2004 CHEVROLET CORVETTE Complaints

TL*THE CONTACT OWNS A 2004 CHEVROLET CORVETTE. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 5 MPH, THE STEERING WHEEL LOCKED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE STEERING COLUMN AND RELAY SWITCH WERE REPLACED. THE FAILURE OCCURRED AFTER THE PREVIOUS RECALL REPAIR UNDER NHTSA 04V060000 (STEERING:COLUMN LOCKING:ANTI-THEFT DEVICE). THE CONTACT STATED THAT THE RECALL REMEDY WAS INSUFFICIENT. THE FAILURE MILEAGE WAS 19,786.

TL*THE CONTACT OWNS A 2004 CHEVROLET CORVETTE. THE CONTACT STARTED THE IGNITION AND WHEN THE GEAR WAS SHIFTED INTO "DRIVE" THE STEERING COLUMN LOCKED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE WIRING HARNESS KIT, AND STEERING COLUMN LOCK WERE REPLACED AT THE OWNER'S EXPENSE. THE FAILURE OCCURRED AFTER A PREVIOUS REPAIR UNDER NHTSA CAMPAIGN ID NUMBER 04V060000 (STEERING: COLUMN LOCKING: ANTI-THEFT DEVICE). THE FAILURE MILEAGE WAS 1,700.

TL*THE CONTACT OWNS A 2004 CHEVROLET CORVETTE. WHILE DRIVING APPROXIMATELY 60 MPH THE VEHICLE PULLED TOWARDS THE LEFT AND A SERVICE ACTIVE HANDLING SYSTEM LIGHT ILLUMINATED ON THE DASHBOARD. THE FAILURE CONTINUED TO RECUR INTERMITTENTLY, BUT THE VEHICLE WAS NOT EXAMINED TO DETERMINE THE CAUSE OF FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 20,000 AND THE CURRENT MILEAGE WAS 21,000. THE VIN WAS UNAVAILABLE.

HAD TO HAVE THE GAS TANK REPLACED ON MY 2004 CHEVROLET CORVETTE CONVERTIBLE AT A COST OF $2600 IN SEPTEMBER OF 2009. HAVE SINCE LEARNED THAT NHTSA IS INVESTIGATING THIS. PLEASE ADD THIS TO THE LIST. *TR

ACTIVE HANDLING ENGAGES UNDER NORMAL DRIVING CONDITIONS ON MY 2004 CORVETTE. I LEARNED THAT THERE IS A RECALL FOR THIS FOR VEHICLES MFG FROM MARCH 2004 TO JAN 2006 WITH TELESCOPIC AND TILT STEERING WHEELS. MY CAR WAS MFG IN MAY 2004 AND HAS THE TILT /TELESCOPIC STEERING WHEEL. I WAS ALSO TOLD THAT THE RECALL WAS VIN SPECIFIC AND SINCE MY VIN NUMBER WAS NOT LISTED I HAD TO PAY FOR THE REPAIR WHICH COST ME $581AND CHANGE. I DON'T KNOW WHY MY CAR WITH THE SAME PROBLEM AND SAME DEFECTIVE PARTS WAS NOT COVERED. MY UNDERSTANDING IS THE HARNESS IS TO SHORT AND THE TELESCOPIC MOVEMENT CAUSE WEAR IN THE CONNECTOR WHICH CAUSES THE STEERING WHEEL SENSOR TO SHOW AN OPEN CONNECTION TELLING THE COMPUTER TO ACTIVATE THE HANDLING SYSTEM.. MY DEALER SAYS WAS MY PROBLEM AN OPEN SENSOR AND NOT THE CONNECTOR AND CLAIMS THEY DID NOT HAVE THE REPLACED PART TO PROVIDE TO ME...SINCE I TOTALLY LOST CONTROL OF MY CAR BUT WAS FORTUNATE NOT TO HAVE HAD AN ACCIDENT I PLAN ON REPORTING THIS COMPLAINT TO THE GMAC ,THE NEWSPAPERS IF NOT TO AN ATTORNEY TO PLEA THIS CASE FOR REIMBURSEMENT. I SUSPECT PEOPLE ARE BEING RIPPED OFF AND BEING CHARGED FOR A SENSOR REPLACEMENT INSTEAD OF OWNING UP TO THE CONNECTOR ISSUE... *TR

PROBLEM 1: GASOLINE SMELL WITH LEAK AND ULTIMATE FAILURE OF VALVE TO TRANSFER FUEL FROM ONE TANK TO ANOTHER. OCCURRED CONTINUALLY WITH FUEL TANK REGISTERING FULL TO 3/4 TANK THEN DROPPING TO EMPTY AND VEHICLE APPEARED TO BE OUT OF GAS (WOULD NOT RUN UNTIL FUEL ADDED TO TANK). SOLUTION: TOOK VEHICLE TO CHEVROLET DEALERSHIP FOR REPAIRS. REPAIR INVOICE STATES: "REPLACED L/S GAS TANK AND PUMP AND SENDER AND REPLACED R/S FUEL PUMP AND SENDER. CHECK FUEL GAUGE AND TANKS FOUND L/S FUEL TANK LEAKING AT TOP OF TANK. WELD ALSO FOUND FUEL LEVEL SENSORS OPEN CIRCUIT AND FUEL SYSTEM NOT TRANSFERRING FUEL FROM TANK TO TANK. RETEST AFTER REPAIRS. OK" PROBLEM 2: A/C DISPLAY LIGHTS DO NOT ILLUMINATE AND CONTROLS ARE DIFFICULT TO SEE AT NIGHT. SOLUTION: TOOK TO CHEVROLET DEALERSHIP FOR REPAIRS. REPAIR INVOICE STATES: "CONTROLLER HAS INTERNAL FAILURE, REPLACED CONTROLLER." *TR

2004 CHEVROLET CORVETTE: THIS PROBLEM BECAME EVIDENT AFTER A STRONG GASOLINE ODOR AND GASOLINE VAPORS BEGAN TO BE NOTICEABLE IN THE PASSENGER CABIN. NOW GAS HAS BEEN DETECTED LEAKING FROM UNDER DRIVER SIDE SEAT. AFTER RESEARCHING THE ISSUE ON THE INTERNET IT IS CLEAR THIS IS WIDE SPREAD PROBLEM WITH THE POSSIBILITY OF FIRE AND OR ENVIRONMENTAL DAMAGE. THE CAR WAS PURCHASED USED ONE YEAR AGO. NOTHING HAS BEEN DONE YET TO CORRECT THE PROBLEM DUE TO LACK OF FUNDS TO HAVE THE DEALER ADDRESS THE ISSUE. MOST INFORMATION I HAVE SEEN PLACE THE REPAIR AT AROUND $2,000.00. *TR

2004 CHEVROLET CORVETTE BEGAN LEAKING FUEL AFTER 5K MILES. DEALER SAID IT WAS A FAULTY FUEL TANK AND CROSSOVER TUBE BETWEEN THE TWO PARTS OF THE TANK. $1400 TO REPLACE FUEL TANK. THE CAR COULD HAVE BURNED TO THE GROUND, THERE WAS FUEL RUNNING EVERYWHERE AT THE GAS STATION! *TR

TL*THE CONTACT OWNS A 2004 CHEVROLET CORVETTE. WHILE THE VEHICLE WAS PARKED IN THE GARAGE THE CONTACT SMELLED A STRONG FUEL ODOR. HE REPLACED THE GASOLINE CAP, WASHED THE VEHICLE BUT COULD STILL SMELL FUEL. THE VEHICLE WAS TAKEN TO A MECHANIC WHO DIAGNOSED THE FAILURE AND CONFIRMED THAT THE FUEL TANK PIPE CONNECTORS WERE DEFECTIVE. THE FUEL TANK CONNECTORS COULD NOT BE REPLACED; THEREFORE, THE FUEL TANK HAD TO BE REPLACED. THE VEHICLE WASN'T REPAIRED. THE FAILURE MILEAGE WAS 35,400 AND THE CURRENT MILEAGE WAS 36,100.

04 CORVETTE ZO6 LEAKING FUEL WHEN I FILLED IT. I HAVE BEEN SMELLING FUEL FOR A WHILE NOW AND I GUESS THIS WHY. IT SEEMS WHEN I WAS ALMOST DONE FILLING IT UP IT STARTED DRIPPING FUEL ON THE GROUND IN FRONT OF THE L/R TIRE. TOOK IT TO DEALER NO RESULTS YET. *TR