2008 CHEVROLET AVEO Complaints

The wiring to my headlights have overheated and melted twice. I found the really on the year and model of my car but wasn't on the list when I entered my vin

There was no prior warnings or notices that there was an issue. While diving on a major road with my children, smoke started coming into the cabin from the vents, and around the stereo. Luckily I was near a very vacant parking lot and immediately pulled over. I removed the kids from the car safely and did open the hood to try troubleshoot the problem. There was no smoke anywhere under the hood. Immediately after, sparks started falling from under the steering wheel to the gas pedal. Immediately after that the car was engulfed in flames. The car is currently located at my local police impound and is available for inspection upon request. From the time the smoke started to when the car was engulfed, it was approximately 5 minutes. This could have been dangerous had we been on a highway and unable to pull over and get out of the car safely within that time. It was only inspected briefly by the fire department who arrived to put out the fire and they reported it was an electrical issue that caused the fire.

The contact owns a 2008 Chevrolet Aveo. The contact stated that while driving approximately 15 MPH, the transmission became unbolted and separated from the vehicle. Additionally, the engine separated from the motor mounts rendering the vehicle undrivable. The vehicle was later towed the local mechanic. The cause of the failure was not yet determined. The local dealer was notified of the failure. The manufacturer was not notified of the failure. The failure mileage was 121,000.

The left side mount-to-mount bracket bolt broke when accelerating normally from a stop. This is one of the bolts that holds the engine to the frame. This caused my shift stick to be thrown back on every acceleration. This is an obvious safety risk. I have not yet had this problem verified or confirmed by anyone. The car seemed to drive well and normal before and up to this incident.

The contact's son owns a 2008 Chevrolet Aveo. The contact stated that while her son was driving at an undisclosed speed, the passenger's side air bag warning light was illuminated. The vehicle was taken to an independent mechanic and diagnosed that the passenger's side air bag needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was unavailable.

In-dash clock module contains the vehicle 'Check Engine Light' - required to pass inspection. Solder joints are defective ('cold' or cracked) creating intermittent electrical connections. Prevents warning of engine defects to driver. Solder defects eventually cause destruction of the module incurring unreimbursed denial of transport and expense to driver to repair.

The contact owns a 2008 Chevrolet Aveo. The contact stated that the vehicle was parked and had the headlights illuminated. The contact's wife went to start the vehicle and turned off the lights when smoke began to emit from the dashboard and the engine compartment. The contact was able to disconnect the battery and the smoke had stopped. The contact stated no warning lights were illuminated. Upon investigation, the contact associated the failure with, NHTSA Campaign Number: 14V261000 (EXTERIOR LIGHTING) however the VIN was not included. The vehicle was not diagnosed or repaired. The manufacturer was informed of failure and told the contact that they were able to assist but would not without the contact having computer access. The failure mileage was approximately 110,000.

TL* THE CONTACT OWNS A 2008 CHEVROLET AVEO. THE CONTACT STATED THAT THE VEHICLE STARTED LOSING MOTIVE POWER AND DECELERATED HOWEVER, THE VEHICLE DID NOT STALL. THE CONTACT PULLED OVER AND WAITED FOR THE VEHICLE TO REGAIN FULL POWER. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS DIAGNOSED BY AN INDEPENDENT MECHANIC HOWEVER, THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE VEHICLE WAS NOT REPAIRED. NEITHER A DEALER NOR THE MANUFACTURER WERE MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS UNKNOWN.

2008 CHEVY AVEO SEDAN - [XXX] - AIRBAG WARNING LIGHT REMAINS ON AT ALL TIMES - NO BODY CODES ARE PRESENT / DETECTED - (USING FOXWELL ELITE NT630 SCANNER WHICH CLAIMS TO READ / CLEAR AIRBAG CODES) - I'VE ALREADY RESEARCHED THIS ISSUE - "MUCHO PROBLEMOS" - WITH OVER HALF OF ALL CHEVY AVEO COMPLAINTS INCLUDING AIRBAG WARNING LIGHT REMAINS ON. IT'S MOST LIKELY EITHER THE CLOCK MODULE - WHICH PASSES THE PASSENGER SIDE AIRBAG SIGNALS TO THE MAIN SRS CONTROLLER, THE SRS CONTROLLER MODULE (LOCATED UNDER CENTER SHIFT CONSOLE AREA) OR THE PASSENGER SIDE AIRBAG ITSELF - CODE SCANNER ONLY SEES PASSENGER SIDE AIRBAG STAGE 2 - (NO STAGE 1 SEEN) ... DRIVER'S SIDE SHOWS BOTH STAGE 1 AND STAGE 2 ... ALL PRETENSIONERS ARE PROPER (2 OHMS CIRCUIT RESISTANCE) ... BATTERY STRONG / GOOD / NEW - 1 YEAR OLD - 13.5 VOLTS - I'M WORRIED DEALER (HAWTHORNE CHEVROLET - HAWTHORNE NJ) WILL ACTUALLY NOT KNOW THE EXTENSIVE ISSUE WITH CHEVY AVEO AIRBAG WARNING LIGHT COMING ON - AND WILL WRONGLY DIAGNOSE AND TRY TO CHARGE BIG BUCKS - AND PROBLEM WILL RETURN - THIS IS A SAFETY ISSUE - SINCE WITH AIRBAG WARNING LIGHT STAYING ON - SRS AIRBAG SYSTEM WILL NOT OPERATE, NO AIRBAG PROTECTION - I HAVE ALSO NOW CONTACTED CHEVROLET ON THIS SUBJECT / PROBLEM - WAITING FOR THEIR REPLY - LOCATED IN NORTHERN NJ - HAWTHORNE CHEVROLET WOULD BE THE PROPER DEALERSHIP - (I PURCHASED THE CAR THERE - 10 YEARS AGO - THEY HAVE SERVICED THE CAR FOR ROUTINE REPAIRS) ... WILL BE CONTACTING THEM ON THIS SRS AIRBAG WARNING LIGHT PROBLEM - BUT WORRIED THEY ARE NOT REALLY KNOWLEDGEABLE ON IT ... THERE SHOULD BE A RECALL ON THIS PROBLEM - SRS / AIRBAG WARNING LIGHT STAYING ON - SAFETY RELATED FAILURE - CHEVY KNOWS ABOUT THIS BY NOW FOR SURE - INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNED A 2008 CHEVROLET AVEO. WHILE DRIVING 20 MPH, SMOKE ENTERED THE CABIN OF THE VEHICLE FROM UNDER THE STEERING PANEL. THE CONTACT WAS ABLE TO SAFELY EXIT THE VEHICLE. THE FIRE DEPARTMENT WAS CALLED AND WAS ABLE TO EXTINGUISH THE FIRE. A FIRE REPORT WAS FILED. THERE WERE NO INJURIES SUSTAINED. THE VEHICLE WAS TOWED TO A SALVAGE YARD. PRIOR TO THE FIRE, THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC DUE TO AN ABNORMAL CHEMICAL ODOR IN THE VEHICLE. THE CONTACT WAS INFORMED TO LUBRICATE THE WIRES IN THE INSTRUMENT PANEL, REMOVE THE FUSES FROM THE FUSE PANEL, AND DO THE SAME WITH THE PROPER DI-ELECTRIC GREASE. THE CONTACT STATED THAT THE VEHICLE CAUGHT FIRE BEFORE PERFORMING THE LUBRICATION. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING). THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 124,000.