2024 CHEVROLET BLAZER Complaints

Vehicle: 2024 Chevrolet Blazer VIN: [XXX] Component: Engine Cooling System (Radiator) Description of Incident: On XXX the vehicle was brought in for a routine maintenance service at approximately 20,000 miles. During the inspection, technicians at Hamilton Chevrolet in Warren, Michigan discovered a premature radiator leak. The servicing technician noted that this is a common failure on modern Blazers due to a manufacturing material mismatch, specifically where the plastic end tanks meet the aluminum radiator core. This structural component failure poses a severe safety risk. A rapid loss of engine coolant can cause immediate engine overheating, thermal management failure, and a sudden loss of vehicle propulsion while driving at highway speeds, significantly increasing the risk of a crash. Corrective Action: The defect was located and the radiator was subsequently replaced under the factory warranty by Hamilton Chevrolet (Warren, MI). However, this failure occurred far too early in the vehicle's lifecycle, indicating a structural or material defect in the OEM radiator seams. Please investigate this issue, as premature cooling system failures on this model year present an ongoing safety hazard. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

There was a wreck up ahead, and two tow trucks with their emergency lights flashing were blocking the left two lanes. Traffic was stop-and-go due to the existing wreck. I was traveling in the lane to the right of the tow trucks as I approached. I stopped about 1–2 car lengths behind them. When traffic started to move, I began to move forward and advanced about a car length when the automatic emergency braking (AEB) activated and slammed on the brakes, even though the path in front of me was clear. The person behind me rear-ended me. Luckily, no one was physically hurt, but there is damage to our car that now has to be repaired, along with all the headache that brings. If this had happened at higher speeds, it could have resulted in serious injuries. My family’s safety and the safety of others are definitely at risk because of this phantom braking. I would welcome an inspection of the black box and AEB. Feel free to contact me if you can facilitate this. The vehicle has not been inspected by anyone yet. There were no warning lamps or messages prior to the phantom braking. However, this has happened previously; this is the first time it resulted in a wreck. From what I’ve seen online, this appears to be a common problem, and the dealership does not have a definitive fix.

The car just stopped while I was driving. I was in an intersection. The car would not turn back on

The contact owns a 2024 Chevrolet Blazer. The contact stated that while driving at an undisclosed speed, the vehicle experienced phantom braking on four separate occasions. The Forward Collision Avoidance warning light was illuminated. The vehicle was taken to the dealer, but the cause of the failure could not be determined. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 40,000.

Sudden catastrophic drive train failure while driving. Car stopped instantly and was totally immobilized. It had to be dragged onto a flatbed tow truck. It is at dealership now for evaluation.

The radiator had a crack that nobody located even though I had been smelling antifreeze since I purchased it at 24,000 miles just over a year ago. I brought it in for an oil change today because I was leaving town for the weekend tomorrow and now a hole had blown through the bottom of the radiator. Had this happened when I was in a remote area of the mountains without cell service this could have been a very big problem. Or had it blown while traveling up the mountain pass it would have put my life and others passing me on the road at risk. There weren't any warning lights on and the car never overheated. There weren't any outward leaks up until the hole was blown in the radiator. I have had it in several times for oil changes and there were never any visible leaks noted. Luckily my engine never blew because I've been driving with a cracked radiator for at least a year now.

While driving my 2024 Chevrolet Blazer EV, the vehicle suffered a sudden, complete failure of the power braking assist system. The failure was accompanied by a rapid cascade of three sequential dashboard warning messages in immediate succession: First Warning: "Service ESC" illuminated alongside the "Brake Park" warning light. Second Warning: "Brake Assist Failure. Press Hard to Brake. Speed Limited" illuminated with "Brake Park" remaining on. Third Warning: "Brake System Failure. 62 MPH Top Speed" illuminated with "Brake Park" remaining on. Immediately upon these warnings triggering, the power braking assist and emergency mechanical reserve failed completely. When pressing the brake pedal, the vehicle did not slow down, and the pedal failed to engage the brakes. To avoid a catastrophic intersection collision and bring the vehicle to a halt, I was forced to deliberately steer the vehicle into a concrete curb to use friction to stop the car. The vehicle is a total loss of braking safety and cannot be driven. Safety Risk: The sudden loss of braking assist creates an immediate crash hazard, as stopping distances are severely multiplied. Limiting a vehicle to a maximum speed of 62 mph while experiencing zero brake assist on active roadways places the driver and surrounding traffic in extreme danger.

"While attempting to merge onto a high-speed freeway on-ramp, the vehicle suffered a sudden and catastrophic loss of engine power, rendering it unable to accelerate and creating an immediate life-threatening safety hazard. The vehicle was restarte and driven home, where an onboard diagnostic check revealed an emissions system failure. The dealership later confirmed that BOTH close-coupled catalytic converters on the 3.6L V6 were damaged. The check engine light was a solid light. Not flashing.

The contact owns a 2024 Chevrolet Blazer EV. The contact stated that while driving approximately 45 MPH and depressing the brake pedal to reduce speed, the vehicle failed to respond as intended and crashed into the rear end of a second vehicle at approximately 5 MPH. Moments later, a third vehicle crashed into the rear of the contact's vehicle. The contact was not injured during the crash. The occupant of the third vehicle sustained an unknown injury. A police report was filed. The vehicle was towed the residence and was later towed to a repair shop. The third vehicle was towed to an undisclosed location. The local dealer was not contacted. The cause of the failure was not determined. The manufacturer was notified of failure. The failure mileage was 5,500.

I am reporting a potential safety defect involving unintended automatic emergency braking/forward collision warning/brake-control behavior, reverse automatic braking, parking brake behavior, and driver-assistance/sensor calibration. Incident XXX ~11:15 AM, [XXX] driving 2024 Chevrolet Blazer EV ~20–25 mph on/near [XXX]. Vehicle displayed red collision alert and abruptly braked hard although the lane was clear; only a car was parked in a driveway on the right. Sudden braking created serious risk of rear-end collision/loss of control. Vehicle used for family transportation; toddler (~30.8 lb) had been in vehicle ~10 minutes before and family includes blind/visually impaired passenger. History of unwanted reverse emergency braking ~every 45 days: Jan 2026 near Crust Pizza Woodforest (backing up) and March 2026 at H-E-B 7988 FM 1488 Magnolia (backing out), jolting child in rear-facing car seat. Prior service at Keating Chevrolet Nov 12, 2025 (including recall/service for Unintended Parking Brake Engagement N252503010 and missing chassis harness plugs update) did not resolve unwanted braking. After June 10, AEB/front pedestrian braking/intersection collision braking were disabled as temporary safety mitigation. Vehicle removed from daily family use, available for inspection, and I request NHTSA review. Any inspection should preserve relevant braking/parking/AEB/forward collision/sensor data before any reset/update/repair. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)