2021 CHEVROLET BLAZER Complaints

"Steering assist reduced" message was displayed. At the same time the temperature gauge stopped working and after I shut the car off, the motor fan ran full force for 10+ minutes. Shows no check engine light.

My 2021 Chevrolet Blazer experienced a radiator failure at approximately 42,000 miles. The radiator and cooling system malfunctioned, causing coolant loss and triggering a warning light on the instrument panel. The failed radiator is available for inspection upon request. This defect put my safety and the safety of others at risk because a compromised radiator can lead to engine overheating, sudden loss of power, or even steering assist reduction while driving. These conditions increase the likelihood of an accident, particularly at highway speeds. The problem was confirmed by my Chevrolet dealer, who diagnosed the radiator as needing replacement. They initially quoted $1,800, later reducing the cost to $915.90 after acknowledging that approximately 20 customers per month at their dealership alone are experiencing the same issue. This indicates the defect is widespread, at least regionally, and may be systemic across the model. The vehicle has been inspected by the dealer service department, which is an authorized GM representative. No police or insurance inspection has occurred. Prior to the failure, a warning lamp illuminated on the instrument panel, alerting me to a cooling system issue. This was the first symptom I noticed before bringing the vehicle in for service. I believe this premature radiator failure represents a systemic defect in the 2021 Chevrolet Blazer’s cooling system. It occurred well within the 5-year/60,000-mile warranty period, yet the dealer claimed the radiator is not covered. I am requesting NHTSA investigate this issue, as it appears to affect many owners and poses a significant safety risk.

Driving along vehicle shut down in middle of road replace fuel pump, fuel module control in August 2025. Now both top and bottom fuel hose needs replacing. On Nov 2025 I smelled gas and vehicle shut down

In September 2023, when getting my vehicle serviced for a routine oil change, I was told there was a leak in my radiator. They replaced the entire thing under warranty. On November 15th, 2025, while driving on the highway heading home from out of town with my children, an error flashed up saying “steering assist is reduced – drive with care” Upon arriving home, the fan on my car was running on high for a solid 10 minutes after turning the car off. No recall but Special Coverage N252508350 covers the thermostat replacement. Upon inspection by a mechanic, I was informed that the radiator is also leaking again in the exact same spot as it was previously. It should be noted I have never seen leaking fluid in my garage/driveway. I’ve driven less than 10,000 miles since the radiator was replaced previously. If there is a known problem with the coolant system which can cause overheating and steering assist issues, why isn't the faulty radiator and thermostat recalled. The radiator is cased in plastic to aluminum. Plastic can easily catch fire if a car overheats. The casing also prevents an owner from even knowing if there is a leak since the plastic is catching leaks - the mechanic informed me that's why I didn't know about both times it leaked. This is a 4yr old car with 46k miles, twice replaced radiator and thermostat. A recall should be issued since both problems could potentially cause a fire from an overheated engine & loss of steering assist while driving. A google search quickly showed me thousands of other Chevy Blazers from 2019-2021 with reoccurring thermostat and radiator issues. I feel unsafe driving in my vehicle but still owe too much to even trade it in for something else. I've owned dozens of vehicles in my lifetime, used and new and keep them 8-10yrs and have never had to replace a thermostat and radiator. This vehicle is dangerous due to GM/Chevy's cheap radiator model and thermostat which could overheat and catch fire

The contact owned a 2021 Chevrolet Blazer. The contact stated that while driving at 30 MPH, a 2012 Mazda CX-7, allegedly going at 70 MPH traveled through an intersection and crashed into her vehicle. The Mazda later crashed into another unknown vehicle. All the air bags deployed; however, the driver's side air bag exploded in her face. The air bag dust was in the vehicle. The contact was rendered unconscious due to the incident. All the warning lights illuminated after the crash. OnStar was activated and disabled the vehicle. There were unknown fluids leaking from the vehicle. There was no reported fire. A police report was filed. The contact sustained a severe brain injury, and medical attention was provided at the hospital. The vehicle was towed to her residence. The insurance company later towed the vehicle on a flatbed to a tow lot. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified. The vehicle was deemed a total loss by the insurance agency. The failure mileage was approximately 36,463.

Car was running fine yesterday, today does not want to start. Thought it was the battery, bought anew battery. Still wouldn't start. Rest of cat is getting great power. Code reader is reading its a fuel pump control moduler which just so happens to be in an open recall for my exact year of vehicle yet my vin number does not pop up on the GMC website under active recall. I have a 2021 chevy blazer .

Action Required "Steering Assist Warning" drive with caution, Temp gage reads cold, A/C stops working, engine cooling fan runs on high speed (even after the engine is shut off), pending P2018 code, with no Check Engine Light (CEL). Replaced Engine coolant Temperature (ECT) sensor, problem did not go away. Several reviews suggest to replace the thermostat, check fuses for proper insertion, reroute ECT wiring, and possibly replace radiator. Most of these repairs can be very expensive. Chevy Blazer Forum states that the issue is a out of range detection of ECT sensor reading. GM needs to determine a true solution and stop guessing at owner expense/frustration.

I was driving at approx 45 mph when my car lost all ability to accelerate and shut down in the street. Flashing check engine light and esc warning on the screen. It would try to start but wouldn't. I had it towed to a mechanic who diagnosed and informed me that it is the Fuel pump power control module. Upon review he I formed me that there was a recall posted in September 2025 for 2021 Blazer on this exact issue. My car has now been unusable for a week as my mechanic recommends it be repaired via recall at dealership.

I PURCHASED MY 21 CHEVY BLAZER IN 2024 AND HAD A FEW PROBLEMS WITH A TRANSMISSION PROBLEM. THE VEHICLE WOULD STOP AND JERK WHENEVER I DROVE IT. I TOOK IT TO THE DEALER A FEW TIMES FOR REPAIR. THEY CLAIMED TO HAVE FIXED THE PROBLEM, BUT IT STARTED AGAIN SEVERAL MONTHS LATER. THE VEHICLE HAS APPROX 82,000 MILES ON IT. I HEARD THAT THERE WERE SOME RECALLS ON THESE VEHICLES, BUT NOT SURE IF MINE IS ONE OF THEM. I FEEL THERE ARE OTHER VEHICLE LIKE MINE THAT HAVE THE SAME PROBLEM.

In March after a short drive, 24 miles, the car temp was pegged at Cold. After turning off the car, the fan continued to run several minutes. After a quick internet search several posts commented on a similar issue with their vehicle. Two potential issues were identified - thermostat failure or programming issue. With less than 40,000 miles on the car, I purchased a diagnostic tool. Running the tool program two errors were identified. After resetting the sensors, the problem went away. In September, yesterday and today the problem occurred again - and the error reset fixes the issue. I believe Chevy needs to fix the issue with a recall to either update programming or replace the thermostat. [Several posts state the thermostat replacement didn't fix the issue and is very expensive.]