT IN VEHICLE BEING HIT FROM BEHIND.

. WANT MY AIRBAGS TO WORK IF I NEED THEM. RECOVERED A LETTER IN MAIL TODAY 10/31/2017

CRACKED DASHBOARD. ABOVE INSTRUMENT CLUSTER AND ON RIGHT SIDE BY AIRBAG. VEHICLE IS NOT DRIVEN HARD OR IN 4X4 MODE. ONLY ABOUT 7500 MILES A YEAR. TREATED VERY WELL.

TOP REAR BREAK LED LIGHT . LET'S WATER AND MOISTER IN SIDE . DEALERSHIP HAS REPLACED 2 ALL READY AND 3RD ONE IS LETTING WATER IN THE LIGHT HOUSING ALL READY

I HAVE 2 CRACKS IN THE DASHBOARD OF MY 2013 AVALANCHE THAT SEEMINGLY APPEARED OVERNIGHT. MUCH LIKE THE OTHER COMPLAINTS I'VE SEEN ON THIS SITE, ONE CRACK IS AT THE TOP CORNER OF THE PASSENGER AIR BAG AND THE OTHER IS ON THE DRIVER SIDE. I'VE BEEN IN CONTACT WITH GM AND THEY'VE OFFERED TO SPLIT THE REPAIR WITH ME BUT MY RESEARCH INDICATES THIS MIGHT BE A MORE WIDE SPREAD ISSUE. OPENING THIS ISSUE TO HOPEFULLY BRING MORE AWARENESS TO THE SITUATION. VEHICLE HAS BEEN EITHER KEPT IN A GARAGE OR HAD A THICK WINDOW VISOR IN THE FRONT WINDOW SINCE I BOUGHT IT NEW.

THE DASH CRACKED OVERNIGHT. THERE ARE NOW TWO BIG CRACKS IN THE DASH OF THE VEHICLE, ONE ON PASSENGER SIDE JUST ABOVE THE AIRBAG AND ANOTHER ON THE DRIVER SIDE, JUST TO LEFT OF CENTER ABOVE THE MAIN GAUGE CLUSTER. I HAVE READ ONLINE THAT THIS IS A KNOWN ISSUE BY GENERAL MOTORS FOR THE 2013 AVALANCHE, AS WELL AS OTHER MODELS FROM THAT YEAR AND THE FEW YEARS PREVIOUS. THIS VEHICLE IS KEPT IN THE GARAGE, HAS NEVER BEEN OFF ROAD OR BEEN WRECKED IN ANY WAY. THE DASH ITSELF IS ONLY WIPED DOWN WITH A DAMP CLOTH WHEN TRUCK IS WASHED, AND NEVER HAS CHEMICALS USED ON IT. WHEN THE TRUCK IS NOT IN THE GARAGE, A SUN VISOR SHIELD IS PLACED IN THE FRONT WINDOW AT ALL TIMES. THIS IS A BIG SAFETY ISSUE, DUE TO THE FACT THAT IS COMPROMISES THE INTEGRITY OF THE AIR BAG AND ALSO CAN ALLOW FOR FLYING DEBRIS IN THE CASE OF AN ACCIDENT.